Full Answer
Why does my golf cart battery run out of water so fast?
The golf cart battery may run out of water quite a lot. It can be due to any reason. If you overcharge your battery most of the time, it may start to evaporate the fluid inside the battery that causes a decrease in the battery’s life.
Should I refill my golf cart battery when water level low?
The first thing to be aware of is that you should not necessarily refill your golf cart battery every time the water level is low. When a battery is discharged, the water level will be low by design. If you refill it, and then charge the battery, it will overflow.
What happens if you overfill a car battery?
What is more important though is that if you overfill the battery too much your effectivly weakening the acid solution which is how the charge is maintained and transported within the cell. Also an overfilled battery is more likely to leak as it is charged, so the sulphuric acid content is more likely to cause issues as it is very corrosive.
How do you maintain a golf cart battery?
In terms of maintenance, the most important thing you can do for your golf cart battery is to ensure that its water levels are good. Without enough water, your batteries will eventually dry out and suffer irreversible damage. Fortunately, adding water to your batteries is pretty easy and won’t take too much of your time.
What happens if you put too much water in golf cart batteries?
Golf cart batteries produce electricity using electrolytes and water, which means you will need to occasionally add some more water. But be careful of the amount! Too much water can lead to the electrolytes overflowing. Too little water can cause sulfation, which damages the lead plates.
What happens if you over fill a battery?
If too much water was added before charging, the electrolyte levels will expand and cause the battery to overflow and damage the battery. Additionally, excessive watering of a battery can result in additional dilution of the electrolyte, resulting in reduced battery performance.
How full should golf cart batteries be?
Fill battery cells (aka water fill holes) with distilled water (not tap water) ¼ to ½ inch above the plates. With ¼ inch of water you'll have to check your batteries more often, but at ½ inch you'll likely have more acid accumulation on the tops of the batteries. Either level is acceptable; it's really your call.
Can you overcharge a cart battery?
6) Do not overcharge your golf cart batteries. Avoid operating batteries in a partially charged condition. This will reduce their capacity and shorten their life span.
Can you overfill a 12 volt battery?
The answer is yes and the results are messy and potentially toxic and corrosive. The only time you add water to a lead acid battery is when it is fully charged. The reason for this is when a battery is fully charged the plates are thicker and the there is less space between them.
Can you overcharge a Club car golf cart?
Club Car Overcharging Problems Overcharging can cause severe damage to your cart's batteries. Sometimes even automatic chargers can malfunction and fail to turn itself off.
How often should you fill golf cart batteries with water?
about once every 30 daysThe typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
Should I leave my golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
Should you charge your golf cart after every use?
Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
Why is my golf cart dying so quickly?
The most common issue that typically affects battery carts and causes them to drain more quickly is a low water level. This situation is so common because many cart owners don't take the time to balance the water in their battery or don't know that they even need to perform this step.
What should my golf cart charger read when fully charged?
If the batteries are full, the ammeter reading will quickly drop below 15 amps. As the batteries charge the ammeter read out will eventually drop to about 2 or 3 amps. This indicates a near full charge in the batteries.
How long should a fully charged golf cart last?
Recharging Batteries Golf course maintenance personnel recharge institutionally owned golf carts after every 18-hole round of golf, which lasts approximately four to five hours, and measures approximately 6,000 yards (3.5 miles).
How full should I fill my battery with water?
The fluid should be about 1/2- to 3/4-in. above the internal “plates,” or about 1/2- to one-inch from the top of the battery (just to the bottom edge of the fill hole). If the fluid is below that, it needs to be topped off.
What happens if you put too much acid in a battery?
Adding acid actually makes a battery deteriorate faster. It comes down to how batteries work and eventually lose their ability to hold a charge. In a typical wet-cell design, a lead plate (negative) and a lead oxide plate (positive) are immersed in the electrolyte.
How much water should be in a battery?
Before charging, make sure there is just enough water to cover any exposed plates (rectangular metal parts visible when you look inside a battery). After charging, add enough water to bring the level to the bottom of the vent, about ¾ below the top of the cell.
Will adding water to a battery fix it?
0:531:52How To Correctly Add Water to Car Battery -Jonny DIY - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what you're going to take is you're going to take distilled water not tap water not bottled waterMoreSo what you're going to take is you're going to take distilled water not tap water not bottled water it has to be distilled water to get all the minerals out and what we're going to do is we're just
What happens if you don't fill the vent tube?
By not filling above the bottom of the vent tube, you leave air space for the gases to expand into. Without that space, the outgassing forces liquid out the vent.
Can you add things to a flooded cell?
Yes it would... It would ruin them.. You add one, possibly 2, things to a flooded wet cell
Can you gass a well tube slotted?
I've done the same thing for a "hunert" years. As long as the fill well tube is slotted to allow out gassing, you will be fine.
Does RV have fixed voltage charging?
But now on the RV is just fixed voltage charging so you have to be mindful of the charging voltage and check the water more often because the battery temperature might not be optimal for charging (either too hot or too cold).
Can plates remain submerged in electrolyte?
Totally agree. Just as long as the plates remain submerged in electrolyte.
Do batteries hold more acid than meets the eye?
Depending on the age and condition of the batteries (hydrometer), if good, I wouldn't worry too much about it. The cells hold more acid than meets the eye.#N#If you are worried about it, you could always have them load tested after you get the acid levels where you want them.
What Happens If Golf Cart Batteries Run Out Of Water?
When the batteries are discharged, they will consume the electrolytes, causing the water levels to drop. This water evaporation is a normal part of deep-cycle battery functionality, and when you recharge the battery, the water quantity is usually restored to its optimal amount.
How To Add Water To Golf Cart Batteries?
The first thing to be aware of is that you should not necessarily refill your golf cart battery every time the water level is low. When a battery is discharged, the water level will be low by design. If you refill it, and then charge the battery, it will overflow. This will leak battery acid everywhere, which will then cause corrosion. Never add water to a battery when it is discharged.
What to do with golf cart batteries in 2021?
June 1, 2021. by Nick Lomas. In terms of maintenance, the most important thing you can do for your golf cart battery is to ensure that its water levels are good. Without enough water, your batteries will eventually dry out and suffer irreversible damage. Fortunately, adding water to your batteries is pretty easy and won’t take too much of your time.
Why do you need to refill a battery with water?
You are only required to refill your battery with water in order to maintain the chemical makeup of the battery. However, accidents can happen, and a battery may be tipped or dropped, causing the acid to spill out. If this happens, you will need to replace the sulfuric acid that has been lost.
Why do batteries dry out?
The heat causes the water to evaporate, diminishing your batteries’ access to the crucial electrolytes. When the water levels are low, the battery plates will be exposed to the air for longer than they should be, which will cause them to dry out and flake off. This results in a condition called sulfation.
Why do you need distilled water for batteries?
Instead, you must use distilled water. This is because distilled water is essentially pure water, free of any contaminants that will harm your battery. Now for the process.
What happens when you recharge a battery?
This water evaporation is a normal part of deep-cycle battery functionality, and when you recharge the battery, the water quantity is usually restored to its optimal amount. However, after a number of charge cycles, or if the cart has not been used for a while, you might notice that the water levels are low even when the battery is not discharged.
How to corrode golf cart batteries?
The electric golf cart batteries will not be able to perform at their optimal level. 2. Spilling corrosive acid on the battery box and cables and metal frame. The battery acid can corrode whatever it comes in contact with.
Can battery acid corrode?
The battery acid can corrode whatever it comes in contact with.
Can you turn off the radio on a golf cart?
Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.
Can you use an automatic battery charger when it is fully charged?
It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.
Can you use a bad boy golf cart for long distances?
Many of our great E-Z-Go, Cushman, and Bad Boy options are designed for longer-distance use, but even they have their limits. Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.
Should golf cart batteries be charged?
Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.
What happens if you overfill a battery?
Also an overfilled battery is more likely to leak as it is charged, so the sulphuric acid content is more likely to cause issues as it is very corrosive.
Why does water evaporate when charging?
Too much water causes more gases when charging , such that you upset the specific gravity of the acid in that cell causing it to produce a lower voltage causing the gas.It will evaporate eventually at the expense of battery service life being lowered.
When to add water to lead acid battery?
The only time you add water to a lead acid battery is when it is fully charged. The reason for this is when a battery is fully charged the plates are thicker and the there is less space between them. The electrolyte level is at its highest. When discharged the reverse is true. The electrolyte level is at its lowest.
Can you drain battery fluid?
I can't recommend you try draining any excess battery fluid as sulphuric acid can cause skin burns etc and will certainly eat any clothing etc it comes into contact with. A battery specialist or good garage however will likely be able help, and drain a little excess liquid from the cell for you, just to prevent any future bubbling over of water/acid.
