Golf-FAQ.com

what make a feul pump work on a yamaha golf cart

by Dr. Ralph Littel DDS Published 2 years ago Updated 2 years ago
image

The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart. Click to see full answer.

As the crankcase runs, it produces a pressure at the bottom of the piston of the cart. This pressure is also known as a “pulse,” and must be balanced carefully to keep a golf cart running smoothly. As this pressure builds, it produces a power that goes through the vacuum line of the engine and to the fuel pump.

Full Answer

How does a fuel pump work on a golf cart?

While cars and gasoline-powered golf carts both have fuel pumps, the two operate very differently, so we've put together a short guide to help you know how to check your fuel pump — and what to do if you're worried it isn't working correctly. Your golf cart's fuel pump is essentially vacuum-powered using crankcase pressure.

What is the fuel pump pressure on a Yamaha G2 cart?

An electric fuel pump in a Yamaha G2 cart often has a low pressure of 3 to 5PSI with 1/4-inch lines. In some cases, the fuel pump gets activated when the fuel pressure is lower than 2PSI.

What should I do if my Yamaha golf cart runs out of gas?

If the fuel filter of a Yamaha golf cart is empty, disconnect the fuel line coming from the carburetor followed by a turnover of the motor. This should release a stream of fuel. After this, consider pulling the vent out and sucking through it. This will help to clear blocks in the vent if any. What Happens If my Golf Cart Runs Out of Gas?

Why is my golf cart fuel pump leaking oil?

Like a gas leak, the golf cart fuel pump should also be tested for oil leaks in the lower part of the engine or crankcase. This usually happens because of a defective case gasket or crankshaft seal.

image

How does a Yamaha golf cart fuel pump work?

The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart.

How do you fix a fuel pump on a golf cart?

10:2015:25Fixing My EZGo Golf Cart New Fuel Pump, Cleaned the Carb and it Runs!YouTubeStart of suggested clipEnd of suggested clipClean it up a little bit stick the new one on and we'll see what happens after a little bit ofMoreClean it up a little bit stick the new one on and we'll see what happens after a little bit of messing with it. The new fuel pump doesn't seem to want to like suck the fuel out of the fuel.

What causes a petrol pump not to pump?

Fuel pump failures can be caused by electrical faults, old age (wear) or fuel contaminants (dirt, moisture or bad gas). Fuel pump failures often occur without warning. Fuel pump failures can be caused by electrical faults, old age (wear) or fuel contaminants (dirt, moisture or bad gas).

How do you test a pulse fuel pump?

1:122:37How To Diagnose An Impulse Fuel Pump - YouTubeYouTubeStart of suggested clipEnd of suggested clipBut it's that simple these things are not hard to understand guys anybody can do this. Just checkMoreBut it's that simple these things are not hard to understand guys anybody can do this. Just check for fuel if there's no fuel coming out. Check your impulse line if you've got a good pulse.

How do you know if fuel pump is bad on golf cart?

Fuel Pump Problems The simple answer is the engine doesn't run as well as it should. More specifically, you may have trouble with your engine at low speeds, or it may lose power at high speeds. If your clog is especially bad, the engine sputters to a halt or may not even start.

Why is fuel not getting to the carburetor?

float may be stuck in the closed position or if carburetor equipped with a electric shut off/solenoid it could be faulty/stuck/bad connection. Now if you are getting fuel to carb. and the bowl is filling, either the jets are clogged or you have not adjusted the screws out to the proper settings to allow fuel to flow.

How do I get my fuel pump to work again?

1:164:17How to Fix Your Car (Briefly) with a HAMMER!!! - YouTubeYouTubeStart of suggested clipEnd of suggested clipBut here's a really quick way to tell if you've got a bad fuel pump take your hammer and strike theMoreBut here's a really quick way to tell if you've got a bad fuel pump take your hammer and strike the fuel tank in the middle. Then try to start the vehicle. Again.

What happens when a fuel pump doesn't work?

3:003:40THIS REALLY WORKS!!!!!!! Bad fuel pump, fuel pump relay, no fuel ...YouTubeStart of suggested clipEnd of suggested clipBut here you can see we just spray a little bit in the intake when the engines not getting fuel fromMoreBut here you can see we just spray a little bit in the intake when the engines not getting fuel from the tank.

How do you troubleshoot a fuel pump?

4:255:32How To Diagnose A Fuel Pump Failure - EricTheCarGuy - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd see if we're getting a signal or voltage to the fuel pump itself right and if it is then we canMoreAnd see if we're getting a signal or voltage to the fuel pump itself right and if it is then we can reasonably assume that the fuel pump needs to be replaced right Thank You Shane healty.

How do you check a fuel pump without a pressure gauge?

Disconnect the hose coming from the pump to the filter and block the passage of the hose tightly with your finger. You can then start the car. If you feel that the fuel is pushing your finger hard, it means you have good pressure.

Can you put an electric fuel pump on a golf cart?

The short answer is yes, you can put an electric fuel pump on a golf cart.

How does Mikuni fuel pump work?

0:120:59Identify your Mikuni style fuel pump ports. Input, output, and pulse.YouTubeStart of suggested clipEnd of suggested clipAnd there's little arrows pointing in that direction. And little arrows right there pointing in thisMoreAnd there's little arrows pointing in that direction. And little arrows right there pointing in this direction so the p is for the pulse that's what drives the pump that goes to your engine.

Why is my fuel pump not working?

Fuel issues aren't always caused by the fuel pump. Performance problems could also be caused by issues involving the crankcase or engine. A leaky crankcase or damaged engine cannot produce effective power. You'll want to take a look for signs of an oil leak, a bad crankshaft seal, or issues with the case gasket.

What is crankcase pressure?

While the more generally recognized term "compression" refers to the pressure limits at the top end of the engine, crankcase pressure actually refers to the pressure present at the bottom end, below the piston. While the pistons move up and down, the crankcase pressure will vary; we call this a "pulse.".

Do golf cart fuel lines deteriorate?

Rubber vacuum and fuel lines will eventually deteriorate. This issue is far more common in older and pre-owned golf carts and ATVs that haven't been given regular tune-ups. If you're having problems with the fuel not making it to the carburetor, check the lines very closely.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9