You can try a nut spliiter to get the nut off. Also even if the stud is melted or broken the battery may be fixable. Drill a 1/4 inch hole in the center of the flat round lead surface right next to the melted terminal.
Full Answer
How to fix a leaking battery post on a golf cart?
Spray a protectant on the terminals and reconnect the power connections. The golf cart battery cables, terminals, and posts are all interrelated. So, it is almost certain that if either the cables, terminals, or both leaks, your battery post is likely to leak soon. A few reasons that could trigger a battery post leak are given below.
How to protect battery terminals on a golf cart?
Check out for a battery terminal protector from your golf cart parts store. This is usually available in the form of a spray. Spray a protector on all the terminals to prevent them from getting corroded. To save on money, you may have opted for less pricey cables or automobile cables for connecting the golf cart batteries.
How do you fix a loose battery post?
• Drill pilot hole in battery post no deeper than 3/4 inch. • Use appropriate size screw and washer to secure cable tight. A normal battery post and cable. You can see what a normal battery terminal looks like in the picture abovet. There is a threaded lug that sits in a lead tab. That is what had come loose.
When should you replace your golf cart battery cables?
Your golf cart battery cables must be attended to as soon as you notice them becoming hot. In most cases, the best solution is to replace the faulty cable or wire as soon as possible. What Causes Golf Cart Battery Terminals to Melt?
How do you fix a melted battery post?
1:4110:31Electric Vehicle Battery Post repair - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo you don't doesn't require a flame. Certainly there's potential for spark. So you want to makeMoreSo you don't doesn't require a flame. Certainly there's potential for spark. So you want to make sure that you've vented everything you got good fresh air flow.
How do I clean corroded battery terminals on a golf cart?
0:094:24Easily Clean Battery Terminals | Remove Battery Corrosion FastYouTubeStart of suggested clipEnd of suggested clipHow to clean off your corroded battery terminals to get started just mix up some baking soda andMoreHow to clean off your corroded battery terminals to get started just mix up some baking soda and water. And then you'll just get it on there a little bit you'll see it working already.
What do you spray on golf cart battery terminals?
How To Clean Golf Cart Batteries (In 6 Steps)Grab some baking soda, and mix it with warm water. ... Put your hose on a light setting, and start spraying off your batteries. ... With the batteries all sprayed, you should now pour your water and baking soda mixture over all of the terminals.More items...•
Can you replace battery terminal post?
4:279:56How To Replace Car Battery Posts/Terminals & Wires - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe bad control terminal posts were so destroyed and corroded I just have two new ones they'reMoreThe bad control terminal posts were so destroyed and corroded I just have two new ones they're actually really inexpensive. You can get them online or any auto park auto.
How do you clean battery poles?
0:132:19How to Clean Car Battery Terminals - YouTubeYouTubeStart of suggested clipEnd of suggested clipStep 1 rinse the battery terminals with a solution of one heaping tablespoon of baking soda to oneMoreStep 1 rinse the battery terminals with a solution of one heaping tablespoon of baking soda to one pint of water. And then thoroughly scrub the terminals.
What causes battery terminal corrosion on golf cart?
The recharging process of batteries produces gassing as a result of the breakdown of oxygen and hydrogen gas. This is the primary factor that causes corrosion on your battery cables, terminals, and other battery related metal parts.
Do you put water in golf cart batteries?
Fill battery cells (aka water fill holes) with distilled water (not tap water) ¼ to ½ inch above the plates. With ¼ inch of water you'll have to check your batteries more often, but at ½ inch you'll likely have more acid accumulation on the tops of the batteries. Either level is acceptable; it's really your call.
Can you hose down a golf cart?
Yes, you can hose down your golf cart. But this can easily lead to damage of electrical parts. Instead, create a mixture of water and dish soap. Then, use a microfiber towel to wipe down the various plastic surfaces.
How do you neutralize golf cart battery acid?
This can easily be done with a homemade mixture of baking soda and water. Mix 1 cup of baking soda per each gallon of water and spread evenly over the batteries. You know the acid will be neutralized due to a bubbling chemical reaction between the substances. Then, proceed by using water to remove the homemade mixture.
How do you remove corroded battery terminal nuts?
Cover the battery terminals and other corroded areas with a coat of baking soda. Then pour a small amount of water on each terminal. You'll notice the two ingredients react with each other when they start bubbling. This neutralizes the acidic corrosion and makes it safe to handle.
Do you put the positive or negative terminal on First?
“Positive first, then negative. When disconnecting the cables from the old battery, disconnect the negative first, then the positive. Connect the new battery in the reverse order, positive then negative.”
How do I remove a stripped battery terminal bolt?
Answer provided byUse pliers to wiggle the nut back and forth and loosen it. It should help it come off easier.Cut off the nut with a hacksaw. ... Buy a bolt removal tool like go2 socket that lets you adjust the size and grip of your socket.Use a bolt or screw extractor to pull it out.
Secret Male Removal Methods
I called a poker buddy who lives up the street and asked if he had a set. He'd misplaced his also (I nominate tap and die set as the most commonly lost tools in our community), and suggested just setting a screw into the lead.
Fixed!
We found an appropriate screw and a brass washer of the right size and screwed that cable down tight.
Epilogue
A few days later I drove down to our garden to pick some squash. Imagine my delight when I got back in the cart and found the battery meter flat at zero. Of course I cursed myself for taking the easy fix and called my wife to come get me.
Update
I was driving back from picking some late tomatoes at our garden when a loud POP from under the seat startled me. A few feet later, the cart drifted to a halt.