The light, usually red, starts flashing when the battery has got less than 10 percent charge left, in an electric golf cart or less than 10 percent fuel in a gasoline-powered golf cart. The golf cart has several other warning lights. For example, there is a warning light to indicate if there is any problem with the engine of your cart.
Full Answer
What are the lights on a golf cart called?
Similar to car or truck lighting, headlights on a golf cart produce yellow or white light, whereas brake lights are colored red. The system of wires, fuses, and resistors that produces a stable electrical system. This circuit provides power to a majority of your cart’s electrical functions.
How do I find out what model my Yamaha golf cart is?
Step 1: Serial Number Lookup on Your Yamaha Golf Cart: It is likely located: Under the rear bumper on the frame; or; Under the seat where the floor board meets the motor compartment; or; Under driver side glove box . Step 2: Match the serial number to the table below to determine the model and year of your Yamaha golf cart.
How do I tell what year my Yamaha g5eh is?
If your serial number begins with "J51-2" then you have a 1992 Yamaha G5EH (Sun Classic). Need a new golf cart charger? Here are some links:
Why is my golf cart battery light flashing?
If the batteries of your golf cart are quite old, then there is a chance that the charge will not come on and trigger a flashing battery light. This typically happens if you have used the batteries for quite a few years. The best solution, in this case, is to replace the old batteries with a set of new ones.
Where to find the year of a Yamaha golf cart?
Usually found under the seat, under the driver side glove box area or on the chassis towards the rear of the golf cart. Under the bumper area usually.
Where to find serial number on G1 golf cart?
You can find the serial number under the golf cart towards the drivers side rear wheel.
What is a G11A?
The Hauler or G11 was a limited production utility vehicle Yamaha used to test the market to see if they could fulfill the need for commercial customers abroad not planning on playing golf. You can look under the seat towards the rear of the cart to find the serial number. Serial Number.
Where is the serial number on a G3?
The G3 was short lived and soon to be replaced by the G5. You can find the serial number on the G3 under the cart towards the rear passenger side tire.
When was the Sun Classic introduced?
The Sun Classic was introduced in 1990 and with little applause. Still had the goofy roof like a squished George Jetson car but without the weird running lights from the G3. Finding the serial number on these is a breeze simply look under the front on the frame rails.
Anonymous
I had this same problem on a 1995 Lincoln Towncar -- thought I might have to replace the Signal Switch - then it was suggested to check the ground for this wiring. However I was told to check the HAZARD SWITCH. The Hazard Switch was not On or Off it was stuck in the middle. Simply pushing it up and down correct the problem.
Anonymous
try checking the brake light switch attached to the brake pedal,very common problem. has about 5 contacts in it ,they all operate different things. If you have a scan tool with live data readings you can watch them all. also check fuses and bulbs ,but you say the signals work so that seems ok.
Anonymous
Replace the turn signal switch. If you want to prove this have someone stand behind the car with your foot on the brake. Then wiggle the turn signal lever. The brake lights should blink. This is a real common problem with W body. I have replaced two on my cutlass plus tons more at my shop.
E-Z-GO Golf Cart Brake Shoes - Genuine E-Z-GO Parts and Accessories
https://shop.ezgo.com > Shop > Parts > Brake Parts > Brake ShoesOEM Golf Cart Brake Shoe 4084 ' Single Shoe. Fits 1996 -current E-Z-GO Golf Car and Utility Gas & Electric Vehicles. Item #: 648037. $24.70/ea. Spring- Shoe Return- LH (Blue).
Everlasting turn signal flasher or relay location on a club car
Turn signals have never been a factory option on any standard carts. Only on models like the villager 8 passenger. Most likely behind the dash.
I need a wiring diagram for a Yamaha G22R Golf Cart
I am sorry but this is the wrong category and we have no wiring diagrams as they are copyrighted material by the manufacturer.
1982 e-z go electric golf cart needteck sheet
I have a 96 EZ GO gas golf cart with loose steering. What parts are normally needed to correct this problem and are special tools required for me to replace the parts.
Why is my Yamaha golf cart controller so hot?
The primary reason why a Yamaha golf cart controller gets too hot is because of overuse. When the golf cart is used for long periods of time, the controller can start overheating. The driving surface might also be a cause of heating. If driving on a straight and soft surface, the problem of heating should not occur.
How to test Yamaha G16?
To test the Yamaha g16’s speed controller, check the voltage reading while pressing the accelerator. Test other components such as the batteries, the charger, and the solenoid for their smooth functioning. If any of these components do not work as expected, then you need to replace them.
What to do if your golf cart controller does not increase?
If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead. If dead, replace them. Examine the controller, as discussed in the previous sections. Remember to always consult a mechanic to have your golf cart controller repaired.
What are the problems with a Yamaha G22?
Yamaha G22 also faces similar problems like G9 and G16. Overheating, battery faults, wiring issues, voltage issues are some problems that might occur with your Yamaha G22. To avoid these problems, test the golf cart’s major components connected to the controller regularly.
Why is it important to troubleshoot a golf cart controller?
Troubleshooting the controller is extremely important for the golf cart’s smooth functioning. Generally, controllers face major issues only when there is a problem with wires or defects on the controller itself, such as marks or cracks.
How to troubleshoot a G9 controller?
Here are some easy steps for troubleshooting the G9 controller: Check the controller’s body to locate any major defects such as cracks, scratches, or black marks. If these are found, then replace the controller immediately. If no major defects are found, then check the wiring.
Why is my golf cart not heating?
If driving on a straight and soft surface, the problem of heating should not occur. But, if driven on uneven or steep surfaces , there are chances of heating. Another reason could be the brakes. It is essential to check if the brakes are dragging while the golf cart controller is driven.
What happens if you don't hook up a golf cart?
If you own a 48V or 36V golf cart, and if you do not install or properly hook up a voltage reducer, you will put too much voltage through your lights, resulting in blown lights (and generally voiding all warranties - see blown board image below).
How many volts does a golf cart take?
Even the most basic voltage reducer will do the job, taking 16,18, 36 or 48 volts down to 12. Check out Golf Cart Voltage Reducers for more information.
Why are my lights blown out?
If the voltage reducer was hooked up improperly, the lights may have been blown out due to over-voltage. What you will need to do is check what voltage your cart is running at. Because all electrical accessories run on 12V, and the reducer's job is to take higher voltages down to 12V.
What to do before taking a golf cart out on the street?
The cardinal rule before taking your golf cart out on the street, EVEN WITH the proper lighting/indicators is: CHECK YOUR LOCAL LAWS. Laws and rules are constantly changing, so before taking your golf cart out on the roads, ALWAYS check with your local municipality.
Do you have to engage the parking brake on a gas golf cart?
Yes. If you have a gas golf cart, you will need to engage the parking brake prior to installation. This ensures that your golf cart stays put while you’re working on it. I’ve hooked up the light kit and voltage reducer, but some of the lights are not coming on or came on for a minute and went off.
Should a golf cart be in the TOW position?
Your golf cart should always be in the TOW position when installing electrical accessories such as lights. I want to upgrade my headlights and taillights and already have the holes/cut-outs where the lights should go on my cart.
Why is my golf cart not clicking?
This insulated wire channels the electric current from the battery that powers the cart. If you press on the cart's accelerator and do not hear a clicking sound, the solenoid wires may need tightening.
What does a Yamaha cart run on?
Yamaha carts run on electricity generated by an acid-based rechargeable battery and most problems can be traced to this source. If your cart is sluggish or won't start, the battery may need to be charged. If it is charged, but still not working properly, make sure the battery terminal connections are clean and secure.
Do Yamaha golf carts need maintenance?
Yamaha golf carts, like any other machine, will occasionally require troubleshooting and maintenance to ensure that they are functioning properly. Learning to troubleshoot your cart will help you recognize any potential problems before they become serious issues or safety hazards.
What is the warning light on a golf cart?
The warning light on an electric golf cart is the battery light . True to its name, this light gets illuminated to warn you of a low battery or low batteries. It serves as a signal for you that it’s time for battery recharge.
What is a golf cart battery light?
A golf cart’s battery light is undoubtedly an indispensable accessory of any battery-operated golf cart. This light notifies you when your golf cart battery or batteries are low on charge. It saves you the hassle of worrying whether you would be stranded because of a drained battery.
What happens if your golf cart battery is low?
Weak Battery Voltage. One or more of your golf cart batteries are likely to have a low voltage. This can stop the batteries from being able to pick up charge. Check the voltage of each battery separately. When you find a battery with a low charge, try charging it to its full voltage using a smaller auto charger.
Why does my golf cart light flash red?
The light, usually red, starts flashing when the battery has got less than 10 percent charge left, in an electric golf cart or less than 10 percent fuel in a gasoline-powered golf cart. The golf cart has several other warning lights. For example, there is a warning light to indicate if there is any problem with the engine of your cart.
Why is my battery light flashing?
One reason why your battery light is flashing could be because the batteries are not getting a full charge from the charger. The flashing indicates that the charging is less than 90 percent.
Why do my batteries flash?
A mistake in the installation of batteries can cause flash ing battery lights. This can be something like a wrong polarity connection. Analyze how your battery connections have been made. One or more batteries have likely been connected in the reverse order.
Where are taillights located on a golf cart?
As the name indicates, the taillights are located on the rear of your golf cart. They primarily have LED bulbs because of the long lifespan and brighter illumination that is required.
Why aren't my golf cart lights working?
The main reasons golf cart head lights don’t work are blown out bulbs, dead battery’s, faulty wiring, bad headlight switch, bad voltage reducer or a blown fuse. These are all easy to troubleshoot, and very easy to fix. Your golf cart’s lights may prove faulty for a variety of other reasons.
What is the lighting system on a golf cart?
Your golf cart’s lighting system is composed of various parts. Each of these parts works together to produce a working electrical circuit that provides a current to your vehicle’s headlights and brake lights (if your vehicle is equipped with them). The most obvious parts of your vehicle’s lighting system are the headlight and brake light bulbs. These parts of the system are responsible for producing light. In addition to the actual bulbs, the lighting system is also composed of fuses and the lighting switch.
What causes a golf cart to not light up?
Troubleshooting Your Golf Cart’s Faulty Headlights. 1. Blown Fuse on your Golf Cart Headlights. Problems with a golf cart’s headlights are commonly linked to a blown-out headlight fuse. A blown headlight fuse will cause your vehicle’s headlights to not receive the power necessary for them to produce light.
Why do my golf cart headlights stop working?
The third reason for a golf cart’s headlights to stop working is a faulty headlight switch. Sometimes this switch will not receive enough current causing the switch to fail. When this switch fails there is no way for the golf cart operator to activate the vehicle’s headlights.
How many terminals do you need to connect your golf cart headlights to?
These wiring for a cart’s headlights should only be connected to two battery terminals; any additional connections will cause the headlights to blow immediately. In order to check your golf cart’s circuit wiring you should refer to the wiring diagram included in your golf cart’s user manual.
What is the difference between headlights and brake lights?
The actual part that produces light for the vehicle. Similar to car or truck lighting, headlights on a golf cart produce yellow or white light, where as brake lights are colored red. Electrical Circuit. The system of wires, fuses, and resistors that produces a stable electrical system.
What are the parts of a vehicle's lighting system?
The most obvious parts of your vehicle’s lighting system are the headlight and brake light bulbs. These parts of the system are responsible for producing light. In addition to the actual bulbs, the lighting system is also composed of fuses and the lighting switch.
Step 2: Match the serial number to the table below to determine the model and year of your Yamaha golf cart
Please note: You only need to search and match the first 4 characters of your serial number to determine your model/year:
How to Find the Year of Your Golf Cart
If your serial number begins with "JW9-3" then you have a 2013 Yamaha DRIVE.