Batteries can be one of the most common problems that take places in an electric golf car, however it doesn’t have to be with some proper education. When the vehicle is not properly charged and maintained, it will eventually lead towards the discharging and deterioration of the battery.
Full Answer
Why do golf cart batteries fail?
The never ending war on corrosion. The most common thing that leads to early golf cart battery failure is corrosion. The problem goes deeper, too. It will ruin your cables, terminals, and even cause damage to battery trays and tie downs. Replacing a whole battery cable can be costly and difficult, so it’s best to avoid that problem.
What can go wrong with an electric golf cart?
There are quite a few common things that can go wrong with an electric golf cart. These common issues include rapidly depleted batteries, worn machinery behind ignition, damaged ignition switch, blocked motor just to name a few. Read on to find out the twenty most common things that can go wrong with your electric golf cart.
Do electric golf cart batteries need to be replaced?
Electric golf cart batteries need to be charged and have water added regularly. If you purchase a preowned electric golf cart, be sure to ask about the age of the battery before you buy. You may not need to replace your battery for a long time, but the older a golf cart is, the more prone it may be to corrosion.
How to top up golf cart batteries?
If you need to top up the acid levels – only fill to slightly above the battery cells. You need to leave enough room for expansion, so the acid should only be filled to just above the lead cells inside. Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries.
How do you reset an electric golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
Why did my electric golf cart stop working?
If you're lucky, the problem could be as simple as a loose wire or a broken coil. In some cases, corrosion can also be a factor. If you suspect a faulty solenoid, your best bet is to take your cart to a repair shop. A mechanic can diagnose the problem and replace the solenoid if necessary.
How do you ruin golf cart batteries?
Don't Run the Radio After You're Done Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly.
What would cause a golf cart not to charge?
If your batteries aren't hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Should you leave your electric golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How often should you put water in golf cart batteries?
about once every 30 daysAlways fill the batteries after charging. The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
What causes golf cart batteries to drain quickly?
The reason why your golf cart battery keeps losing charge or drains quickly, may be due to loose wires, corroded connectors or an insufficient amount of water in the battery. The battery connections may have become loose or the connectors are corroded.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do I know if my golf cart is charging?
1:564:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipOff if you're using a more modern style charger like this one you'll find led indicator lights toMoreOff if you're using a more modern style charger like this one you'll find led indicator lights to show that charging is in progress depending on the make.
How do you charge a completely dead golf cart?
3:335:42How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe recommend starting by charging each battery for 5 to 10 minutes at a time and then moving on toMoreWe recommend starting by charging each battery for 5 to 10 minutes at a time and then moving on to the next. One.
How do you troubleshoot an electric golf cart?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
Why does my golf cart suddenly stop?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch. If the micro-switch is faulty, it can also cause the cart to suddenly stop midway.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How do you fix a golf cart that won't start?
3:214:39How To Fix Almost any Golf Cart that won't start - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo it's a real simple fix all you're going to do is take that bolt off or that nut off right thereMoreSo it's a real simple fix all you're going to do is take that bolt off or that nut off right there unravel that tape.
What happens if your golf cart battery fails?
Obviously, for electric golf carts, the battery is what provides power to your motor. If your batteries start to quit on you, the golf cart won’t move, or will drastically decrease in range. With a gas motor, the battery is what starts the motor and keeps it running by providing electricity to the spark plugs. Without it, your motor won’t crank.
Why is my golf cart battery failing?
The most common thing that leads to early golf cart battery failure is corrosion. The problem goes deeper, too. It will ruin your cables, terminals, and even cause damage to battery trays and tie downs. Replacing a whole battery cable can be costly and difficult, so it’s best to avoid that problem.
How to clean corroded battery posts?
Undo the terminals from the battery posts and soak the corroded area in the cleaner or baking soda solution for about 5 or so minutes, then put on some gloves, grab your wire brush, and keep scrubbing until it’s all gone. Repeat as necessary, then rinse with a lot of water.
How does a battery work?
Your battery works by having two metals, a cathode and anode, react to each other to create chemical energy that we harness as electrical energy. With wet cell lead-acid batteries, these metals are kept in a liquid electrolyte, a liquid solution comprised of pure water and hydrosulphuric acid mixed to a set specific gravity. Other types of batteries typically use a gel, mat, or solid electrolyte to perform the same function. For the purpose of this topic however, the only battery we’ll be discussing is the traditional lead-acid battery, as this is the only type of battery for which you will have to worry about electrolyte levels.
Why is my battery puddled?
If your battery gets dirty, muddy, grimy, or anything else, make sure to clean that off too. These things can cause extra resistance in your electrical system, putting an unnecessary drain on your battery and shortening its life.
How long do batteries last?
All joking aside, every battery is different, but most properly maintained batteries will last about 4 to 6 years depending on usage, charge cycle, and a bunch of uncontrollable variables. Lead acid batteries will require a lot of maintenance to do so, however.
What happens when hydrogen gas is released from a battery?
Look for corrosion often, and neutralize it immediately. It’s a long and never ending war, but your wallet will thank you. Corrosion happens when hydrogen gases, released from your battery, mix with other chemicals and gasses in the atmosphere, and then bond to the metals of cables, terminals, and battery posts.
Why won't my electric golf cart start?
Today, we'll look at the most common problems with electric golf carts, and how you can prevent or repair them. 1. Batteries That Break Down or Lose Charge. If your golf cart won't start, the first thing we suggest it checking your battery! Electric golf cart batteries need to be charged and have water added regularly.
Why is my golf cart ignition not working?
If your ignition has problems, it's almost certainly due to wear and tear or the age of your golf cart. Wires can become loose and lose the connection between the switch and the battery, or they may require replacement when they wear out or break over time.
What is the solenoid on a golf cart?
The solenoid is a cylindrical coil of wire that works as the magnet carrying an electric current. Basically, when you start up your golf cart, the solenoid is the reason for the clicking sound you hear when engaging the acceleration pedal. This sound is a good thing!
What is a direction switch on a golf cart?
Direction Switch. The direction switch simply lets you control whether your golf cart is in forward or reverse. One of the most frequently used parts on a golf cart, it's heavily prone to wear and tear and breaking down over time.
Do electric golf carts run quietly?
They generally run more quietly than gasoline-powered golf carts and ATVs do, and keeping them moving is as simple as keeping up with preventative maintenance and maintaining a full charge. However, electric golf carts do have their share of unique concerns and potential issues that you'll want to keep an eye out for.
Do you need to replace a golf cart battery?
If you purchase a preowned electric golf cart, be sure to ask about the age of the battery before you buy. You may not need to replace your battery for a long time, but the older a golf cart is, the more prone it may be to corrosion.
Why does my golf cart stop working?
It is one of the essential parts of the golf cart. It will let you know that you have started the car because of the clicking sound that it makes when you engage the accelerator pedal or turn the key switch on. However, it often stops working because of the following reasons: Corrosion. Loose Wires.
Why won't my golf cart start?
It is one of the essential parts of the golf cart. It will let you know that you have started the car because of the clicking sound that it makes when you engage the accelerator pedal or turn the key switch on. However, it often stops working because of the following reasons: 1 Corrosion 2 Loose Wires 3 Broken Internal Coil
What is the controller on a golf cart?
The controller is responsible for controlling the speed of the golf cart and also handles all the information being transferred from the ignition switch to the batteries to the motor. Some refer to the controller as the brain of the golf cart. The most common issue that occurs in the controller is that it might become damaged because ...
What happens if you use a golf car for a long time?
The wear and tear of the machinery behind the ignition. Extensive usage will eventually damage the ignition switch and can lead to improper usage. There also might be an issue with the wiring of the ignition switch. It is important that you inspect potential ...
Why do people use golf carts?
Individuals use golf carts for a wide variety of reasons. It originally started as a means to relieve the burden of carrying golf clubs on the course and has now evolved into a means of transportation.
What is a direction switch on a golf cart?
Direction Switch. There are special direction switches in the golf cart. It helps the person to move the car in a forward or reverse direction. However, with the extensive usage of the vehicle, the switch can become damaged and eventually breakdown.
Is a golf cart controller reliable?
Overall though, controllers these days are quite reliable due to the advancement of technology. However, the older and more hours a vehicle has, the higher likelihood of potential replacement. Keep in mind that it is one of the most difficult problems to diagnose and is one of the more expensive components in an electric golf cart.
How to tell if golf cart battery is bad?
1. Charging Issues. First, check to ensure that your golf cart was charged before you took it out.
How to check if golf cart is charging?
First, check to ensure that your golf cart was charged before you took it out. Plug it back into the charger and follow the instructions. Just in case the charger is the issue, check that the battery charger is turned on. There should be an indicator light to show that it is charging the batteries. In the morning, disconnect ...
What hole does a golf cart stop dead?
It’s a real hassle if your golf cart stops dead and you’re only at the 15 th hole of play. Not only is this an embarrassing event, but it’s a major pain to have to arrange for the cart to be towed back to the parking lot.
Why won't my cart fire up?
But more often than not, your cart suddenly refused to fire up and go due to a dead or bad battery.
Can you top up golf cart batteries?
Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries. If this is the case, you will notice how several individual batteries have been “daisy-chained” together to form one large battery. 4.
Can you top up a golf cart battery with distilled water?
You need to leave enough room for expansion, so the acid should only be filled to just above the lead cells inside. Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries.
Do golf cart batteries last forever?
Golf cart batteries won’t last forever. In fact, each year they age a little bit closer towards their final use. If your battery is close to its warranty end date you may want to consider simply making the upgrade now.
Can you turn off the radio on a golf cart?
Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.
Can you use an automatic battery charger when it is fully charged?
It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.
Can you drive a golf cart up steep hills?
Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.
Should golf cart batteries be charged?
Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.
Why do electric golf carts fail?
These carts can start to show signs of wear and may fail just like any other vehicle over time.
What are the problems with electric golf carts?
These carts can start to show signs of wear and may fail just like any other vehicle over time. Learn about some of the more common issues associated with electric golf carts. 1. Solenoid Wear. The solenoid is the primary electrical switch in your golf cart and is designed to ensure the current from the battery flows into the motor. ...
What is the controller on a golf cart?
An electric golf carts' controller is known as the heart of the operation and closely resembles and operates much like the motherboard in a computer. So a problem with the controller will have rippling effects throughout the cart. A common function of the speed controller is to control the speed of the golf cart.
Why does my gas cart not work?
When you press down on the gas pedal and hear a tapping-like sound, this is the sound of the solenoid activating. When there is a disruption in the flow of the electrical current , your cart will not operate. A common reason for current disruption is solenoid wear.
What happens if your cart doesn't move?
If the cart doesn't move in either direction, both switches have failed. Diagnosing a problem with the direction switches isn't a complicated matter, but repairing the switch is more complex, especially if the switches are built into the speed controller.
Why won't my sped controller accelerate?
Problems with the sped controller occur for a variety of reasons, but most often the cause is degradation due to age or lack of use.
How does a solenoid work?
Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate. Over time, the force of this pressure creates tiny electric arcs on the plates' surface. These arcs eventually create a resistance that prevents the current from properly flowing.