Golf-FAQ.com

what tempature will hurt golf cart batteries

by Rylee Lowe V Published 3 years ago Updated 2 years ago
image

For every twenty degrees below eighty degrees Fahrenheit, the battery will lose about ten percent capacity. Of course, this capacity will come back when the weather gets warmer, so this will not be a permanent loss for the battery.

Full Answer

Why does my golf cart battery get too hot?

Loose battery connections and dirty terminals are the main reason why your golf cart battery will get too hot. A battery that feels too hot while charging usually means that the water level is too low.

Should my golf cart batteries boil on the floor?

It should remain on a hard surface like the garage floor. There are multiple reasons for the water in wet cell batteries to boil. Sometimes, you may have more water in your golf cart batteries than what is needed. According to some studies, there should be a gap of ¼ inch above the plates. Sometimes, your golf cart batteries are old and worn out.

What happens if the battery in a golf cart dies?

If your batteries start to quit on you, the golf cart won’t move, or will drastically decrease in range. With a gas motor, the battery is what starts the motor and keeps it running by providing electricity to the spark plugs. Without it, your motor won’t crank.

Should I charge my golf cart battery every day?

If you don't have access to an automatic charger, just be careful to check on your battery and to turn the charger off as soon as possible after it's finished. Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery.

image

What temperature is too cold for golf cart batteries?

Although these fleets may not experience freezing temperatures, the cold temperature increases the resistance in the battery's chemistry and causes a reduction in battery capacity. A general rule of thumb for capacity is for every 15-20 degrees below 80 °F, the battery loses 10% of its capacity.

Can you leave an electric golf cart outside in the winter?

Golf carts can be stored outside for shorter and even longer periods. But one thing comes under consideration while keeping them outside and without any protection, i.e., they can quickly wear out. Golf carts left outside for weeks can cause severe exterior and surface damage and even sometimes become immovable.

Is it OK to leave my golf cart plugged in all winter?

No, it's not recommended that you leave your golf cart plugged in all the time. Although automatic chargers are designed to prevent over-charging, there is still the risk of the circuit breaker tripping, which would result in damage to your battery's cells.

How do I protect my golf cart batteries in the winter?

Keep them in a cool area and stay away from areas that are near heat sources such as radiators or heaters, since hot temperatures accelerate battery self-discharge. In addition, al- ways avoid areas where freezing temperatures are expected during the storage pe- riod.

Can you run a golf cart in winter?

Although driving a golf cart in the snow is possible, golf is not a Winter sport, so you rather store your cart for the cold period. However, do not wait for the snow to fall but prepare your electric golf cart for long-term storage when the leaves start falling and temperatures drop significantly.

Can you put a trickle charger on a golf cart?

If you tend to use the golf cart during the warmer months and store it during the winter, pick a trickle charger to make the battery last longer. These chargers connect to the battery over weeks or months at a time. They provide enough power to the battery to keep it charged but without harming the internal components.

Will electric golf cart batteries freeze?

Yes, golf cart batteries can freeze. There are a few factors that are going to affect how the golf cart battery freezes, and we will help try to explain that. A battery that is not charged is going to freeze at a much higher temperature than a battery that is charged.

How often should I add water to my golf cart batteries?

DO: You have to get your timing right. After charging your battery is when you want to add water. Adding water after charging prevents acid from spilling over. ... We recommend service once or twice a year. Always use distilled water so you don't add additional minerals into your battery.

Should golf cart batteries be charged after every use?

Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.

How long can golf cart batteries sit without charging?

An electric golf cart can sit for months without charging if the battery is at about 50% and not exposed to temperatures above 100°F during the storage time. If you leave battery power too high or low while parked, this will damage the battery cells and cause them to wear out sooner.

How do you store a golf cart for 3 months?

7 Tips for Long-Term Golf Cart StorageStep 1: Fully Charge the Battery. The typical golf cart is run by a 6-volt battery. ... Step 2: Disconnect the Battery. ... Step 3: Refill Water Level. ... Step 4: Secure the Cart. ... Step 5: Take Care of The Tires. ... Step 6: Make Sure it's Clean. ... Step 7: Store it in a Secure Place.

Can a golf cart be left outside?

Yes, golf carts can be left outside for both short- and long-term periods, though this does end up shortening their life if you choose to do so.

Why do golf cart batteries melt?

Why Do Golf Cart Battery Terminals Melt. The terminal of a golf cart battery will usually melt when connections become loose or dirty. To avoid terminals melting, ensure you use the correct size wires, and that limps, nuts and bolts are tightened securely.

How much torque does a golf cart battery need?

According to the majority of the golf cart battery manufacturers, the torque required falls between 85 to 100 and 5-inch pounds.

Why is my cart hot after charging?

Using your cart with a dry battery will cause heat damage quickly! Maintaining optimal water levels is a must. If you find your batteries becoming hot soon after charging, it may indicate low water levels. Don’t forget to check the cable connections as well.

Why does water boil in golf cart batteries?

Why Water in Wet-Cell Batteries Keeps Boiling While Charging. There are multiple reasons for the water in wet cell batteries to boil. Sometimes, you may have more water in your golf cart batteries than what is needed. According to some studies, there should be a gap of ¼ inch above the plates.

How far should the battery be from the plate on a golf cart?

According to some studies, there should be a gap of ¼ inch above the plates. Sometimes, your golf cart batteries are old and worn out. Such batteries fail to work efficiently and will eventually die. These factors will force your charger to add more pressure on the batteries to get them completely charged.

What happens if you use a dry battery?

Remember it’s crucial that you regularly check the water level in your battery. There is a line marked on the tank that indicates how much water is needed. If the amount of water in your battery is too low, then you’re working with a dry battery. Using your cart with a dry battery will cause heat damage quickly!

What is a post on a golf cart?

The post is associated with the cell plates of the golf cart’s battery. This helps in the transferring of power from battery to the engine of the golf cart. Remember that leaving connections loose or dirty can easily lead to some resistance.

Can you turn off the radio on a golf cart?

Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.

Can you use an automatic battery charger when it is fully charged?

It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.

Can you drive a golf cart up steep hills?

Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.

Should golf cart batteries be charged?

Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.

How to tell if golf cart battery is bad?

1. Charging Issues. First, check to ensure that your golf cart was charged before you took it out.

How to check if golf cart is charging?

First, check to ensure that your golf cart was charged before you took it out. Plug it back into the charger and follow the instructions. Just in case the charger is the issue, check that the battery charger is turned on. There should be an indicator light to show that it is charging the batteries. In the morning, disconnect ...

What hole does a golf cart stop dead?

It’s a real hassle if your golf cart stops dead and you’re only at the 15 th hole of play. Not only is this an embarrassing event, but it’s a major pain to have to arrange for the cart to be towed back to the parking lot.

Why won't my cart fire up?

But more often than not, your cart suddenly refused to fire up and go due to a dead or bad battery.

Can you top up golf cart batteries?

Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries. If this is the case, you will notice how several individual batteries have been “daisy-chained” together to form one large battery. 4.

Can you top up a golf cart battery with distilled water?

You need to leave enough room for expansion, so the acid should only be filled to just above the lead cells inside. Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries.

Do golf cart batteries last forever?

Golf cart batteries won’t last forever. In fact, each year they age a little bit closer towards their final use. If your battery is close to its warranty end date you may want to consider simply making the upgrade now.

What happens if your golf cart battery fails?

Obviously, for electric golf carts, the battery is what provides power to your motor. If your batteries start to quit on you, the golf cart won’t move, or will drastically decrease in range. With a gas motor, the battery is what starts the motor and keeps it running by providing electricity to the spark plugs. Without it, your motor won’t crank.

Why is my golf cart battery failing?

The most common thing that leads to early golf cart battery failure is corrosion. The problem goes deeper, too. It will ruin your cables, terminals, and even cause damage to battery trays and tie downs. Replacing a whole battery cable can be costly and difficult, so it’s best to avoid that problem.

How to clean corroded battery posts?

Undo the terminals from the battery posts and soak the corroded area in the cleaner or baking soda solution for about 5 or so minutes, then put on some gloves, grab your wire brush, and keep scrubbing until it’s all gone. Repeat as necessary, then rinse with a lot of water.

How does a battery work?

Your battery works by having two metals, a cathode and anode, react to each other to create chemical energy that we harness as electrical energy. With wet cell lead-acid batteries, these metals are kept in a liquid electrolyte, a liquid solution comprised of pure water and hydrosulphuric acid mixed to a set specific gravity. Other types of batteries typically use a gel, mat, or solid electrolyte to perform the same function. For the purpose of this topic however, the only battery we’ll be discussing is the traditional lead-acid battery, as this is the only type of battery for which you will have to worry about electrolyte levels.

Why is my battery puddled?

If your battery gets dirty, muddy, grimy, or anything else, make sure to clean that off too. These things can cause extra resistance in your electrical system, putting an unnecessary drain on your battery and shortening its life.

How long do batteries last?

All joking aside, every battery is different, but most properly maintained batteries will last about 4 to 6 years depending on usage, charge cycle, and a bunch of uncontrollable variables. Lead acid batteries will require a lot of maintenance to do so, however.

What happens when hydrogen gas is released from a battery?

Look for corrosion often, and neutralize it immediately. It’s a long and never ending war, but your wallet will thank you. Corrosion happens when hydrogen gases, released from your battery, mix with other chemicals and gasses in the atmosphere, and then bond to the metals of cables, terminals, and battery posts.

Why is a golf cart important?

It is the most essential type of equipment for golf. It helps to take away the golfers with their all playing instruments from one place to another in the green side of the golf courses. So this golf cart should be kept well charging while driving in the golf courses. Otherwise, the golfer can face trouble riding with this golf cart.

What is the most important part of a golf cart?

A battery is the most important part of any golf cart. If the battery will not fit well or will not charge up properly a golfer cannot ride this golf cart comfortably. So people should take proper care of this golf cart battery. All of the new golf cart batteries are good enough to drive for a long time. But day by day the battery of the golf cart ...

Can a golf cart battery be damaged?

So the battery can fully damage. It also increases the cost of the battery will be damaged fully. Overcharging the golf cart battery also affects the golf cart too. People also need more electricity while overcharging the golf battery. So we see that many problems will happen while overcharging the golf cart battery.

Can overcharging a golf cart cause damage?

Overcharging may damage your golf cart battery. It ruins the lifespan of the cart battery. The battery cannot give enough power to start the engine properly. Sometimes for overcharging batteries may heat up exceed level. So the battery can fully damage. It also increases the cost of the battery will be damaged fully.

Can you overcharge a golf cart battery?

People cannot overcharge a golf cart battery. This is seriously damaged the battery. This affects the worst impact on the golf cart battery. People think that overcharging a battery is helpful to hold more charges in the battery, maybe it will run for a long time with this battery.

Do you turn the lights on a golf cart when you stop driving?

Do not turn the Lights after they have Stopped Driving: They should avoid turning lights or radios of the golf cart when it is keeping on idle time. Leaving LED indicators light or radio also running on any idle golf cart it will affect the battery. The battery can run down quickly.

Can you charge a golf cart with an automatic charger?

Using this automatic charger they can avoid overcharging easily. So try to use an automatic charger while charging a golf cart battery. Otherwise, they should aware to check the battery while charging with a normal charger. If it is charged fully then they should disconnect the charger line as soon as possible.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9