
This is a common problem that occurs from leaks in a golf cart's battery. The Army Corps of Engineers has been purchasing the Concrete Rust Remover for this problem for the last ten years. They use it to remove the acid stains left by the golf carts that they use to taxi up and down the locks and dams.
Full Answer
Why is my golf cart blowing white smoke?
Excessive amounts of white smoke might mean there’s a problem with your cooling system. One reason your cart might be blowing out white smoke is that there might be some water in your golf carts system. You should give your carburetor a good cleaning and drain your fuel tank to try and fix this problem.
Are your golf cart batteries leaking acid?
If you own a golf cart, chances are, the batteries have leaked acid onto the floor of your garage or patio at some point in the past. This can be an alarming sight, particularly if it’s your first time encountering battery acid. Thankfully, this is a relatively common error, and is an easy one to avoid.
Why is my golf cart stalling?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
How do I avoid golf cart battery spillage?
The key to avoiding golf cart battery spillage is simple: avoid over-watering your golf cart batteries. Watering batteries is the act of replacing water that naturally evaporates from within the battery casing, either due to excessive heat or daily use.

What is leaking from my electric golf cart?
Battery leakages are the result of over-watering a battery. One of the most common mistakes golf cart owners make is watering a discharged battery during the summer season. When batteries are fully charged, the water is warmer, and the liquid levels are higher, because the acid is drawn out of the plates.
How do you get battery acid off concrete floor?
Pour chlorine bleach into a spray bottle. Spray affected area until completely covered and let it set for a five minutes. Scrub battery acid stains with a hard bristle brush. If the stain remains, spray on another application of bleach and let it set longer.
How do you clean battery acid stains?
Steps to Remove the Stain:Mix the baking soda with a small amount of water to form a paste.Spread the paste over the stained area and allow it to set for at least two hours.Wash the sheets as normal with laundry detergent. ... Allow the sheets to air dry until you are sure the stain is completely removed.More items...
How do I protect my garage floor from battery acid?
The Shield Family Floor Protector is an Ultra Light Weight, Multi-layered, protective barrier made from high tech materials. It will protect your garage or shop floor from messy petrochemicals, battery acid, harsh cleaners, coolant, oil, gasoline, other fluids and all dirt and grime.
How do you remove acid stains?
Step 1: If the acid stains are fresh or recent, take a generous amount of baking soda to sprinkle over the stain. Whereas if the acid stain is old, you can make a thick consistency paste of baking soda with water and apply it on the stain to cover the whole area. Step 2: Wipe it off after a few minutes with a cloth.
How do you fix acid etched concrete?
0:2013:50How to Repair Concrete Cracks plus the Science of Muriatic AcidYouTubeStart of suggested clipEnd of suggested clipIt's going to remove dirt and grease. And get everything looking good before we add the bondingMoreIt's going to remove dirt and grease. And get everything looking good before we add the bonding agent. And then the concrete. Mix. We also want to make sure we get any of the loose gravel out of.
How do you remove Sulphuric acid stains?
Pour a generous amount of baking soda over the sulfuric acid spill and the few inches surrounding it. ... Sponge the baking soda solution and neutralized sulfuric acid up once it stops bubbling. ... Scrub the area with a scrub brush and clear water.More items...
What does battery acid do to concrete?
Battery acid is a mixture of sulfuric acid and water. When the mixture comes in contact with concrete it may react with the components in the hardened Portland Cement or in the aggregate. If this happens, surface deterioration will probably be visible.
How do you get rid of distilled water stains?
Vinegar. Vinegar is a safe, all-natural household cleaner with the amazing ability to combat hard water stains. Pour some in a spray bottle and squirt any surface where you find hard water stains. Let it sit for five to 15 minutes to give the vinegar time to break down the minerals in the chalky, white stain.
What neutralizes battery acid spill?
Neutralize spilled or splashed sulfuric acid solution with a baking soda (sodium bicarbonate) solution, and rinse the spill area with clean water.
Does battery acid eat through wood?
Battery acid eats through the finish and damages the wood. Wood floors are beautiful additions to any room in a home. One of the worst things that can happen to a wood floor is damage from a battery acid spill. This eats through the protective finish and damages the wood fibers beneath.
What protects against battery acid?
Wear personal protective equipment, including splash-proof goggles, gloves and aprons. Other PPE, such as a faceshield (with safety goggles), may be necessary depending on the situation. Practice extreme caution when pouring concentrated acid to avoid spills or splashes – it can damage clothing and cause serious burns.
Will battery acid eat concrete?
Normally, concrete is a hardy material that's tough to damage, but the acid leaking from car and machinery batteries is actually a mixture of water and sulfuric acid, which can be very dangerous. Acids attack components in the concrete and can cause not just staining, but physical damage to the surface as well.
Does vinegar neutralize battery acid?
For alkaline batteries, a mild household acid solution can be effective. Mix vinegar and lemon juice and swab that onto the battery and/or spill with a cotton swab, which will neutralize the acid. A toothbrush can also be used to clean the spill if dealing with delicate internal workings of an electronic device.
Does baking soda neutralize battery acid?
The baking soda will react by bubbling up quite ferociously for a couple seconds. The reaction between the baking soda and water mixture and the acidic corrosion on the battery terminals will neutralize the acid, making it safe to handle.
What is the best rust remover for concrete?
If you need to get rid of rust from concrete, your best bet is to use some WD-40 Multi-Use Product, and some elbow grease. WD-40 is specially formulated to be a penetrant, so when you spray it on a rusted surface, it gets to work right away by getting under the rust.
How To Clean Dirty Golf Cart Seats?
Dirt can find its way onto your golf cart seats in a number of ways. As you drive through mucky off-road areas or puddles, dirt will inevitably splash up onto your seats. You might also accidentally transfer dirt from your clothes onto your seats.
How To Keep Your Golf Cart Seats Clean?
Now that you’ve got your golf cart seats looking spick and span, you’re probably wondering how you can keep them that way so that you don’t have to clean them again anytime soon.
How to get a dirty cart seat off?
You’ll need: Fill one bucket with warm water and a splash of dish soap. Stir to activate the soap suds. Get your sponge or cloth nice and soapy, and then wring it out a bit. Start scrubbing your seats.
How to get mildew off of car seats?
With the entire seat sufficiently scrubbed with soap, it’s time to rinse it off. Fill your other bucket with warm water – without soap. Dip your other sponge into it, wring it out, and use it to get rid of all the soap on your seat. Try not to use too much water, as it could end up seeping through the seats which would result in mildew.
How to clean a car seat that won't fit?
For the particularly dirty areas, you may need to scrub a little harder. Use an old toothbrush to get into the seams where the sponge won’t fit. With the entire seat sufficiently scrubbed with soap, it’s time to rinse it off.
How long does it take for mildew to go away from a car seat?
Leave it to set for 5-10 minutes. Most of the mildew should have disappeared simply by spraying it. After enough time has passed, and you’re satisfied that the mildew has been removed, you can rinse off your seats with fresh water. Then pat dry with a towel.
How to get a stain out of a car seat?
There are a few different ways of tackling tough stains, but we suggest grabbing a bottle of rubbing alcohol. Apply it to a plain white cloth (avoid colored cloths, as these could stain your seat), and gently rub it on the affected area until the stain is gone.
How to clean battery acid from floor?
To clean your floor from battery acid, you will want to use an alkalizing cleaner that will neutralize the acid. Baking soda can be used in this case. If it is a small spill, you can simply pour the baking soda over the acid and allow some time for it to neutralize the acidic liquid.
What to do if battery acid spills on floor?
If you have battery acid that has spilled onto your floor, you will want to clean it up as soon as possible. First and foremost, before you touch anything that has to do with battery acid, you will want to take precautions and make sure you are wearing safety gear.
What happens if you don't clean your concrete floor?
If you do not clean it up, you may end up with a damaged area on your concrete floor similar to the one that I had on my floor.
Do golf cart batteries leak?
Under normal circumstances, properly functioning golf cart batteries will not leak. These batteries generally leak when they are filled with water before they are fully charged. When they are filled with water when cold, the water will heat up and expand as they are charged.
Can you refill golf cart batteries after they are fully charged?
Here are a few tips that will help you prevent your batteries from leaking onto your garage floor. Only refill your batteries after they are fully charged.
Can electric golf carts overflow?
If you have an electric golf cart, you may be aware of the overflow that can occur if you do not maintain your batteries properly. This overflow can be very damaging to concrete or other surfaces that you may park your golf cart on. When I first purchased my electric golf cart, the salesman from the place I purchased it from told me how ...
Can you disconnect a golf cart battery?
Disconnect your golf cart from the battery when not in use. I leave my golf cart unplugged at all times unless it’s time for a recharge.
The Issue
Virtually all golf carts run on battery. When these batteries are over-charged, over-filled, or left uncapped, they’ll begin to leak. The unwilling recipient? Your concrete garage floor or driveway.
The Solution
Eco Friendly Power Washing uses an F9 removal process to attend to your stained concrete.
Battery Acid Removal Before & Afters
In Palm Desert, tee time is the best time. Eco Friendly Power Washing is proud to offer professional battery stain removal that will prevent costly repairs, enhance curb appeal, and keep the beautiful region that we call home safe and healthy.
Why does my golf cart spit?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Why Does a Golf Cart Sputter and Die?
If your cart sputters and dies, it might be because your spark plug is faulty. If your cart starts and runs for awhile but then sputters then dies, try replacing your spark plug. If you’re lucky that’ll instantly solve your problem. If not, you might have a failing ignition coil.
Why Do Golf Carts Blow Out Smoke?
Your cart shouldn’t blow out a lot of smoke. It should run quite clearly without much smoke if your cart has been serviced regularly and maintained well . Older carts tend to release more smoke than newer ones though.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
What to do if your golf cart is spitting gas?
Lastly, if your golf cart is spitting gas, you may need to replace your air box. A relatively common problem is getting replacements that aren’t the stock air box for your cart. Something that most people don’t know or forget about is that if you’re using aftermarket filters, you absolutely must reset your carburetor.
How to check oil in a car?
First things to check is that you have the correct amount of oil in your engine as you might be overfilling it. Check it using the dipstick in your cart. If your cart has been lifted though, you can’t go by the full mark on the dipstick. You’ll need to use the specified amount of oil for a refill in that case.
