Check if the charger is not plugged into the receptacle of the golf cart. The charger needs to connect with sockets within the replaceable. Examine the charger’s cable connections. Damaged cables will not be able to charge the batteries. Using an extension cord is not ideal for charging a golf cart.
Why won’t my 48 volt golf cart battery charger charge?
As a result, golf cart battery chargers for 48 volt Club Cars need a working OBC to get them to start charging. So, it is possible that your OBC is malfunctioning and it is not the golf cart charger. Again, this is only for 48 volt Club Car golf carts (Not for Yamaha or EZGO golf carts).
What size battery do I need to charge my golf cart?
Even if you are able to drive your golf cart and even if you just got brand new batteries, we'd suggest getting a 6V OR 12V CAR BATTERY CHARGER AND MANUALLY CHARGING UP THE GOLF CART BATTERIES FOR A COUPLE MINUTES EACH.
How do I know if my golf cart battery is bad?
To find out for sure whether your batteries are the culprit, you’ll need a Digital Voltage Tester to test each individual battery. You’ll want to completely charge your golf cart before testing. While the charger is running, test your volts every 15 minutes.
Why will my Club Car golf cart not charge?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
How do you test a Club Car 48 volt charger?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do I reset my club battery charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do I know if my golf cart battery charger is bad?
Bad Charger: IN GENERAL, if the charger kicks on, but doesn't charge fully or kicks off soon after, this is likely a charger issue. If the charger makes a loud clicking noise, this is likely a battery charger issue.
How do you test a 48 volt Club Car golf cart?
2:5915:0248 Volt Club Car Diagnostics - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd do that same test right on the two small terminals of the solenoid. Just like we did on theMoreAnd do that same test right on the two small terminals of the solenoid. Just like we did on the other cars that's exactly the same kind of test the solenoid is hidden under here.
How do you test a 48v golf cart battery?
Touch the voltmeter's negative probe to the battery's ground or negative terminal. Repeat this step with the positive side. Healthy batteries will indicate about 50 to 52 volts on the voltmeter. Most battery packs hold around 48 volts.
Where is the reset button on an electric Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
Where is the reset button on electric golf cart?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do I know if my club car is charging?
3:254:21Club Car New Advanced Chargers - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd status lights indicate when the vehicle is connected and charging the state of charge.MoreAnd status lights indicate when the vehicle is connected and charging the state of charge.
How can I tell if my battery charger is working?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
Is there a fuse in an electric golf cart?
Yes, golf carts contain fuses just like those found in a car or truck.
How do I know if my club car charger is working?
If the Club Car's computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse. If you check the fuse and it is okay, then you could also have a damaged relay, although this is rare.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do you test a power drive battery charger?
1:5218:30Testing Powerdrive Charger Parts - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou take your test leads. It doesn't matter which one you start with but in this case I'm going toMoreYou take your test leads. It doesn't matter which one you start with but in this case I'm going to start with a positive. And I'm putting it on the metal bracket this copper bracket.
How do I know if my club car is charging?
3:254:21Club Car New Advanced Chargers - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd status lights indicate when the vehicle is connected and charging the state of charge.MoreAnd status lights indicate when the vehicle is connected and charging the state of charge.
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
Step 2. Unplug your golf cart charger from your golf cart
If your charger is currently plugged in to your golf cart. Unplug the charger from the golf cart.
Step 3. Check AC power from wall outlet
Starting the troubleshooting process begins with checking the simplest to correct stages of the charging process first. In this case, we’ll begin by checking the AC power from your wall outlet to the golf cart charger.
Step 4. Check the reset switch on charger (if applicable)
After you’ve confirmed that your wall outlet is energized and providing proper power, quickly check if your golf car charger has a reset switch.
Step 5. Confirm charger is properly plugged into golf cart
After unplugging your charger from the golf cart and making sure your outlet is providing power, wait at least 20 seconds before plugging the charger back into the golf car. This is particularly important for Club Car vehicles equipped with an on-board computer (OBC).
Step 6. Check Battery pack voltage
The most common reason a golf cart isn’t charging has to do with an issue with the battery pack, battery cables, or a single battery. Well run through how to check for each issue.
Step 7. Test the charging receptacle
If your golf car battery pack is within the ranges above, but your golf car is still not charging with the golf cart charger, you may have an issue with your charging receptacle on the golf car.
Step 8. Test On-board Computer (Club Car only)
At this point, there are only a couple of components left that could be preventing your golf cart from charging. On Club Cars only, one component is the on-board computer, or OBC. This component is involved in the charging system on your 48V Club Car on troubleshooting this component will be discussed in a separate article.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How many volts does a battery charger need to charge?
When your charger can’t tell that your batteries are hooked up, it often won’t even turn on. A base charge of 25-30 volts is usually sufficient to wake up your charger and begin charging. To get around this problem, specific chargers offer modes that keep your batteries charged even when you’re not using them.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
What to do if battery is stuck at no charge?
However, if you’re stuck at no charge, a small, manual charger should provide each battery with enough juice to activate your regular charger.
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
How to keep a charger from getting hot?
But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight.
Why is my golf cart battery undercharging?
Undercharging: Undercharging caused by using a cheap golf cart battery charging system ( One that does not apply enough amperage in the charging cycle) can cause lead sulfate to gradually build up and crystallize on the plates greatly reducing the. battery’s capacity and ability to be recharged.
What is the specific gravity of a battery?
If the specific gravity measures between 1.100 and 1.220, the battery must be. recharged. If the specific gravity is between 1.225 and 1.265, the battery is ok to test. If the hydrometer has a temperature correction chart, be sure to adjust the reading for the battery’s temperature.
How to tell if battery life is nearing?
Draw electrolyte into the hydrometer several times to allow the thermometer to adjust to the temperature of electrolyte and note the reading. Observe also the electrolyte color. A gray or brown coloration shows that the end of your battery life is nearing.
What is a golf cart battery charger?
The battery charger is designed to bring a normally discharged battery back to full or nearly full charge in a given time.
How to tell if your golf cart battery is bad?
Symptoms of a failing battery or batteries could include the following: 1 You may notice the range decreasing over time. The range should be about 2 rounds of golf. 2 A “Shutter” is when the cart feels like you are running across a corduroy road or someone is tapping the brake in a rapid staccato. This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. 3 On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the controller not engaging when the voltage falls below a preset value. 4 It takes twice as long to charge your batteries as it did when you first had them installed. As the batteries age, they will not hold a charge as well as they used to. The charger has no way to know this and will continue to charge the batteries trying to get to a full charge – meaning it will take longer to charge the batteries than normal.
What temperature should a battery be when charging?
This will also initiate the equalizing charge. The batteries should begin gassing and bubbling. Keep the battery temperature between 115 degrees and 125 degrees.
What is a Trojan T-105 battery?
Trojan T-105 batteries are the best-known premium battery and have nearly 100 years of manufacturing experience. Trojan Battery Company was founded in 1925 and developed the golf cart battery for the Autoette in 1952. The distinctive maroon color of the T-105 makes it easy to distinguish from its competitors.
How many amps does a golf cart battery take to recharge?
To recharge, the batteries will require 90 ampere-hours + 20% to make up for any charge deficiency.
How to tell if your golf cart is low voltage?
You may notice the range decreasing over time. The range should be about 2 rounds of golf. A “Shutter” is when the cart feels like you are running across a corduroy road or someone is tapping the brake in a rapid staccato. This is a classic sign of low voltage.