Where can I buy a rear axle for my golf cart?
Golf Car Catalog offers rear axles for many golf cart brands and models including Club Car, EZGO and Yamaha, Within this section, we not only offer the entire differential assemblies, but also the side specific axles which rotate within the differential axle tubes, as well various rear axle bearings, and supplemental hardware.
How to remove a bearing from a golf cart axle?
You may require a slide hammer to help you with releasing the bearing from the axle if it’s stuck on to it. You can also check for a C-clip at the backside of the golf cart that keeps the axle in position. This clip is often inside the axle tube behind the drum mounting flange.
How to jack up a golf cart?
Chock the front wheels of the Club Car to prevent it from moving. Loosen the lug nuts present at the back of the golf cart. Loosen the nut present on the axle at the end. Raise the rear end of the cart and place it on the jack stand. Take off the rear wheel followed by the brake hub. Check where the axle is positioned at the rear end.
How do you remove the rear suspension on a golf cart?
Lift the rear suspension frame using the floor jack so that the rear wheel is suspended in the air. Take off the screws fitted on the rear wheel using the same socket mentioned above. Take off the rear wheel and place it below the chassis of the golf cart near the jack.
What does DS stand for on club cart?
What does DS stand for in Club Car golf carts? The Club Car DS model type, in production from 1980 to 2014, was named after Dom Saporito, a vehicle designer at Club Car in the 1980s.
What is a rear differential on golf cart?
A golf cart rear axle, often referred to a differential, helps propel your Yamaha G1, G2, G8, G9, G14, G16, G19, G22, and G29 the drive gas or electric golf cart. A differential slows the rotational speed of your clutch or electric motor before it hits the rear wheels.
What is the differential on a golf cart?
Maintaining your golf cart's differential and transmission is essential to your vehicle's performance and longevity. Your differential transmits torque to the Club Car wheels and allows them to turn at different speeds.
Does a golf cart have an axle?
Axles are responsible for turning your cart's front and rear wheels by transferring power from the differential to the wheel hubs. Excessive noise or vibrating can be an indication that the driveline part may need to be replaced.
Do both wheels spin on a golf cart?
Do both wheels spin on a golf cart? Both wheels can spin on a golf cart by using the correct kits.
Does a Go Kart need a differential?
Karts do not have a differential. The lack of a differential means that one rear tire must slide while cornering. This is achieved by designing the chassis so that the inside rear tire lifts up slightly when the kart turns the corner.
How do you change the rear axle shaft on a EZ Go golf cart?
1:592:59How to Remove an E-Z-GO TXT Front and Rear Axle - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe first step is to remove the rear pin from the brake cable once this is done remove the c-clipMoreThe first step is to remove the rear pin from the brake cable once this is done remove the c-clip and slide the brake cable from the assembly.
How do you put oil in a golf cart rear end?
0:221:112002 EZGO gas golf cart Rear differential 80/90 weight oil changeYouTubeStart of suggested clipEnd of suggested clipAt the top see this yellow tab there that is a plastic plug. And you pull that plastic plug out andMoreAt the top see this yellow tab there that is a plastic plug. And you pull that plastic plug out and you fill it up with gear oil up to this hole right here.
Does a gas golf cart have a transmission?
All golf carts (much like cars) have a clutch, which is the part of the drivetrain that helps the put the power of the motor down through to the wheels/ground. Golf cart clutches are a part of the Continuously Variable Transmission (or CVT).
How much does it cost to replace a rear axle?
The average to repair a front axle is $550 dollars. Rear axle repair costs run a little higher and average about $799 dollars.
Can a golf cart tip over?
An unexpected turn in a golf cart can lead to your cart tipping over or a passenger falling out. Always slow down for corners and take them carefully. These rules are especially important when driving on hills or turning on blind corners.
Do golf carts have brakes on all 4 wheels?
The conventional golf cart has rear brakes to stop the cart because of the low speed. Apparently, the brakes at the rear wheels do not have to exert much force to stop the cart. But, as golf cart owners seek more powers, it ultimately requires more brakes to cope with an increase in speed.
When did Club Car start using a Graziano transaxle?
Club Car started using a Graziano transaxle in some models starting in 1994 I believe and later in the 90's around the time they switched the engine rotation to clockwise they started using the Graziano rear end in all gas models as far as I know.
What engine did the Club Car use in 1986?
Late 1986 to 1991 Club Car used the KF82, 4-cycle, 341cc, side valve engine with a Kawasaki differential. The Kawasaki differential has a rubber oil fill plug.
What engine did the 1993 Club Car use?
1993 Club Car started with the FE351 (351cc) Overhead valve, 4-cycle, gas engine for utility vehicles. Engine rotation is counterclockwise when viewed from the clutch side of engine (see 1997).
