Full Answer
Why are my golf cart’s lights not working?
Your golf cart’s lights may prove faulty for a variety of other reasons. Common issues with a golf cart’s lighting system can range from a blown-out fuse to a faulty lighting switch. In general, most golf carts are equipped with headlights but no tail lights.
Why won't my golf cart move in both directions?
If the cart doesn't move in either direction, both switches have failed. Diagnosing a problem with the direction switches isn't a complicated matter, but repairing the switch is more complex, especially if the switches are built into the speed controller.
Why do golf carts have tail lights?
Tail lights are quite handy if you do a lot of driving in your golf cart at night. They help inform other vehicles about where you’re on the golf course to avoid accidentally bumping into each other. Some golf carts make use of halogen bulbs but these lights are more expensive.
What causes a golf cart ignition to go bad?
3. Issues With the Ignition If your ignition has problems, it's almost certainly due to wear and tear or the age of your golf cart. Wires can become loose and lose the connection between the switch and the battery, or they may require replacement when they wear out or break over time.
What would make a golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Where is the reset button on a golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
How do I know if my golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
Do all golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How do you know if your club car motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Where are the fuses on a Club Car golf cart?
In a 1997 Club Car, the fuse is located in the electrical components black box that is present near the battery. On the other hand, in a 2005 Club Car Precedent, the fuse is connected to a blue wire under the golf cart seat.
What are symptoms of bad solenoid?
As a result, the common signs of a bad starter solenoid include:Engine Doesn't Crank or Start. ... No Clicking Noise When Trying to Start the Engine. ... Starter Spins Without Fully Engaging the Flywheel (Rare) ... Engine Cranks Slowly (Rare) ... Test the battery. ... Check That Power is Getting to the Starter Solenoid.More items...•
What happens when a solenoid fails?
A faulty starter solenoid can exhibit several symptoms, including these: Engine doesn't crank: This is a result of the starter solenoid failing to deliver power to the starter motor. No clicking sound: This can mean either a faulty starter solenoid or starter relay.
How do you know if its the starter or solenoid?
Let someone turn on the ignition key or press the starter button. Observe the light — if it doesn't turn on, the solenoid is likely failing to transfer power and might need replacement. However, if the light turns on but there's no clicking sound or starter engagement, the issue lies with the car starter.
How do you diagnose a golf cart problem?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do I reset my golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Why did my golf cart stop working?
When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
Why won't my golf cart start?
Like any other electric vehicle, the batteries are mainly at the root of why your cart won't start. After all, they are the primary source of power for your electric golf cart. If your cart is not working, this is the first place to check. Generally, lead acid-based batteries are used for electric golf carts, and you must recharge them regularly so that they function correctly.
What is a direction switch on a golf cart?
The direction switch or forward/reverse switch controls whether the golf cart moves forward or backward. This switch is one of the most used parts in a golf cart, which means it will be subject to wear and tear. You'll find what the issue is if the switch is acting up. There is a big chance that it will need to be replaced. Again, it's best to choose a mechanic for repair.
Why won't my electric golf cart start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won’t start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Why does my golf cart make a clicking noise?
The solenoid is a critical component of your golf cart because it is the main switch that connects the current from the battery to the traction motor. That clicking noise that you hear when you press the gas pedal is the solenoid.
What is the best way to check if a golf cart battery is charging?
A Battery Hydrometer: A battery hydrometer measures the specific gravity of the electrolyte solution and can indicate whether or not your batteries are charging correctly. This method is inexpensive and reliable, making it a popular choice for golf cart owners.
How to reduce golf cart issues?
However, the best way to reduce your chances of golf cart issues, later on, is by performing regular preventative maintenance. With preventative maintenance, you can extend the life of your golf cart and potentially save money in the long run.
How to test golf cart batteries?
Another method to test your batteries is by using a load tester. Battery load testers can come in a variety of different price ranges. They give golf cart owners the ability to monitor their battery’s voltage to see how much the volt drops during testing, which indicates the health of the batteries.
How to check if a battery is charged?
Make sure your batteries are fully charged, first, and then check for the following: 1 Any cracks or dirt in the batteries. 2 The water-electrolyte levels (on a weekly basis). If the water runs too low, it can shorten the life of your batteries. Overfilling can also result in a loss of electrolytes. 3 Look for signs of corrosion on your connectors and ensure that they are tight. 4 Dirt and other debris can affect the performance of your batteries. Clean them regularly with a bristle brush, water, and baking soda, but take care not to get any of the electrical components wet.
Can you prevent problems with a golf cart?
While some problems are simply bad luck, many issues with your golf cart can be avoided through simple preventative maintenance. By keeping your golf cart in good condition, you can extend its life and save yourself tons of money in the process.
Why aren't my golf cart lights working?
The main reasons golf cart head lights don’t work are blown out bulbs, dead battery’s, faulty wiring, bad headlight switch, bad voltage reducer or a blown fuse. These are all easy to troubleshoot, and very easy to fix. Your golf cart’s lights may prove faulty for a variety of other reasons.
What causes a golf cart to not light up?
Troubleshooting Your Golf Cart’s Faulty Headlights. 1. Blown Fuse on your Golf Cart Headlights. Problems with a golf cart’s headlights are commonly linked to a blown-out headlight fuse. A blown headlight fuse will cause your vehicle’s headlights to not receive the power necessary for them to produce light.
Why do my golf cart headlights stop working?
The third reason for a golf cart’s headlights to stop working is a faulty headlight switch. Sometimes this switch will not receive enough current causing the switch to fail. When this switch fails there is no way for the golf cart operator to activate the vehicle’s headlights.
How many terminals do you need to connect your golf cart headlights to?
These wiring for a cart’s headlights should only be connected to two battery terminals; any additional connections will cause the headlights to blow immediately. In order to check your golf cart’s circuit wiring you should refer to the wiring diagram included in your golf cart’s user manual.
What is the lighting system on a golf cart?
Your golf cart’s lighting system is composed of various parts. Each of these parts works together to produce a working electrical circuit that provides a current to your vehicle’s headlights and brake lights (if your vehicle is equipped with them). The most obvious parts of your vehicle’s lighting system are the headlight and brake light bulbs. These parts of the system are responsible for producing light. In addition to the actual bulbs, the lighting system is also composed of fuses and the lighting switch.
What is the difference between headlights and brake lights?
The actual part that produces light for the vehicle. Similar to car or truck lighting, headlights on a golf cart produce yellow or white light, where as brake lights are colored red. Electrical Circuit. The system of wires, fuses, and resistors that produces a stable electrical system.
What are the parts of a vehicle's lighting system?
The most obvious parts of your vehicle’s lighting system are the headlight and brake light bulbs. These parts of the system are responsible for producing light. In addition to the actual bulbs, the lighting system is also composed of fuses and the lighting switch.
What is the warning light on a golf cart?
The warning light on an electric golf cart is the battery light . True to its name, this light gets illuminated to warn you of a low battery or low batteries. It serves as a signal for you that it’s time for battery recharge.
Why does my golf cart light flash red?
The light, usually red, starts flashing when the battery has got less than 10 percent charge left, in an electric golf cart or less than 10 percent fuel in a gasoline-powered golf cart. The golf cart has several other warning lights. For example, there is a warning light to indicate if there is any problem with the engine of your cart.
What happens if your golf cart battery is low?
Weak Battery Voltage. One or more of your golf cart batteries are likely to have a low voltage. This can stop the batteries from being able to pick up charge. Check the voltage of each battery separately. When you find a battery with a low charge, try charging it to its full voltage using a smaller auto charger.
What is a golf cart battery light?
A golf cart’s battery light is undoubtedly an indispensable accessory of any battery-operated golf cart. This light notifies you when your golf cart battery or batteries are low on charge. It saves you the hassle of worrying whether you would be stranded because of a drained battery.
Why is my battery light flashing?
One reason why your battery light is flashing could be because the batteries are not getting a full charge from the charger. The flashing indicates that the charging is less than 90 percent.
Why do my batteries flash?
A mistake in the installation of batteries can cause flash ing battery lights. This can be something like a wrong polarity connection. Analyze how your battery connections have been made. One or more batteries have likely been connected in the reverse order.
What to do if there is no power supply?
If there is no power supply between one or more wire connections involving the headlight, use a voltmeter and check if there is power going through all the wires connected to the headlights .
Why won't my electric golf cart start?
Today, we'll look at the most common problems with electric golf carts, and how you can prevent or repair them. 1. Batteries That Break Down or Lose Charge. If your golf cart won't start, the first thing we suggest it checking your battery! Electric golf cart batteries need to be charged and have water added regularly.
Why is my golf cart ignition not working?
If your ignition has problems, it's almost certainly due to wear and tear or the age of your golf cart. Wires can become loose and lose the connection between the switch and the battery, or they may require replacement when they wear out or break over time.
What is the solenoid on a golf cart?
The solenoid is a cylindrical coil of wire that works as the magnet carrying an electric current. Basically, when you start up your golf cart, the solenoid is the reason for the clicking sound you hear when engaging the acceleration pedal. This sound is a good thing!
What is a direction switch on a golf cart?
Direction Switch. The direction switch simply lets you control whether your golf cart is in forward or reverse. One of the most frequently used parts on a golf cart, it's heavily prone to wear and tear and breaking down over time.
Do electric golf carts run quietly?
They generally run more quietly than gasoline-powered golf carts and ATVs do, and keeping them moving is as simple as keeping up with preventative maintenance and maintaining a full charge. However, electric golf carts do have their share of unique concerns and potential issues that you'll want to keep an eye out for.
Do you need to replace a golf cart battery?
If you purchase a preowned electric golf cart, be sure to ask about the age of the battery before you buy. You may not need to replace your battery for a long time, but the older a golf cart is, the more prone it may be to corrosion.
Why do electric golf carts fail?
These carts can start to show signs of wear and may fail just like any other vehicle over time.
What are the problems with electric golf carts?
These carts can start to show signs of wear and may fail just like any other vehicle over time. Learn about some of the more common issues associated with electric golf carts. 1. Solenoid Wear. The solenoid is the primary electrical switch in your golf cart and is designed to ensure the current from the battery flows into the motor. ...
What is the controller on a golf cart?
An electric golf carts' controller is known as the heart of the operation and closely resembles and operates much like the motherboard in a computer. So a problem with the controller will have rippling effects throughout the cart. A common function of the speed controller is to control the speed of the golf cart.
Why does my gas cart not work?
When you press down on the gas pedal and hear a tapping-like sound, this is the sound of the solenoid activating. When there is a disruption in the flow of the electrical current , your cart will not operate. A common reason for current disruption is solenoid wear.
What happens if your cart doesn't move?
If the cart doesn't move in either direction, both switches have failed. Diagnosing a problem with the direction switches isn't a complicated matter, but repairing the switch is more complex, especially if the switches are built into the speed controller.
Why won't my sped controller accelerate?
Problems with the sped controller occur for a variety of reasons, but most often the cause is degradation due to age or lack of use.
How to reset a golf cart motor?
Reset the motor. Remove a panel in the rear of the golf cart using a screwdriver. When the motor is exposed, search for a small red button. Most often, the button is located where the wires enter the motor. If the button is sticking out, push it back in.
What to do if battery terminals are dirty?
If the terminals are dirty, purchase a battery terminal cleaner spray and use it on the terminals then try to start the motor. The cleaner spray is available at auto retail shops and in most automotive sections of chain retail stores.
Why does my golf cart keep turning but not starting?
Solenoid problems: A solenoid can wear out after using your golf cart regularly. A faulty solenoid can cause your golf cart to turnover but not start. Your golf cart solenoid is a coil of wire cylindrical in shape, but in reality it functions as magnet carrying electricity.
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
What to do if golf cart doesn't start?
If you find any moisture, you have to replace the plug. If the golf cart doesn’t start, you will want to clean the carburetor with some cleaning fluid. You can also take a look at the fuel bowl to check if it’s empty. If not, open and drain it.
Can a Yamaha G2 golf cart start?
Yamaha G2 golf cart turning over but not starting. A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark.