The axle bearing of a 1998 electric Club Car rear axle houses a retainer nut that is located inside the axle tube. This is often a C-clip and keeps the axle in position inside the tube. This C-clip or retainer nut can be accessed only using a pair of 90-degree C-clip pliers.
Full Answer
How to replace the axle on a golf cart?
Loosen the nut present on the axle at the end. Raise the rear end of the cart and place it on the jack stand. Take off the rear wheel followed by the brake hub. Check where the axle is positioned at the rear end. You’ll also notice the C-clip just before the axle bearing.
How do you remove the rear axle on a club car?
You can remove the rear axle of a Club Car golf cart by taking off the snap ring that is located behind the hub. Remove the rear wheel of the golf cart. Take off the brake drum from its place. Insert a 90-degree snap ring pliers through the holes in the hub and remove the snap ring.
What are the parts of a club car golf cart?
Rear End, Axles & Parts for Club Car Golf Carts. Axels, Bearings, Differential Parts, Transmission Parts. 3829 Input shaft bearing. For Club Car gas 2000-up DS 3829 Input shaft bearing. For Club Car gas 2000-up DS
How to jack up a golf cart?
Chock the front wheels of the Club Car to prevent it from moving. Loosen the lug nuts present at the back of the golf cart. Loosen the nut present on the axle at the end. Raise the rear end of the cart and place it on the jack stand. Take off the rear wheel followed by the brake hub. Check where the axle is positioned at the rear end.
What are the components of a golf cart?
These include components such as tires, which are made out of rubber; seat cushions, which typically consist of foam cushion covered by vinyl; steering mechanisms, made of metal; and motors, brakes, batteries, transaxles, suspensions, drive trains, and electrical cables.
How do you remove the rear axle on a EZ Go golf cart?
1:592:59How to Remove an E-Z-GO TXT Front and Rear Axle - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe first step is to remove the rear pin from the brake cable once this is done remove the c-clipMoreThe first step is to remove the rear pin from the brake cable once this is done remove the c-clip and slide the brake cable from the assembly.
What is a rear differential on golf cart?
A golf cart rear axle, often referred to a differential, helps propel your Yamaha G1, G2, G8, G9, G14, G16, G19, G22, and G29 the drive gas or electric golf cart. A differential slows the rotational speed of your clutch or electric motor before it hits the rear wheels.
How do you remove the rear axle on a Club Car golf cart?
How do I remove the rear axle on a Club Car golf cart?Remove the rear wheel of the golf cart.Take off the brake drum from its place.Insert a 90-degree snap ring pliers through the holes in the hub and remove the snap ring.Slide the axle out of its position.
Why do golf carts wobble?
Check whether the tire is properly seated and also check for proper wheel alignment. Sometimes if the wheel alignment is not proper, it could make the cart wobble. The lug nuts and hubs in the wheel could also cause this problem. If one of the hubs is missing or bent at an odd angle, the cart could wobble.
How much does it cost to replace a rear axle?
The rear axle is usually more expensive to repair or replace. It can cost anywhere from $450 to over $1,000 for the rear axle, but most people pay between $600 – $900.
Do golf carts have a differential?
The differential transmits torque to the golf cart wheels and allows them to turn at different speeds, especially on turns and curves.
What is a differential on a golf cart?
Maintaining your golf cart's differential and transmission is essential to your vehicle's performance and longevity. Your differential transmits torque to the Club Car wheels and allows them to turn at different speeds.
Does a Go Kart need a differential?
Karts do not have a differential. The lack of a differential means that one rear tire must slide while cornering. This is achieved by designing the chassis so that the inside rear tire lifts up slightly when the kart turns the corner.