Full Answer
Does your Yamaha g-16a golf cart get gas in the oil?
When I change the oil in my Yamaha G-16A golf cart I find that it contains gasoline. It's been getting gas in the oil for several years. I've changed carburetors. in the past, and had it serviced by a Yamaha dealer several times.
How to change rear end oil in a golf cart?
It fills with almost a full quart of oil. It is necessary to change the oil because the oil darkens and becomes dirty, causing harm to the golf cart. You first need to park your club car on a flat-leveled surface for a rear-end oil change. Take the plug out. Now you will be able to drain the rear end. Use the magnet to remove metal filings.
What kind of oil do you put in a Yamaha golf cart?
Some manufacturers recommend non synthetic oil only, so make sure to check with your golf carts manual to determine the correct type of oil to use. Here’s the thing: manufactures like Yamaha recommend that you only use non-synthetic oils in their gas golf carts.
Can you use the same oil for a golf cart and differential?
But you cannot think about using the same fluid as you use inside of your car engine. Almost every car or other vehicle manufacturer specifies the oil weight for the differential on the manual guide. In case you have an EZ-GO golf cart, it is the 30weight oil that you should use in the rear end of your cart.
What kind of gear oil does a Yamaha golf cart take?
What Kind of Oil Does a Yamaha Golf Cart Use? Yamaha recommends using the YamaLube non-synthetic 10W-30 oil for its golf carts. Any oil with a viscosity range of 10W-30 is suitable for any Yamaha Golf Cart though. Citing the splash systems used in these golf carts, Yamaha recommends using only non-synthetic oils.
What kind of oil goes in the rear end of a?
Differential fluid, also called gear oil, is the fluid that is poured into the rear differential housing. It needs to lubricate the clutches, gears, and bearings in the rear end. It also keeps all of those components cool so that all of the parts in the differential don't overheat and belt.
How do you check the oil in a Yamaha golf cart rear end?
1:052:06Yamaha Drive 2 Quietech Golf Cart Rear Diff Oil Change - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then mark where the top of your diff is at pull it back out. And then you can measure from whereMoreAnd then mark where the top of your diff is at pull it back out. And then you can measure from where the top was at you should be around five and a quarter to five and a half inches.
How do you change the oil on a Yamaha G16 golf cart?
2:228:18Yamaha golf cart oil change - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you were so to look behind the clutch let's see right there or my flashlight beam is that oneMoreIf you were so to look behind the clutch let's see right there or my flashlight beam is that one right there that's the 17 millimeter bolt you removed to drain all.
What weight oil goes in rear differential?
In a rear-wheel-drive car, the differential has its own housing and lubrication, a thick, dark oil usually heavier than 80 weight.
What gear oil should I use in my differential?
75W90 GL-5 Gear Oil The go-to gear oil for most differentials.
Does Yamaha drive 2 have an oil filter?
6:059:12Yamaha G29 Drive/Drive 2 - OIL CHANGE - Service - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo do not put car engine oil in these but these just hold one quart. So you're going to remove theMoreSo do not put car engine oil in these but these just hold one quart. So you're going to remove the fill cap.
Does a Yamaha G16 have an oil filter?
Yamaha golf cart engines do not have oil filters like many other makes. We carry these tune up kits for Yamaha G1, G2, G3, G5, G8, G9, G11, G14, G16, G20, G22, and G29 "The Drive" golf cart models.
What is 10W-30 oil?
The 10W30 designation on engine oil means that the viscosity of the oil is rated at 10W when an engine is cold, and 30 when the engine is hot. This is different than an oil labelled 5W30, which has a thinner viscosity when the engine is cold at 5W.
How do you adjust the governor on a G16 Yamaha golf cart?
Locate the cable nut that holds the cable to the throttle lever for a clutch cable governor. Adjust the main cable nut, holding it in place with the screwdriver. Turning the nut counter-clockwise will make the cable longer, allowing the cart to go faster. Turning the nut clockwise will reduce the vehicle's top speed.
How much oil does a Yamaha G16 hold?
The oil capacity of Yamaha G16 is lower than the Yamaha G2 and it can hold only around 1.16 US qt. The type of oil to be used remains the same; 10W-30 non-synthetic.
How long does it take to change the oil on a golf cart?
If you are a regular cart user, 150-250 hours of operation should take around 6 months. The timeframe for changing the oil in any golf cart depends on the time for which the cart is operated. If you can’t keep a track of your cart’s running hours, you can always turn to the dipstick oil level indicator.
How to check oil level on a cart?
With the cart on a level surface and engine a little warm, take the dipstick out. Clean it with a dry piece of cloth and dip it in to check the oil level. If the oil level is below the safe range, operating the cart without an oil change can leave the engine damaged.
Where is the drain plug on a Yamaha G16?
The drain plug is right under the driver seat in the Yamaha G16 cart. You can un-screw that using a 17mm drain bolt. Once the engine oil is completely drained out, screw the drain plug back in its position. Open the oil filler cap on the top side of the engine.
Is it bad to run an engine without oil?
It is important to ensure that the engine oil is not overfilled. Overfilled engine oil can disrupt the flow of oil causing severe damage to the engine. It is as harmful as an engine running without engine oil. Often the crankshaft comes in contact with the oil adding air in the oil flow system.
Can you use synthetic oil on a Yamaha golf cart?
The synthetic oil can prove to be too thin for Yamaha’s splash system mechanism. There are several synthetic oil options available in the market with the YamaLube being the most popular for Yamaha golf carts. Mobil 1 non-synthetic oils can also be used and are quite good with golf cart engines.
Synthetic vs Non-Synthetic
Here’s the thing: manufactures like Yamaha recommend that you only use non-synthetic oils in their gas golf carts. This is largely due to the splash systems used in their line of golf carts. However, I’ve found that you can essentially use any kind of oil as long as it has the right viscosity.
Choosing the Right Engine Oil
There are many excellent oil options available that should suit your gas golf cart well. Mobil-1 makes a non-synthetic engine oil that seems to complement gas-powered golf carts.
Wrap-Up
For the most part, checking and changing your golf cart’s engine oil is quick and painless. As long as you invest in the right viscosity, you shouldn’t run into any issues. However, if you want to play it safe, only use non-synthetic engine oil in your golf cart.
When to change oil on a golf cart?
The best time to change the oil is when the engine is still warm. The next step is to part your golf cart on a plane level. Turn the engine on and let it warm up for a while and then turn it off. Apply the brakes after you have turned off the engine.
What kind of engine does a golf cart have?
Club car golf carts are equipped with two kinds of engines. It is either equipped with an electric engine or a gasoline engine. A club car which is powered by a gasoline engine should be checked frequently and be handled just like any regular car. The oil should also be changed at proper intervals.
How to park a golf cart?
You first need to park your golf cart on a flat surface. Turn the engine of the golf cart off. Remove the oil cap located that is usually on the top of the engine.It is of a round shape. Place the oil cap in a safe place. Remove the dipstick that is located on the driver’s side.
How to remove oil filter from a cart?
Secure your cart with a block of wood or a floor jack. While the oil drains, remove the oil filter. Make sure to place the pan in front of the oil filter and the drain hole. Put the plug back to its place and place it firmly after the oil drains out completely. Now, take the new oil filter and put it on tightly.
How often should a golf cart starter be checked?
The engine of a gasoline-powered golf cart must be checked on a monthly level. After the first hundred hours of use of the golf cart, the filter and the engine oil must be changed.
How to change oil in a car?
You can change the oil easily by placing a funnel in the engine cap hole. Add the oil by passing it through the funnel into the engine. After you have added the oil, remove the funnel and put the cap back on properly. Start the engine and run it for about a minute.
How to get an O ring out of an engine?
While doing so, make sure that the o-ring remains in its place. Put the oil filter in a drip pan and let the oil drain out from the engine completely . Get a new oil filter for your engine and make sure that an o-ring is attached to the top of it.
