Find the ignition wire on your golf cart. This runs from your ignition switch to the starter solenoid. Check this over for corrosion on either end and make sure you’ve got a tight connection.
Full Answer
What causes ignition coils to go bad on a golf cart?
The main cause of golf cart ignition coils going bad is the wearing out due to a bad spark plug ignition cable. When a bad plug is inserted, it will have a much higher resistance value. During such high resistance a high amount of voltage gets generated from the secondary wiring of the ignition coil.
How to start a golf cart with a bad ignition?
Find the ignition wire on your golf cart. This runs from your ignition switch to the starter solenoid. Check this over for corrosion on either end and make sure you’ve got a tight connection. If the connections use a spade lug, pull the connection loose, wipe off the terminal, and plug it back in again. Try to start the cart now.
What can go wrong with an electric golf cart?
There are quite a few common things that can go wrong with an electric golf cart. These common issues include rapidly depleted batteries, worn machinery behind ignition, damaged ignition switch, blocked motor just to name a few. Read on to find out the twenty most common things that can go wrong with your electric golf cart.
How to replace the ignition switch on club car golf cart?
Remove the face nuts with a pair of pliers. Now, the ignition switch can be removed easily. Install the new switch on to the plate and screw the face. Reverse the steps given above for locking the ignition switch back in place. Turn on the switch and verify that it is working. How to Replace the Ignition Switch on Club Car Golf Cart
What does the igniter do on a Club Car golf cart?
The Nature of Golf Cart Ignitors In essence, the ignitor works to enhance electrical signals and produce a larger flow of electricity to the coil that helps your spark plug operate. In this way, it is an essential part on gas-powered golf carts but is usually not found on electrical carts as there is no need.
How do you test a golf cart Ignitor?
Take the voltmeter's black and red probe and place it on the –ve and +ve terminal of the coil. Take the readings. It should be between 3.7-5.2 ohms. If outside the range, the coil should be replaced.
What does a coil igniter do?
The igniter is the step up transformer that sits inline between the engine control computer and the ignition coil. It takes the low amperage signal from the computer, usually a 12 volt square wave, and steps it up to higher amperage trigger signal for the ignition coil.
How do you test a ignition switch on a golf cart?
Testing a Club Car Ignition SwitchFind the back and red wires on the back of your battery pack.Connect the black wire to the negative terminal and the red to the positive.Keep the cart turned off while you work on it.Check the wires with a probe meter while the cart is off – only one wire should have a charge.More items...
What would cause a gas golf cart not to fire?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
How do you test a club car ignition coil?
0:071:56Engine Won't Start? Ignition Coil Testing, Troubleshooting - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf a spark jumps across the terminals in the tester window or the engine starts the spark plug andMoreIf a spark jumps across the terminals in the tester window or the engine starts the spark plug and ignition coil are working properly. If you do not observe a spark unclip the tester from the plug.
What is a ignition Ignitor?
The ignition ignitor is the component that is responsible for sending a signal from the key's ignition switch to the electrical system to supply power to the spark plugs and start your engine.
How do you change the ignition igniter?
0:111:20Replacing an Ignition Module on a Gas Grill - YouTubeYouTubeStart of suggested clipEnd of suggested clipInstall the plastic nut on the front of the ignition module insert the battery in the new ignitionMoreInstall the plastic nut on the front of the ignition module insert the battery in the new ignition module install the igniter button on the front of the ignition module.
How do you replace igniter?
0:211:29Replacing an Oven Igniter in a Gas Range - YouTubeYouTubeStart of suggested clipEnd of suggested clipPull the igniter forward and unplug the wire harness from the igniter. Pull the old igniter out ofMorePull the igniter forward and unplug the wire harness from the igniter. Pull the old igniter out of the oven plug. The new igniter into the wire harness.
What happens when ignition switch goes bad?
A bad ignition switch won't be able to supply power to the starter motor, ignition system, and other engine controls, preventing the engine from starting. Keep in mind, however, that engine issues may also be caused by other electrical and mechanical problems, such as a dead battery or a faulty starter solenoid.
How do I know if I have a bad ignition switch?
Signs Of A Faulty Ignition SwitchCar Won't Start. If you turn your key and the car attempts to start, but fails, then you might have a broken ignition switch. ... Key Won't Turn. ... Car Stalls. ... No Noise From The Starter. ... Dashboard Lights Flicker.
How do u know if your ignition switch is bad?
5 Telltale Signs of Ignition Switch ProblemsYour car stalls while driving. One of the first signs is a vehicle that suddenly stalls while the engine is operating. ... Car starts and then suddenly stalls. ... The engine doesn't start. ... Issues powering on the accessories. ... Issues turning or removing the key.
How to remove ignition switch?
Remove the face nuts with a pair of pliers. Now, the ignition switch can be removed easily.
How to make a shopping cart start when the key is in ON position?
One of the solutions to this issue would be to use a toggle switch. Try wiring it in such a way that the cart would start only if the key is in ON position while the switch is in the OFF position. And by default, keep the switch in ON position. This way the cart will not work unless a person knows this particular arrangement.
How to check if key switch is working?
If you wish to check if the key switch is functioning properly, follow these steps. There are two probe wires present in the battery pack – a black and a red. Connect the black probe wire to the 36v negative terminal of the battery pack. The red probe wire should be connected to the back of the battery pack.
What to do if you can't wire a key switch?
If you are unable to wire it correctly, it may be a good idea to consult a key smith to get the key switch changed.
Can you replace the ignition switch on a club car golf cart?
So, if you are looking to replace the ignition switch of a Club Car golf cart, the steps that you followed for the E-Z-GO may not help. A few minor modifications may have to be made.
Do all golf cart keys have the same key?
Yes, all club car golf cart keys are the same. The downside of owning a golf cart is that the key switch can be easily accessed using any key from the same manufacturer. If you have a single key from a particular manufacturer, you can easily use it to open all the carts made by them.
Can you park a golf cart on a golf course?
Some people park their carts on the golf course but do not prefer other people using it. To avoid this problem, you can change the key switch or use a combination of other techniques. This way the cart cannot be used by others without your permission.
Why won't my golf cart start?
Like any other electric vehicle, the batteries are mainly at the root of why your cart won't start. After all, they are the primary source of power for your electric golf cart. If your cart is not working, this is the first place to check. Generally, lead acid-based batteries are used for electric golf carts, and you must recharge them regularly so that they function correctly.
Why are my ignition switches loose?
There might be issues with the wiring of the ignition switch. Due to wear and tear, wires may become loose and require replacement.
What to do if your solenoid is bad?
Make sure to inspect it properly. If you find a damaged solenoid, the best thing is to take your cart to a garage. A mechanic can solve the issue and replace the solenoid if required.
What is a direction switch on a golf cart?
The direction switch or forward/reverse switch controls whether the golf cart moves forward or backward. This switch is one of the most used parts in a golf cart, which means it will be subject to wear and tear. You'll find what the issue is if the switch is acting up. There is a big chance that it will need to be replaced. Again, it's best to choose a mechanic for repair.
Can you fix a golf cart speed controller?
If you face issues with the speed controller, do not try to fix it yourself unless you can easily find and tighten the connection. It's best to take it to a specialist to diagnose the problem correctly.
Is an electric golf cart invincible?
Electric golf carts are convenient, durable, and efficient, but that doesn't make them invincible. Therefore, it is essential to understand that issues can arise in an electric golf cart. Do not panic if your golf cart doesn't start— chances are, it's going to be one of the following five most common reasons.
What does it mean when a golf cart solenoid goes bad?
Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor ...
What are the symptoms of a bad solenoid on a golf cart?
In addition, the spring that pulls the pinion back to its resting position could wear down leaving the starter engaged continuously. (Starters are supposed to get the flywheel moving, then back out of position – disengage.)
Why does my golf cart make clicking sounds?
On a gas golf cart, the most common symptom is the starter failing to engage – so the engine doesn’t turn over – while all you hear a series of very futile clicking sounds.
Why does my solenoid wear out?
Like any switch that relies on wiring, the solenoid could also just wear out due to overheating. This might cause it to fail to retrieve the pinion gear.
What does a solenoid do when you turn the ignition?
Step by step, it looks like this: When you turn the ignition key, a small amount of electricity goes to the solenoid. The solenoid uses that small amount of juice to close two heavy-duty contacts that allows a large jolt of electricity to pass through the starter. The solenoid also sends a pinion gear forward, which is the device ...
Why do starter contacts wear out?
Secondly, the contacts could begin to wear out from overheating or exposure to high levels of current. This needs to be fixed right away if possible, because this causes continuous use of the starter. If not caught in time, the solenoid and the starter will both need replacement.
Why won't my solenoid click?
The solenoid might not be getting enough electricity to do its work – which could be caused by loose connections, a weak battery or the coil wearing out.
Golf Cart General Introduction
The popular definition for a golf cart is that it is a small vehicle designed to carry two or more golfers and their equipment around the golf course or desert pathways to avoid walking effort.
Electric Golf Carts
The two main types of golf carts driven at the golf courses are gasoline and electric golf carts. Both of them function on the principle of a regular, less powerful gasoline or electric car, with some insignificant differences. Electric golf cars are popular with their environmentally friendly mode of operation.
Common Things That Can Go Wrong With An Electric Golf Cart
Buying and driving an electric golf cart, you should be aware that, just like other cars, it has a lifespan, and its parts also wear out. Some golfers perceive their carts as small, funny vehicles that can drive them around the golf course forever.
How To Avoid Or Mitigate The Issues
The key to avoiding or mitigating possible electrical golf carts malfunctioning is, as already mentioned a few times above, proper and regular maintenance. Golf cart owners should perceive their small electric vehicles as regular cars with a more restricted use range.
The Elite Of The Electrical Golf Carts
Pointing out so many common issues with the electrical golf carts may leave you with the wrong impression that they are pretty problematic vehicles. Let’s clarify that technical issues are typical for the used carts but are quite unusual for new carts with a warranty.
Electric Golf Carts FAQ
To determine whether your electric golf cart motor is bad or not, you need to test it first. Sometimes the problem is easy to detect, but sometimes you need to check the entire electrical system.
Sources
Wikipedia, “Golf Cart.” Wikimedia Foundation, https://en.wikipedia.org/wiki/Golf_cart Assessed June 8, 2021