Full Answer
What size oil for EZ-GO golf cart differential?
In case you have an EZ-GO golf cart, it is the 30weight oil that you should use in the rear end of your cart. This article will cover everything you need to know regarding the differential of your EZ-GO golf cart.
Do EZGO marathon golf carts need an oil change?
Since the speeds at which EZGO Marathon golf carts run are relatively low than others in the category, the need to change the engine oils is also a matter of lesser concern than the rest.
Can you use the same oil for a golf cart and differential?
But you cannot think about using the same fluid as you use inside of your car engine. Almost every car or other vehicle manufacturer specifies the oil weight for the differential on the manual guide. In case you have an EZ-GO golf cart, it is the 30weight oil that you should use in the rear end of your cart.
What weight oil does the EZGO use?
EZGO uses 30 weight oil in the rear end. You fill it until the oil comes out of the fill hole with the cart sitting level. It holds less than a quart.
What kind of fluid goes in a rear differential?
There are two types of differential fluid. One is mineral oil, which is a natural, crude oil-based fluid. The other is synthetic differential fluid, which is created in a lab.
What gear oil should I use in my differential?
75W90 GL-5 Gear Oil The go-to gear oil for most differentials.
What kind of diff fluid do I need?
Use the highest-quality gear oil you can afford to fill the differential. The weight and capacity will be listed in your owner's manual; your differential will usually hold as much as 3 quarts. Be sure to read that manual, though, because some limited-slip differentials require a secondary friction-modifying additive.
How do you fill an ezgo TXT differential?
0:241:112002 EZGO gas golf cart Rear differential 80/90 weight oil changeYouTubeStart of suggested clipEnd of suggested clipAt the top see this yellow tab there that is a plastic plug. And you pull that plastic plug out andMoreAt the top see this yellow tab there that is a plastic plug. And you pull that plastic plug out and you fill it up with gear oil up to this hole right here.
How much oil does a 14 bolt rear end take?
How Much Gear Oil Does A 14 Bolt Axle Need? The gear oil capacity of a 14 bolt axle is either 3.6 quarts (full float) or 2.75 quarts (semi-float).
What rear differential do I have?
Stamped Number on the Axle To figure out exactly what axle you have, you can look for the Dana stamped bill of materials number. This stamped number can usually be found on the righthand side or on the longer axletube on the same side of the tube as the differential cover, facing the rear of the truck.
What happens if you use the wrong differential fluid?
Using the wrong diff fluid will cause poor lubrication, system overheating, and possibly, differential failure. Even a master mechanic may not reverse the damages by flushing the fluid. It'll require replacing the damaged components and refilling the diff with the recommended fluid.
Is axle oil and gear oil the same?
Well, yes, they are all gear lubricants, but no, you can't just use them interchangeably. Axles, differentials, final drives and other gear sets used in mobile equipment applications all require specific lubricants designed for the heavy loads and the sliding and rolling forces associated with the operation of gears.
What oil is used in a limited slip differential?
Full Synthetic 80W-140 Heavy Duty Limited Slip Differential Oil (SYN80W140) Is an extreme pressure API GL-5/GL-6 and API MT-1 limited slip and conventional differential oil, with superior high temperature stability when compared to mineral differential gear oils. It is the preferred substitute for SAE 85W-140.
How do you put oil in a golf cart rear end?
0:282:06Yamaha Drive 2 Quietech Golf Cart Rear Diff Oil Change - YouTubeYouTubeStart of suggested clipEnd of suggested clipPlug. Once your oil is done draining. And you have reinstalled your drain plug you can then removeMorePlug. Once your oil is done draining. And you have reinstalled your drain plug you can then remove the rubber fill plug this unit holds 16 ounces of gear oil they recommend an 80 90 weight.
How much oil does a EZ Go golf cart take?
The typical engine oil which is used in most of the EZGO carts is 10W-30 and 10W-40. The oil capacity of an EZGO cart is around 6 cups.
How do you grease an ezgo golf cart?
The suspension in EZ Go can be greased manually by following these steps:Remove the cap on the front of the rear axle.Turn the wheel anti-clockwise until the cap is off.Remove the grease inside the cap.Pour the newly purchased synthetic water-resistant grease into the cap and replace it.More items...
How much oil does an EZGO cart use?
EZGO uses 30 weight oil in the rear end. You fill it until the oil comes out of the fill hole with the cart sitting level. It holds less than a quart.
What oil does an EZGO use?
If your talking about the gasket for the pan on the rear end EZGO just uses silicone. The service manual calls for 30 weight oil but a lot of guys use 90 weight gear lube.#N#There's a EZGO steering box diagram in the EZGO resource section of the forum.
What oil does an EZGO golf cart use?
The engine of a EZGO golf cart uses 10W-30 grade engine oil. This oil which can be directly poured in-car effectively at lower rates. The primary variants of EZGO golf carts run on electricity; however, there are a few variants that run on gas as well. The EZGO golf cart is primarily used in the community nowadays.
How long does an EZGO golf cart last?
The limit of 125 hours is a direct implication on the fact that an EZGO vehicle must be used or operated for around 125 hours before its engine oil needs to be replenished. Purchasing an EZGO golf cart is considered to a one-time investment which can last for years.
Does the Ezgo golf cart have an oil filter?
In every EZGO golf cart; there is an oil filter present presumably at the bottom of the vehicle. The oil filter needs to be removed so that you can successfully drain out all the oil from your vehicle. Pour in some diesel into the system and spin the motor for a couple of minutes.
Is the Ezgo Marathon fast?
The EZGO Marathon golf cart is usually very slow and is not capable of running faster, thus the name. However, these golf carts do have the reputation of being quite sturdy and sticking around for years without causing any problems to the owner or any technical issue in general.
How to check if your cart needs fluid oil?
Check if your cart needs fluid oil. Ensure the belt is not worn out; if it is, then replacing it could stop the noises. Check if the clutch shaft is alright. If it is damaged, then it will become loose whenever the clutch will open and start making noises.
Why does my EZGO make a noise?
Why is my EZGO making noises from the rear end? The main reason a EZGO cart can start making noises in the rear end is because of loose bolts, or because the input shaft splines are dirty and need to be greased. Check the input shaft splines of the motor as over time they need to be cleaned or greased.
Why does my golf cart make a noise?
The common reason behind any sounds occurring from the rear end of a golf cart is damaged Motor bearings. But it is also for a coach to make noises after a certain period of usage. Well, when a cart gets old, it requires extra care anyway, so let’s get started.
Is a golf cart dangerous?
A golf cart making weird noises is a very common issue. Sometimes, these noises reach such a high pitch that it becomes beyond annoying. If the cart is making whining noises, then it’s not that dangerous.