How good is the automatic transmission on the Volkswagen Golf?
In the case instant, the Golf, the four-speed automatic transmission is a good one, if not great, and actually teams up pretty well with the new 1.8-liter turbocharged engine.
What kind of transmission fluid does a VW Golf use?
The correct fluid is a synthetic mineral oil, such as Pentosin ATF-1 or Volkswagen G 052 162 A2. 3.750 liters is usually sufficient for a filter change. The transmission fluid is checked from underneath the vehicle while running and the transmission in park. This must be completed before the transmission fully warms up.
What kind of transmission does a Volkswagen 01M have?
Volkswagen 01M transmission. The Volkswagen 01M transmission is an electronic/ hydraulic four-speed automatic transmission deployed in Cabrio, Jetta, Golf, GTI, New Beetle manufactured between 1995 through 2005, and transverse engine Passats manufactured between 1995 through 1997.
What kind of transmission is in a 2000 Jetta?
The GMR code transmission is the only one used behind the BHW engine. For what it is worth, until I found a replacement 5th gear, I used a 5th gear out of a gasser in my 2000 Jetta.
See more
How much horsepower does a 2000 Volkswagen Golf have?
90 to 150 hp2000 Volkswagen Golf / Horsepower
Do VW Golf have transmission problems?
While VW claimed that all the evils were fixed by the time the Golf 7 came out in 2013, experience suggests that there are still some examples of this gearbox giving trouble. Symptoms include a loss of drive, poor shift quality, shuddering on take-off and a gearbox that seemingly loses the plot on occasions.
What mk is a 2000 golf?
Golf Cabriolet (Mk3 platform)ModelYearsPower1.61998–200074 kW (101 PS; 99 hp) at 5,800 rpm1.8
How much does it cost to replace a VW Golf transmission?
VW Golf Transmission Cost The cost of a new VW Golf transmission could be over $3,500 depending on the vehicle, however, transmission services such as fluid changes and a transmission fluid flush are considerably less expensive, in some cases costing less than $150.
Which VW has gearbox problems?
The Volkswagen models that have been affected by these transmission problems and have been recalled by the manufacturer are the Jetta, Jetta Sportswagen, GTI and Eos. The problems are mainly due to a fault in the Direct Shift Gearbox (DSG) system.
How do I find my VW transmission code?
0:084:35Where to Find Audi VW Volkswagen Gearbox Code - ALL MODELSYouTubeStart of suggested clipEnd of suggested clipFor most LD m VW models the code can actually be retrieved from the build label. Which is located inMoreFor most LD m VW models the code can actually be retrieved from the build label. Which is located in the spare wheel well in your boots.
Are Golf MK4 reliable?
In all seriousness, the Golf has had an impressive reliability record. Early gripes about the V6 engines have been put to rest, and the entire range has yet to spawn any significant faults. Despite this, the Golf can never quite pip Japanese rivals in reliability surveys.
What years are MK4 golf?
Golf IV, manufactured between 1997 - 2003. In total, the fourth generation of the Golf, including all derivatives, was sold over 4.99 million times. Continuity leads to success.
What does MK4 mean VW Golf?
Volkswagen MK4/MKIV Vehicles As like the MK3's above, Volkswagen MK4 (MKIV) means fourth generation of a specific model (Jetta, Golf, GTI, or New Beetle). These vehicles were built on the “A4” Volkswagen platform (PQ34), or the MK4 (MKIV) chassis.
Is it cheaper to rebuild or replace a transmission?
A transmission replace is the most expensive option when fixing your transmission. In many cases you will hear this referred to as “re-manufactured.” Basically, the manufacturer will replace parts that have gone bad with modified parts. This is an option if the transmission is too damaged to even consider a rebuild.
Is it worth fixing a transmission?
Rebuilding a transmission can save you a lot of money over the short-term, while keeping car payments out of your monthly budget. For many, rebuilding their transmission is worth the initial cost. Rebuilding a transmission may cost you twenty-five hundred dollars or more, which is a significant chunk of change.
What transmission do I have?
The simplest way to find your transmission type is to look in your owner's manual. Your manual should have the name and type of transmission, along with service information. If you've misplaced your owner's manual, most trucks have a white label printed on the inside of the driver's door.
How much does a VW transmission cost?
VW Transmission Cost The cost of a new Volkswagen transmission could be over $3,500 depending on the car, however, transmission services such as fluid changes and a transmission fluid flush are considerably less expensive, in some cases costing less than $150.
Is VW Tiptronic reliable?
A tiptronic gearbox is as safe as any other gearbox - the only difference you'll notice depends on how you drive the car. Of course, if you're an unsafe driver, you'll be just as unsafe driving in tiptronic mode as you would be in automatic mode.
How do I reset my VW transmission?
Reset ProcedurePut the key in the ignition and turn on – Do not start the car.Hold down the accelerator pedal fully for at least 10 seconds (many suggest 20 seconds). You will feel a little click under your foot at you push down the pedal fully.Release the pedal – turn the key in the ignition.
Can you check transmission fluid?
Pull out the dipstick, wipe it clean, replace it slowly, and then pull it back out. Check the fluid level—how high the fluid comes up on the dipstick—against the "full" and "low" or "fill" marks on the dipstick. The color of transmission fluid can tell you a lot about the health of your car's transmission.
What is a certified child passenger safety technician?
Certified child passenger safety technicians conduct hands-on tests of a car’s Latch system and check the vehicle’s ability to accommodate different types of car seats. The Golf received the following grades on a scale of A-F.*
Can you pair a turbo with an automatic?
The only objection I have to pairing the turbo with the automatic is that if you’re shifting for yourself, you can better appreciate the rush of power that comes as the turbo spins up and starts passing air and fuel at a faster pace. Still, the torque curve is relatively flat for a pressurized engine.
Is the Golf 4 speed automatic good?
In the case instant, the Golf, the four-speed automatic transmission is a good one, if not great, and actually teams up pretty well with the new 1.8-liter turbocharged engine.
What transmission did VW use for the Mk3 Golf?
Before the 01M transmission, VW used the 096 four-speed for Mk3 Golf/Jetta cars from 1992-1994. These cars will have a SPORT/ECONOMY switch near the shifter or on the dashboard to alter the shift points.
What is 01M transmission?
The 01M transmission is a specialized transmission used only on Volkswagen vehicles, although very similar to the ones used on Renault vehicles. As a result, most local transmission shops or national chains won't have specific training, knowledge and equipment to test and re-machine vital parts of this transmission.
Is 096 a VW?
Both 096 and 01M VW transmissions are similar to the AD4, and many parts are interchangeable. Some of the 096 parts were held over for the 01M transmission, such as oil filter, oil pan, filler tube, gaskets, speedometer gears, skid plate, etc. These transmissions have different torque converters and other internal parts that are not interchangeable.
What is economy mode?
Economy mode endeavors to keep the engine revolutions lower to save fuel, while Sport mode allows the engine to rev higher before shifts, as well as shift faster with a sacrifice to economy. Changing these modes require transmission programming through a factory scan tool.
How many shift modes are there in a transmission?
There are three shift modes that the transmission can be set to which alters the shift points as well as the speed of the shifts (amount of transmission slip between shifts). Factory Mode, Economy/Touring Mode and Sport Mode.
Where is the transmission computer located on a Volkswagen Golf?
The transmission computer is located under the back seat on Volkswagen Golf Mk3 /Jetta/Passat models, under the right side dashboard cover on Volkswagen New Beetle models, and in the wiper area plenum on other Volkswagen Golf Mk4 /Jetta models.
Can a plastic speedometer break?
Occasionally, the plastic speedometer drive gear will break and fall off of the differential carrier and the speedometer will stop working. To repair this, the transmission must be removed and the differential disassembled far enough to replace the plastic gear.
How long does a transmission fluid change take for my Volkswagen?
If the transmission fluid does need to be changed on your Volkswagen, the time it takes will depend on how old the vehicle is and how complicated it is to change the fluid.
How often do I need to change transmission fluid on my Volkswagen?
Most people understand how important it is to change the engine oil and filters on their Volkswagen, but transmission fluid doesn’t always come to mind. The question of how often to get a transmission flush depends on a variety of factors.
How do I know if I need to change the transmission fluid on my Volkswagen?
Similar to the function that oil has in your engine, transmission fluid lubricates the moving parts in the transmission. When the fluid is worn out, contaminated or missing because of a leak, you’ll start to see – or, more likely, feel – problems with the way your transmission shifts.
Why do I need to change the transmission fluid on my Volkswagen?
Actually, the first question is “Do I need to change my transmission fluid at all?” For the answer, consult your Volkswagen Owner’s Manual. Unless there’s a leak or a problem, some newer transmissions are designed to never need a fluid change.
How do I check the transmission fluid on my Volkswagen?
The first thing to determine is whether you’re able to check the fluid at all. Many modern cars don’t have a transmission fluid dipstick, so the only person who can check it is a pro.
Overview
Successor
The 01M production ended with the last of the Mk4 body style Golf in 2006. It was succeeded by the Jatco JF506E transmission designed 5-speed automatic (09A) Tiptronic, and later an Aisin 6-speed automatic (09G) Tiptronic transmission in New Beetle Convertibles, as well as a Direct-Shift Gearbox (DSG) based dual clutch transmission in recent models of the above cars. The DSG does not have a torque converter, and is more akin to a pair of manual transmissions within a single h…
Design
The 01M and its predecessor 096 are very similar to the other transmissions engineered and manufactured by STA: AR4, AD4 and AD8, which were deployed on Renault vehicles in the 1980s and 1990s. It is an electronically controlled transmission with a lockup torque converter, using planetary gears, clutch packs, and a gear-driven final drive with an open-differential. There is no chain inside this transmission. It does not have provision for a dipstick. It was determined that a …
Weak points
Some areas of failure on this transmission include leaks in the oil filling tube by removing the cap incorrectly, damage to plastic internals due to fluid over-temperature conditions, leaks in the transmission oil cooler, internal fluid pressure leaks from torn piston diaphragms, worn piston bores for solenoids in aluminum valve body, and the resulting worn clutches and bands. Occasionally, the plastic speedometer drive gear will break and fall off of the differential carrier …
Replacement
If replacing this transmission with a new or used transmission, pay special attention to the transmission code. The code is a three character code stamped in a pad just above the starter flange. This transmission was available in several gear ratios for different engines and vehicles, so it's important to get a transmission with the same code or another code known to be the same gear ratios. If the gear ratios are not the same the transmission controller will assume the trans…
Rebuilding
The 01M transmission is a specialized transmission used only on Volkswagen vehicles, although very similar to the ones used on Renault vehicles. As a result, most local transmission shops or national chains won't have specific training, knowledge and equipment to test and re-machine vital parts of this transmission. This may result in several teardowns under warranty to get an acceptable result, if possible at all.
Checking and filling oil levels
The correct fluid is a synthetic mineral oil, such as Pentosin ATF-1, Mercon V or Volkswagen G 052 162 A2. 3.750 liters is usually sufficient for a filter change. The transmission fluid is checked from underneath the vehicle while running and the transmission in park. This must be completed before the transmission fully warms up (35-38°C). Once running, the drain plug on the bottom of the transmission oil pan is removed with a 5mm allen wrench. Some fluid will drip out whether o…
Transmission controller
The shifting of this transmission is controlled by the Transmission Control Module, or TCM. There are three shift modes that the transmission can be set to which alters the shift points as well as the speed of the shifts (amount of transmission slip between shifts). Factory Mode, Economy/Touring Mode and Sport Mode. Economy mode endeavors to keep the engine revolutions lower to save fuel, while Sport mode allows the engine to rev higher before shifts, as …