The Run/Tow switch in an EZGO TXT golf cart is located below the seat on the passenger side of the cart. The toggle switch is usually protected with a black cover above it. However, if the cart is a series drive model, the cart will not have a Run/Tow switch.
Where is the tow switch on an EZ GO golf cart?
Lift your E-Z-Go cart’s front seat. You will see the tow/run switch; turn it to tow instead of run. Look for wires labeled 1, 2, 3, 4 and ensure that wire 1 connects to wire2 and where wire3 connects to wire 4.
What are the problems with the EZGO RXV golf cart?
The EZGO golf carts, including the EZGO RXV and EZGO TXT, show uncontrolled speed changes and fail to drive at a constant speed in case of a bad micro switch. EZGO golf carts tend to stop and start while running when there is a problem with the micro switch.
How do I test the micro switches on an EZGO golf cart?
The micro switches on an EZGO golf cart can be tested by conducting a test for continuity using a voltmeter. There are multiple switches on an EZGO golf cart and the following step-wise guide can help you test all of them.
How do you turn off tow run on a golf cart?
In a golf cart application, a separately excited controller draws a very small amount of power at all times, even when the vehicle is not in use. To disable this feature, you must flip the tow run switch into the “TOW” position. This minimizes its power draw over time.
What does the run tow switch do on a golf cart?
TOW / RUN switches are basically kill switches designed to disable the golf cart. there are several reasons for this switch. Usually, a TOW / RUN switch is only used on electric golf carts, specifically those with a separately excited electrical system with regenerative braking.
Should I charge my golf cart in tow mode or run mode?
Your golf cart needs to be charged in Run. Tow should only be used in long term storage or if you are going to remove the battery.
What is the tow switch on an EZGO golf cart?
To tow an EZGO golf cart, use the Run-Tow switch to set your golf cart into Tow mode. This will allow you to tow your golf cart. Almost all golf carts have a Run-Tow switch that helps to switch the cart from Run mode to Tow mode and vice versa. The cart must be set to Tow mode when it cannot move with its power.
Where is the tow run switch on a golf cart?
The tow run switches are typically found inside the battery compartment of the cart in plain sight.
What is freedom mode on a ezgo golf cart?
Flip the run-tow switch back to "tow" and then "run" to escape the diagnostic setting mode. This enables freedom mode and allows the cart to reach a maximum speed of 19 mph. Helpful.
Should I leave my golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How do I make my EZGO faster?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Where is the maintenance switch on an ezgo golf cart?
Flip the maintenance switch All EZ-GO speed controllers are equipped with a maintenance switch that needs to be flipped before you begin work on repairing the problem. You will likely find the switch under the seat of your golf car,t but if you're having trouble finding it, consult your owner's manual.
How long should it take to charge my golf cart batteries?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.
When should I charge my golf cart?
Charge Your Batteries After Every Use The best way is to charge overnight after you are done using the golf cart for the day. Even if you have only used the cart for 10 minutes, you still need to charge your golf cart batteries.
How do I charge my EZ Go golf cart?
InstructionsBuy an EZ Go Golf Cart charger from the manufacturer or your local retailer if you did not acquire one when you purchased your cart.Confirm the golf cart battery charger by inserting it into a power source (wall outlet) and then plugging the charger plug into your golf cart's charging receptacle.More items...
Can you drive a golf cart while charging?
No. You should turn your golf cart off when charging its batteries. Trying to charge a golf cart while it is running is a pointless exercise, as the battery will be draining while you're trying to charge it. A golf cart should only be turned on once its batteries are fully charged.
Where is the run/tow switch on an EZGO golf cart?
The Run/Tow switch in an EZGO TXT golf cart is located below the seat on the passenger side of the cart. The toggle switch is usually protected with a black cover above it.
What is a run tow golf cart?
Almost all golf carts have a Run-Tow switch that helps to switch the cart from Run mode to Tow mode and vice versa. The cart must be set to Tow mode when it cannot move with its power. Your EZGO golf cart is operated in this mode when it has to be pushed or pulled to get moving.
How much weight can a golf cart tow?
Golf carts can be used for towing when you have to haul small items between two places. Often, the towing capacity of a golf cart is close to 1,000 pounds. It’s worth noting that some golf carts can tow between 3,000 and 5,000 pounds without any problem.
What to do if your golf cart doesn't run?
Remove the wire connections from the switch and try running the golf cart. If it doesn’t run, the switch could have become faulty and needs a replacement. However, if the cart continues to run, you have a problem with the wiring harness. As a safety measure, you can remove the negative cable from the battery pack.
How fast can a golf cart go?
You can tow a golf cart with a roof safely at a speed of 60 to 70 mph. Strapping the top of the roof to keep it in place can help you to tow the cart without having to worry about the roof. The windshield of the cart may tend to snap off during the towing process.
Does an EZGO golf cart have a run tow switch?
An EZGO golf cart doesn’t have a run-tow switch unlike PDS and most other golf carts. The following steps can help you to tow an EZGO golf cart safely without any damage. Keep the Forward/Reverse switch in a neutral position. Remove the battery connections from the motor.
Is it safe to have a golf cart in tow mode?
The switch can be in Run position when charging the golf cart. However, it’s always safer to have it in Tow mode. This prevents damage to the controller in case of unexpected power surges when the cart is getting charged. Remove the switch cover and turn the switch at an angle of 180 degrees.
Tow Run
The tow run switch, also sometimes called a tow maintenance switch, is present in many brands and models of modern golf carts. This switch is only installed into golf carts with a separately excited motor which produces regenerative braking. They are not used in traditional golf carts with a series wound motor.
Separately Excited Systems
The tow run switches are used in golf carts with separately excited motor and corresponding controller. The electronic speed controllers used in this application have a bit of logic memory within, similar to your automobile’s stereo when it saves your favorite preset stations.
Roll Away Feature
There is also another use for the tow run switches used in golf carts with a sepex controllers and motors. Most carts with this type of system also have a special feature built into the programming of the controller, called the “Roll Away” feature.
The Tow Run Switch Explained
In general, a golf cart’s tow mode is activated via a tow run switch, which occasionally is referred to as a tow/ maintenance switch. This switch is common among modern golf carts and is rarely present on older models. The reason for this variance is that tow run switches are only installed on golf carts with a separately excited motor.
Where is the Tow Run Switch Located
Most likely, the tow run switch for your golf cart is located in the battery compartment. As you are probably aware, this compartment is almost always under a golf cart’s seat. The tow run switch should be in plain sight.
Will a Golf Cart Charge in Tow Mode?
The simple answer to this question is, yes, your golf cart will charge while tow mode is activated. Yes, activating tow mode will disable your cart’s computer, but it does not affect your battery or its charging capabilities. However, you can also charge your golf cart while it’s tow maintenance switch is toggled to ‘run’.
Special offers and product promotions
Amazon Business: Make the most of your Amazon Business account with exclusive tools and savings. Login now
From the manufacturer
From humble beginnings, E-Z-GO has become the OEM world leader in transportation and a leading global manufacturer of golf cars, utility vehicles and personal transportation vehicles.
Product description
The Run-Tow Switch is an essential part of the vehicle's operation in that it eliminates potential damage to the electric motor and controller while allowing the vehicle to move freely when it's in the tow position. For the Tow Harness that corresponds with this switch, please reference Part No.62292.
Do E-Z-Go Golf Carts have titles?
E-Z-Go Golf Carts, unlike vehicles, do not have a title, but they do have serial numbers. If you are buying a golf cart, it is essential to check the serial number to ensure you do not buy a stolen one. Each E-Z-Go Golf cart has a unique serial number that you can use to identify your golf cart.
Where is the E-Z-Go Cart Serial Number
As mentioned above, all E-Z-Go Golf carts have unique serial numbers. These numbers are essential when buying replacement parts for your golf cart. Textron Specialized Vehicles has been building golf carts for a long time, and the serial numbers are placed on different parts of the golf carts.
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
Why does my E-Z-Go golf cart not move
There are several reasons why your cart refuses to move, but you should check the battery before anything else. If the battery is charged, here are some other reasons why your golf cart will not move.
Are all E-Z-Go Golf carts electric?
No, there are both electric and gas-powered E-Z-Go Golf carts available. Bear in mind that there are several models you can drive on the street, but those are all-electric. These electric models run on batteries that you have to charge at least every 24 hours, depending on how much you use them.
How to tell the Assembly year of my E-Z-Go golf cart
The placement of serial numbers is discussed above, and you will find the manufacturer’s number right next to it. The manufacturer’s number consists of one letter and 3 or 4 numbers. The last two numbers indicate the last two digits of the year of assembly.
How to service E-Z-Go Golf Cart
Like all vehicles, E-Z-Go golf carts require regular maintenance to enhance longevity and performance. You should ensure that your golf cart is serviced after every six months of use. That will ensure that you spot problems and repair them early, which will help reduce repair costs. Here are essential guidelines for E-Z-Go golf cart maintenance.
Where are the switches on an EZGO golf cart?
Most of the micro switches on EZGO golf carts including the EZGO TXT, EZGO RXV, and EZGO Express are located beneath the cart near the chassis. You have to unscrew the cover and access the switches.
How to bypass a reed switch on an EZGO golf cart?
To bypass the reed switch, remove the reed switch and install an eyelet on the white wire that was cut short in step 3. Connect the new eyelet to the A+ terminal of the charger receptacle which was opened in step 2. The above steps ensure that the reed switch is safely bypassed on your EZGO golf cart.
What is a forward neutral reverse switch?
The forward-neutral-reverse switch on a golf cart is a micro switch that is triggered when the golf cart is supposed to move in the reverse direction. It will trigger a buzzer that will indicate the golf cart’s reverse movement.
Why does my EZGO golf cart stop?
EZGO golf carts tend to stop and start while running when there is a problem with the micro switch. In case you face any of these troubles in your golf cart, the first thing you should do is test the micro switches in your golf cart and have them fixed at the earliest.
How does a golf cart accelerator work?
Accelerates the golf cart. A micro switch on the accelerator pedal gets activated once the pedal is pushed. This sends a signal to the solenoid and in turn more power to your wheels to make them move faster. These micro switches are more common in electric golf carts.
What is a micro switch?
The micro switches on a golf cart are used to control and protect the components through electrical signals. Micro switches play a critical role in the acceleration and reversing of a golf cart. To make the golf carts lightweight, most of the makers including Club Car, EZGO, and Yamaha have increased the usage of micro switches in their golf carts.
Why does my golf cart micro switch stop working?
A bumpy ride, a wrong wiring or a defective component can cause the micro switch to stop performing as expected. A list of common problems associated with micro switches in a golf cart is given below. The mechanical switch gets stuck and doesn’t turn over when charged.
