Why does my golf cart cut out at full throttle?
A golf cart may cut out at full throttle due to a faulty solenoid that needs replacing, or having too low of a battery voltage. Solenoid needs replacing: It may be that the solenoid of the Golf Cart may have developed some glitches due to which it is not responding at full throttle.
Why is my golf cart surging at low speeds?
Why Golf Cart is Surging at Low Speeds A golf cart may be surging due to faulty batteries, faulty battery cables, or because the speed sensor connection has become loose. There are one or more bad batteries or battery cables. Check the battery pack voltage when the cart is stationary.
Does your golf cart cut out at high speeds?
Have you been experiencing any of the above issues with your golf cart? Some people have experienced these issues where the golf cart works properly at normal speeds, but cuts out when driven at high speeds. If your golf cart cuts out at high speeds, then you might have to take a look at the internal mechanism to figure out what the issue is.
What causes a golf cart motor to burn out?
Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you’re trying to drive a race car.
Why does my golf cart shut off while driving?
Why Does My Golf Cart Keep Shutting Off? When a Golf Car is shutting off without warning, it's because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly.
Why does my electric golf cart lose power while driving?
The main reason why a Club Car golf cart has no power is due to a faulty regulator or bad battery. One of the most common reasons could be a bad regulator and the connections to the regulator needs to be checked. The solenoid must have at least 12V charge while being operational which needs to be validated.
What causes a golf cart to stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. What is this? The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
What causes an electric golf cart to sputter?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Why does my gas golf cart lose power?
The main reason why a EZGO golf cart can lose power is because the battery is not charging due to loose cables or the corrosion of the connecting terminals. If they become loose or some of the electrical circuits' connecting wires snap, the battery loses power.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Why does my golf cart jerk when I accelerate?
Why does my Club car golf cart jerk when accelerating? The main reason why a Club car golf cart jerks when you accelerate it is due to a misaligned Inductive Throttle Sensor or dirty clutch.
What is the MCOR on golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
Why is my golf cart losing power up hills?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why does my golf cart quit?
motor burnt-out. One of the big reasons your golf cart could quit on you is that your motor burnt out. Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you’re trying to drive a race car.
Why won't my cart start up after resetting the motor?
However, if your cart doesn’t start up after resetting the motor, you are most likely dealing with burnout. If this seems to be the case, remove the motor from your cart and inspect it to see if there are individual parts like bearings, coils, or brushes that are just broken. You can purchase these parts for a pretty low cost ...
How to find out if your cart has a burnt out motor?
First, you’ll want to reset your motor. Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located near the main battery supply.
Where is the reset button on a cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you’re in luck!
Why does my golf cart spin out?
The brake bub will spin out when there is too much load to prevent any damage to the rear axles, causing the golf cart to stall on hills. Remove the covers from the rear wheel. Notice the castle nuts that are holding the hub to the axles. Apply the brakes.
Why does my golf cart stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. Batteries have lost charge. Faulty ignition. Problem with the direction switch. Faulty speed controller. Bad solenoid. The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
Why does my EZGO golf cart hesitate?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt. In case it has worn out too much, you can replace the carburetor.
How to check for leaks in golf cart?
You can check for any leaks by following these steps: Crank up the golf cart and check every seal for leakage. You can also spray wd40 at the clutch to find leaks. When the cart becomes hot, the voltage also drops. So, make sure you provide enough voltage to the batteries so the cart can run.
Why is my EZGO RXV hesitation?
In most cases, the hesitation problem occurs due to bad batteries. If you have bought new batteries for your EZGO RXV, make sure to fully charge them before the first use. Batteries should then be charged after every use. To keep the batteries in check, get a Digital MultiMeter to measure the individual voltage.
Why does my cart stutter?
If you change the battery, change the charger as well; otherwise, the battery will keep running down. If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor.
What causes a cart to heat up?
Weak batteries. Bad connection between the batteries. If there are loose connections, it will cause heating in the battery. To check, you can drive your cart for a while and feel the temperature in the cables and connections. If there is no heating, then check the individual voltages.
Why does my golf cart cut out?
A golf cart may cut out at full throttle due to a faulty solenoid that needs replacing, or having too low of a battery voltage. Solenoid needs replacing: It may be that the solenoid of the Golf Cart may have developed some glitches due to which it is not responding at full throttle.
Why does my golf cart keep turning off?
When a Golf Car is shutting off without warning, it’s because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly. It is best to use a voltmeter and check if the voltages ...
Why does my Yamaha G2 keep shutting off?
Yamaha G2 golf cart keeps shutting off: The Yamaha G2 Golf Cart may keep shutting off due to one of the following reasons: Loose solenoid wiring: The first check should be done whether the wiring on the golf cart is in right condition.
How to fix an EZGO golf cart?
The ways to fix a EZGO are stated below: Check the Solenoid contacts: The wires connecting the solenoid may not have electricity flowing due to which the Golf cart is getting abruptly shut off. It is recommended to change the wires connecting the solenoid and check if the problem gets sorted.
What happens if the voltage goes down on a golf cart?
Again, when the voltages go down, it will hit minimum and all the power that is gained shall be lost.
Why is my controller not connecting to the solenoid?
It is advisable to check the connections out there to check if the wires are getting disconnected.
Can you replace solenoid on golf cart?
Replacing the solenoid helps in most cases but it is advisable to get it checked at an authorized service center. Battery voltage is too low: In many instances, the batteries may not be carrying adequate amounts of voltage to keep the Golf Cart in running order. The voltages of the batteries should be checked via a voltmeter to see ...
Why does my golf cart blow out?
How to Fix Golf Cart Blowing Out (White Smoke) White smoke usually means your engine is running hotter than normal. If there’s a bit of smoke when you’re just starting the cart, it might just be the cart warming up. Excessive amounts of white smoke might mean there’s a problem with your cooling system.
Why does my golf cart spit?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
How to tell if your carburetor is dirty?
Lastly, it might be that your carburetor is too dirty. If your carburetor is dirty, your cart engine will sputter.
Why is my cart blue?
It might be a leaking valve which could lead to fires in your engine. Blue smoke might be caused by damaged rings in your engine. Check if the rings in your cart engine are busted and if they are, do a ring job and replace them.
What to do if your golf cart is spitting gas?
Lastly, if your golf cart is spitting gas, you may need to replace your air box. A relatively common problem is getting replacements that aren’t the stock air box for your cart. Something that most people don’t know or forget about is that if you’re using aftermarket filters, you absolutely must reset your carburetor.
How to get more speed out of golf cart?
Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts. If you install a tire with a larger diameter on your golf cart, the end result is a higher top speed.
How fast can a golf cart go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour . Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
How does a new battery work on a golf cart?
Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart’s motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart’s speed dramatically.
What is a series wound DC motor?
Series Wound DC Torque Motors are made with a larger field coil inside. A larger field coil inside of the motor , allows a larger magnetic field generation and holds the armature much more securely, thus producing greater torque. This is an excellent option if you're looking for more torque in your Club Car, EZGO or Yamaha golf cart, but are not so concerned about the speed.
What is torque in motors?
You know what 'speed' is, of course, but what is torque? Torque is the pulling power of the motor and is a function of current. So, basically, the higher the current, the more torque.
Is there a catch all solution to increasing golf cart speed?
A golf-cart weighed down by unnecessary clutter and debris is not a happy golf-cart! In closing, something to keep in mind is: There is no "catch-all" solution to increasing golf cart speed / golf cart power. There are many factors to consider such as, how the parts, pieces and changes interact with your golf cart.
Can you install a torque motor in an electric golf cart?
Essentially, installing a torque motor or speed motor may not be the end solution. With that said, something that you will want to keep in mind as you are upgrading, are the two main/major electrical components within your electric golf cart, that play a huge role in your golf carts system:
Reasons Why You Have to Choke Your Golf Cart to Get it to Start
The choke is used to inject fuel into the engine so that it can start. There are a few reasons why you have to choke your golf cart in order for it to start. Some of the most common are:
7 Common Fixes for having to Choke your Golf Cart all the Time
There are a few problems that you may experience with golf cart chokes. Being able to diagnose these problems and fix them will have your golf cart working better and result in you having to choke your golf cart less. Here are some common problems you may be experiencing with choking your golf cart:
Why Do You Need to Choke a Golf Cart all the time?
Your golf cart will not start on its own because no fuel flows into the engine until it’s running, so you need to choke your golf cart before it will start. A new engine should fire right up when flooded with gas. If you live in an extremely cold climate, the choke is critical for getting your golf cart to start.
How Many Times Should I Have to Choke My Golf Cart Before It Starts?
It depends on outside conditions and how much fuel is in the carburetor already. If your thermometer reads below freezing, choking will help get your golf cart’s engine going. If it isn’t that cold, but still cool, you should be able to start up normally as long as there’s enough gas in the carburetor.
When Should I Choke My Golf Cart?
Whenever necessary outside conditions call for it. If it’s cold or you haven’t started it in a while and your golf cart won’t start right away, you might need to choke it. Choking gets more important when temperatures are low since colder air contains less oxygen which makes starting engines more difficult.
1. Speed Sensor Issues
The speed sensor is an essential and critical part of golf cart operation that helps to ensure that cart runs smoothly and efficiently. It operates by measuring how fast you are driving and how much electricity is needed to maintain that speed. When the speed sensor ends up running into trouble, chances are your cart may end up running slowly.
2. Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
4. Bearing Encoder Issues
The bearing encoder is an essential part of your golf cart that provides you with careful electrical charge distribution throughout your cart. It works by encoding various elements of your cart's operation and translating them to different impulses to keep the power running smoothly.
5 Ampacity Controller Fault
The Ampacity controller is a part of your cart that helps to manage the amperage that produces and uses as your cart drives. When this particular part malfunctions, you're going to run into some issues with your cart operation.
How to Increase your golf cart speed?
Are you looking to increase your golf cart speed? Learn more about how to make your golf cart go faster.
Why is my golf cart surging?
A golf cart may be surging due to faulty batteries, faulty battery cables, or because the speed sensor connection has become loose. There are one or more bad batteries or battery cables. Check the battery pack voltage when the cart is stationary.
Why is my carburetor float blocked?
The float bowl is accumulated with water or dirt. Alternatively, the main jet may be blocked because of old bad gas varnish. Cleaning the float bowl and main jet may be a good idea. The carburetor bowl is misaligned or the gasket is worn out. Fix the bowl back in position and replace the gasket.
Why is my carburetor backfiring?
There is backfiring because of incomplete closure of throttle shaft, improper accelerator cables adjustment, damaged carburetor gaskets or loose connection of the nuts that connect the airbox to the carburetor.
What happens if you don't slack your cart?
If there is no slack, the cart will run at full throttle when you press the pedal lightly. The linkage before the front timing cover must also not be too tight. The connections between the motor and controller are either incorrect or corroded. In case of incorrect connections, redoing them correctly will suffice.
How to troubleshoot a Yamaha G16?
You can use the steps given below to troubleshoot a Yamaha G16 that surges. The carburetor is dirty due to dust accumulation. Remove it from its place and clean it thoroughly ensuring that the float bowl and the small air compressor are clean. Disconnect the fuel line and drain off the old fuel.
What happens if the butterfly valve is loose?
If it’s a loose connection, tightening it will solve the problem. However, you may have to replace the cable if it’s faulty or damaged.
Why are my pot pads burning out?
The contacts on the pot pads have burnt out. The water level in the batteries is insufficient. The batteries or their cables are old and due for a replacement. The connector of the speed sensor is not snapped tightly in position. The cables connected to the motor and the eyelets have become loose.
