Yamaha G16 golf cart turns over but won’t start
- Checking if the crank case vacuum tube is lying disconnected at the back. If it’s not, then move on to the next step.
- Next verify if you have sufficient air and fuel lines in working condition.
- Next remove the grounding plug and check if you have sparks.
- If all of these are fine, consider removing the carburetor and giving it a thorough clean.
- Finally check if the throttle blade can be opened properly or not. If all of these fail, better take it to the nearest mechanic.
How do I know if my golf cart won’t start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting.
What to do if your Yamaha golf cart is not moving?
You can move the belt a little in its groove and do the test again. The starter bushes can also be the reason for the golf cart not moving. Check the controller if you find that your Yamaha golf cart’s solenoid is not clicking after you have installed a new set of batteries.
What to do if your G9 Yamaha golf cart won’t start?
Check the fuses and the fuse holder as well, to be doubly sure. If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
How to tell if a Yamaha golf cart battery pack is failing?
If the spin occurs doing the same test with a big jumper and on the larger posts on the solenoid, then the solenoid is not functioning. The absence of a spin in this test could mean your Yamaha golf cart’s battery pack is failing.
Why does my Yamaha golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Where is the reset button on a Yamaha golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Why did my golf cart just stopped working?
When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
Is there a reset button on Yamaha electric golf cart?
The Simple Motor Reset Process Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state.
Why does my gas golf cart not start?
As you can imagine, lack of fuel is the most common reason that gasoline golf carts don't start. This issue is incredibly simple to fix in most cases – just add fuel to the cart and it will start again.
How do you diagnose a golf cart problem?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do you start a Yamaha golf cart?
0:112:14How To Start a Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe have a shifter here that. Says. Forward neutral and reverse okay so what we do is we take the keyMoreWe have a shifter here that. Says. Forward neutral and reverse okay so what we do is we take the key. We move it to on we don't go anywhere we're actually on a slight hill.
How do you know if your golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
Where are fuses in Yamaha golf cart?
Yamaha Golf Cart Fuse Box Location The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
How do I test my Yamaha drive controller?
How do I test my Yamaha g16 speed controller?Keep the key on.Press down the accelerator.If you hear a clicking noise, the solenoid is working. Otherwise, there is a problem.Next, examine the controller for defects. ... If the wires are damaged, replace them to get back the speed.
Why does my electric golf cart have no power?
If you're lucky, the problem could be as simple as a loose wire or a broken coil. In some cases, corrosion can also be a factor. If you suspect a faulty solenoid, your best bet is to take your cart to a repair shop. A mechanic can diagnose the problem and replace the solenoid if necessary.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to tell if a battery is leaking?
It can begin with the batteries taking longer and longer to charge, and the charge they take, they don’t keep very long. Physical signs can include bulging sides, cracks or, in extreme cases, leaking battery acid. If the engine or motor turns over slowly, get out a multimeter and make this quick test.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
What to do if golf cart doesn't start?
If you find any moisture, you have to replace the plug. If the golf cart doesn’t start, you will want to clean the carburetor with some cleaning fluid. You can also take a look at the fuel bowl to check if it’s empty. If not, open and drain it.
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
Why does my golf cart keep turning but not starting?
Solenoid problems: A solenoid can wear out after using your golf cart regularly. A faulty solenoid can cause your golf cart to turnover but not start. Your golf cart solenoid is a coil of wire cylindrical in shape, but in reality it functions as magnet carrying electricity.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
Can a Yamaha G2 golf cart start?
Yamaha G2 golf cart turning over but not starting. A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark.
Why is my golf cart not starting?
The solenoid is a cylindrical coil of wire that works as the magnet carrying an electric current. This is a very common reason for golf cart’s not starting. Battery currents run to the motor through the solenoids, and you should always hear the solenoids clicking every time you press down on the accelerator.
What to do if you can't hear clicking on your cart?
If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up. If the level is low, you'll need to add distilled water, until the plates inside the battery are fully covered.
What is the key switch on a golf cart?
The key switch is the connector between the starter and the battery. Heavy use of the switch will eventually wear it out, so it's worth checking the key switch specifically if you're having issues getting your golf cart started. Check the area for loose wires or any broken pieces.
What to do if your battery is low?
If the level is low, you'll need to add distilled water, until the plates inside the battery are fully covered. Other battery issues, such as off-kilter wiring or corrosion and melted wires could be causing your ignition. If you find a leak, you'll need to replace the battery itself.
Can you replace a forward and reverse switch on a golf cart?
This is an easy fix — replacing the forward/reverse switch is a generally inexpensive and quick repair . You'll want to make sure you have an experienced golf cart service professional do so, though, as the use of electric wires could give you a pretty bad shock if you're not careful.
Do golf carts need to be repaired?
While golf carts are great for getting around your neighborhood, the golf course, down at the beach, or during a family or corporate event, they do have one serious downside — they will, just like any vehicle, eventually need repairs.
Can you repair golf cart brakes at home?
Many of the smaller repairs, such as adjustment or cleaning, can be done at home with what you already have in your tool box. You'll want to give us a call to make sure you order the right brakes for your particular brand and model of cart. Big repairs, like brake replacement, should probably involve bringing your golf cart in to be seen by one ...
Why won't my electric golf cart start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won’t start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
What is the best way to check if a golf cart battery is charging?
A Battery Hydrometer: A battery hydrometer measures the specific gravity of the electrolyte solution and can indicate whether or not your batteries are charging correctly. This method is inexpensive and reliable, making it a popular choice for golf cart owners.
How to reduce golf cart issues?
However, the best way to reduce your chances of golf cart issues, later on, is by performing regular preventative maintenance. With preventative maintenance, you can extend the life of your golf cart and potentially save money in the long run.
Why does my golf cart make a clicking noise?
The solenoid is a critical component of your golf cart because it is the main switch that connects the current from the battery to the traction motor. That clicking noise that you hear when you press the gas pedal is the solenoid.
How to test golf cart batteries?
Another method to test your batteries is by using a load tester. Battery load testers can come in a variety of different price ranges. They give golf cart owners the ability to monitor their battery’s voltage to see how much the volt drops during testing, which indicates the health of the batteries.
How to check if a battery is charged?
Make sure your batteries are fully charged, first, and then check for the following: 1 Any cracks or dirt in the batteries. 2 The water-electrolyte levels (on a weekly basis). If the water runs too low, it can shorten the life of your batteries. Overfilling can also result in a loss of electrolytes. 3 Look for signs of corrosion on your connectors and ensure that they are tight. 4 Dirt and other debris can affect the performance of your batteries. Clean them regularly with a bristle brush, water, and baking soda, but take care not to get any of the electrical components wet.
What to check before checking batteries?
Make sure your batteries are fully charged, first, and then check for the following: Any cracks or dirt in the batteries. The water-electrolyte levels (on a weekly basis).
Why is my Yamaha golf cart not moving?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid. The battery has to be checked first to see if it’s delivering the right voltage while in the idle state as well as when the pedal is pressed. There can be other reasons for the Yamaha golf cart not moving though you hear the click.
What to do if your G9 golf cart is not clicking?
If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
Why is my solenoid not clicking?
The reason why the solenoid is not clicking could be that it is faulty or has no grounding. Experts recommend checking all wiring and cable connections to rule out this possibility. Batteries on your G16 Yamaha golf carts should raise sufficient power to reach the solenoid and the starter/generator.
How to check solenoid on G9 Yamaha?
The solenoid can be checked using an old screwdriver to jump the terminals. Your G9 Yamaha golf cart’s key must be in the start position. If the starter turns when you do this, your solenoid needs to be replaced. You must be careful while doing this crude test; there could be sparks when the two terminals touch.
What is a faulty controller?
The controller is one major component that may have to be replaced. A faulty controller can stall the cart and the click you hear must be from the solenoid. Test the solenoid to see if it is functioning properly. You will require a multimeter, preferably a digital one, or a DVM for this.