- Oil Problems With Your Cart. The most likely trigger for a smoking golf cart is oil problems with your cart. ...
- Crankcase Issues. The crankcase is a critical part of your engine that can run into problems if you aren’t too careful.
- Clogged PCV Valve. ...
- Worn Out or Broken Piston. ...
- Common Valve Problems With Your Engine. ...
Why is my golf cart blowing smoke?
This oil then goes into the vent tube back into the carburetor and blows oil into the intake of the carburetor causing your cart to blow smoke. Fill your engine with the correct amount of oil. If your carts muffler has oil in it, it will blow out smoke. If you’ve got this problem, run your cart hard on a long run to the oil out of the muffler.
Why does my G16 carburetor smoke?
If your oil smells like gas and is too overfull then gas will get dumped into the crankcase of your G16 and cause smoking. This is usually caused by a carb float or fuel pump that needs to be either mended or replaced. Sometimes if you’re lucky, just cleaning your carburetor will fix your carts smoking problem.
Why is my golf cart burning oil?
Your golf cart is burning oil because it has too much oil in the airbox. If your oil is overfilled, then drain it out and put in exactly one quart of oil into your cart engine. You may have overfilled your cart with oil because your dipstick has an incorrect full marking.
How do I Stop my G22 golf cart from smoking?
Replacing the fuel pump, fuel filter, spark plug and air filter of your cart can also fix smoking problems. If your G22’s oil is overfilled then it will smoke. Drain the old oil and clean out your airbox if there’s oil in it. Then fill in exactly one quart of oil to your G22. This should fix your smoking issue.
What causes a golf cart to burn oil?
A club car golf cart with a blown head gasket is the most common cause of the golf cart burning a lot of oil. The presence of accumulated dirt inside the gasket can also cause oil to burn. When a club car golf cart burns excess oil, your fuel expenditure shoots up drastically.
What causes a gas golf cart to backfire?
The golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the scale is out of adjustment and, in turn, stops the vessel from closing when the microswitch makes contact with the ignition.
Why is my gas golf cart running hot?
One of the most common reasons for the overheating is the dirty fins. The obstruction in the fins leads to excessive heat. The best solution, in this case, would be to first try to clean them, if that does not work, get them replaced. Another common reason for overheating can be the dragging breaks.
How do you clean a golf cart muffler?
How to clean golf cart muffler:First spray the inside of the muffler using the chamber cleaner.After a few minutes, scrub inside the golf cart muffler with the help of a brush.Place a container under the muffler to keep the carbon particles that come out from the golf cart muffler.More items...
How do you adjust the carburetor on a gas golf cart?
Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.
How do I clean the carburetor on my golf cart?
Spray the carburetor body inside and out with cleaner. Use the tube nozzle on the spray can to clean the jet ports, idle adjustment port and the choke plate. Use the bristle brush to clean dirt and deposits on the body. Wipe the carburetor with a dry cloth.
How do I fix my smoking golf cart?
Remove the valve with gloved hands to avoid getting stained by excessive grease or oil. Clean off the area where you are installing the valve and put the new valve in place. Tighten it down and your engine should stop smoking. If the clog is deeper in your engine or beyond the valve, you are going to need expert help.
What happens if a golf cart overheats?
Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you're trying to drive a race car.
How do you cool a golf cart engine?
The guys that race (very high speed) electric and also 2 stoke Radio Control boats use water to cool the motors / engines. Try some small diameter copper tube around the outside of the motor, one end is under water facing forward, the other exits behind. Some have the inlet behind the prop and exit above the water.
How do I remove carbon build up from my exhaust?
2:015:35Best Way to Clean Exhaust Tips – Removing Black Carbon BuildupYouTubeStart of suggested clipEnd of suggested clipIf you're dealing with heavy buildup where the polishing sponge is ineffective. You can abandon theMoreIf you're dealing with heavy buildup where the polishing sponge is ineffective. You can abandon the polishing sponge in favor of some fine steel wool put the polishing soap on the steel wool.
How do you clean a clogged muffler?
A long brush with some soap and water may be all that you need to clean a clogged muffler. If the problem is serious, some degreasing solution may help. You will know that you need this if cleaning the muffler with soap and water is not working. Put some degreaser on a towel and wrap the towel around the brush.
Can you clean the inside of a muffler?
Using a cloth, clean the exhaust tip, then for inside the exhaust, use a hard bristled brush, cleaning as deep in the tail pipe as you are able to. Applying a degreaser will help in breaking up carbon deposits and rust. Using a dry cloth, apply a degreaser to the inside and outside of the exhaust.
How do you adjust the carburetor on a EZ Go golf cart?
2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.
How do you adjust the throttle on a golf cart?
Pull the spring that is present around the plastic piece located behind the shifter. Spin it until it falls back. Loosen the throttle cable present in the cable box to adjust the extent to which you can take it out of the housing. Press the accelerator so that the golf cart starts up and begins to idle.
Why do I always have to choke my golf cart?
The carburetor jet is clogged resulting in the choke causing suction of the engine starting from the air cleaner right to the fuel bowl. To solve this problem, Dismantle the carburetor jet from the carburetor. Clean the jet thoroughly and check to see that there are no more clogs.
How does a fuel pump work on a golf cart?
The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart.
Why do golf carts smoke?
1. Oil Problems With Your Cart. The most likely trigger for a smoking golf cart is oil problems with your cart. These issues can vary depending on many factors, such as what type of oil you use, how much the oil has disappeared, and much more.
When do golf carts end up smoking?
For example, some golf carts end up smoking when they get old enough – you’ll usually see this issue when your cart is over 8-12 years old. And this development can be very scary and upsetting and typically has a handful of causes that you must watch.
What is a clogged PCV valve?
Clogged PCV Valve. The PCV valve is another engine part that must be carefully maintained to avoid excessive engine smoke in your cart. The exact purpose of the valve is to ensure that your fuel flows smoothly and doesn’t end up getting too hot in your engine.
Why are valves important in golf carts?
The valves on your golf cart engine are very critical for keeping it running smoothly and efficiently.
How long does a golf cart last?
A high-quality golf cart should run smoothly for years, even over a decade, before issues start occurring.
How do pistons work on golf carts?
The pistons on your golf cart help produce power by compressing your fuel and moving when the spark plug ignites the gas.
Can you see smoke coming from an engine?
And the smoke that you’re likely to experience is going to vary depending on many factors. For example, you may see an engine smoke slightly while you are running it or may see a large amount of smoke coming from the engine as it runs. The exact volume will vary, here, depending on the situation.
Why is your Yamaha gas golf cart blowing white smoke?
White smoke is caused by oil burning or “too full” oil condition in your engine. “Too full” oil condition is what happens when there’s too much fuel in your oil.
Why is your Yamaha golf cart smoking bad?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why is your golf cart burning oil?
Your golf cart is burning oil because it has too much oil in the airbox. If your oil is overfilled, then drain it out and put in exactly one quart of oil into your cart engine.
Why is your Yamaha G1 smoking?
Your Yamaha G1 is more than likely smoking because your muffler is clogged with oil and soot. The muffler becomes like this over time, especially if your car is only used in short bursts.
Why is your Yamaha G16 burning oil?
Your Yamaha G16 is burning oil because it has fuel in the oil. The first thing you should try to fix the burning oil problem is replace the old oil in your cart with exactly one quart of high quality oil. Hopefully this immediately fixes your problem.
Why is my G16 oil overfilled?
Your oil being overfull might be because you lifted your cart which causes your oil dipstick reading to be off (the full mark is incorrect). This causes you to overfill your oil. If your oil smells like gas and is too overfull then gas will get dumped into the crankcase of your G16 and cause smoking.
How to fix a muffler on a golf cart?
There are two ways to fix this problem; the first is to run your cart long and hard for 30 minutes to an hour and then let the cart cool off. The second is to remove your muffler and burn it out on a bonfire to clear up all the oil and soot in it.
How much PSI should a Yamaha G16 have?
I'd start with a compression test. The Yamaha G16 engine should have 150-160 PSI with the throttle held wide open while testing. Happy New Year!
How much oil does it take to fill a G16?
Take a look at the oil. When you change the oil in a G16, it only takes about a quart to fill it up. Measure what you drain carefully and see how much was there. If gas is present, the mix will smell funny and be “watery”.