Batteries look to be in great shape, perhaps it is the meter on the charger that is not working properly or sticking. Try tapping the meter and see if the needle drops down. If not that then something is wrong with the charger (board).
Full Answer
Why won’t my golf cart charge?
The biggest one is a completely dead cart. If the batteries in your golf cart are so dead the cart will not run and drive as intended you will need to charge each battery individually with like an automotive charger with clamps to revive before your Ezgo Powerwise charger will kick on if it is operational.
How do I charge my golf cart battery?
When you plug in your charger to your cart it will fully charge the batteries. Once fully charged, the charger goes into its "storage mode" feature so long as it is connected to the golf cart and the wall.
What if the battery in my golf cart is dead?
If the batteries in your golf cart are so dead the cart will not run and drive as intended you will need to charge each battery individually with like an automotive charger with clamps to revive before your Ezgo Powerwise charger will kick on if it is operational.
Why won't my power wise Charger turn on?
The Power Wise charger must read an appropriate voltage from the battery before it will turn on. If the batteries are dead, the charger doesn't know what is connected to, and won't start
Why does my golf cart battery charger not turn off?
A golf cart charger will not shut off due to a faulty battery, faulty charger, damage to the power cable, or insufficient water levels in the battery. Bad Battery: In general, charging problems with batteries occurs when the battery is no longer in the space of fixing. It's time to change it.
Can you leave golf cart charger plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How do I know if my golf cart battery charger is bad?
Bad Charger: IN GENERAL, if the charger kicks on, but doesn't charge fully or kicks off soon after, this is likely a charger issue. If the charger makes a loud clicking noise, this is likely a battery charger issue.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
Can you overcharge golf cart batteries?
Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Some older models lack this important feature. If you must use a manual charger, don't forget to turn it off.
What happens if you leave a battery charger on too long?
A: If you leave the charger connected continuously, even at a mere 2 amps, the battery eventually will die. Overcharging a battery causes excessive gassing — the electrolyte gets hot and both hydrogen and oxygen gas are generated.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
How do you tell when a golf cart is fully charged?
1:574:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipMost will flash or blink during charging and present a solid green light when finished.MoreMost will flash or blink during charging and present a solid green light when finished.
How do I fix my golf cart charger?
0:476:46Fix Golf Cart Charger Club Car - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then pretty much anything you ever fix you're going to need pair of needlenose pliers. TheseMoreAnd then pretty much anything you ever fix you're going to need pair of needlenose pliers. These needlenose pliers are nothing special no certain size just a pair of needle nose pliers.
Where is the reset button on electric golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Where is the reset button on an electric Club Car golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
How do I know if my battery charger is working?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
What happens if a battery is dead on a power wise charger?
If the batteries are dead, the charger doesn't know what is connected to, and won't start.
Why does my charger plug have a dark spot?
This is usually caused by corrosion or bad connections in the charge plug handle. Open it up and inspect the connections. If you see a darkening of the terminals or corrosion, replace the contacts and tighten up the screws Make sure you do not loose the magnet when you open the handle.
Where is the charge control board located?
The charge rate is controlled by a control board located inside the charger case. If the charger won't stop charging when the batteries are fully charged, the control board is most likely faulty.
Why won't my golf cart charger shut off?
Why Does My Golf Cart Charger Not Shut Off? A golf cart charger will not shut off due to a faulty battery, faulty charger, damage to the power cable, or insufficient water levels in the battery. Bad Battery: In general, charging problems with batteries occurs when the battery is no longer in the space of fixing.
How to tell if a golf cart battery is faulty?
You will know if the battery is faulty or not very quickly. Check if there is any corrosion at the terminals. Check all the cables or wires of your golf cart; ensure that they are not damaged. Don’t forget to check the water levels in your batteries. They should not be lower than the plates.
Why is my golf cart not shutting off?
You should first replace the batteries and charger as these are the likely reasons why the golf cart is not shutting off. The relay might have been bypassed in the charger, or simply, it’s faulty. Maybe the control board of the charger is not in good condition. The “brain” of the charger might have been damaged somehow.
What is OBC on a golf cart?
OBC controls some of the crucial functions of a golf cart, so if it’s outdated, then some of your cart’s parts may not function correctly. Maybe the brain of your charger is failing. In that case, replacing it is the only and quick solution. Make sure if the fuse is alright or it has blown.
How long does it take for an EZGO battery charger to charge?
Why EZGO Battery Charger Won’t Stop Charging. A golf cart’s batteries can take up to 16 hours to complete its charge. This information can help you if you are giving up before 16 hours. You must know that if you have a 36v system, the charger charges the batteries up to 44-46 volts.
How long does it take for a charger to shut off?
The timer board in the charger does the job to shut the charger off after 16 hours, even if the batteries are not fully charged. Maybe buying a new board can fix the problem. It can be possible that somehow the pins in the charger have worn. Try holding it up by you after plugging it in and check what happens.
What happens if the ground wire is at the F2 terminal?
If the ground wire is at the f2 terminal and the wire comes from the solenoid is on the A2 terminal, the generator is active, so the regulator does not have enough time to shut the charger off. Somehow the key switch or the throttle switch is responsible for the overcharging.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How many volts does a battery charger need to charge?
When your charger can’t tell that your batteries are hooked up, it often won’t even turn on. A base charge of 25-30 volts is usually sufficient to wake up your charger and begin charging. To get around this problem, specific chargers offer modes that keep your batteries charged even when you’re not using them.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
What to do if battery is stuck at no charge?
However, if you’re stuck at no charge, a small, manual charger should provide each battery with enough juice to activate your regular charger.
Why are golf cart batteries corroded?
Usually with these older style transformer based golf cart battery chargers we find they are corroded due to extended periods of time left out in the elements. Some other issues occur when a lighting strike takes place and it can cause a Power Surge that will burn something up quite fast. Usually a fuse will pop first if you have a fusable link in the charger circuit but most chargers do not as is the case with your Ezgo powerwise charger.
What happens if your golf cart battery is dead?
The biggest one is a completely dead cart. If the batteries in your golf cart are so dead the cart will not run and drive as intended you will need to charge each battery individually with like an automotive charger with clamps to revive before your Ezgo Powerwise charger will kick on if it is operational.
What to do if you don't get the same voltage?
Now if you don’t get the same voltage you will need to back track the circuit from the charger receptacle to the batteries. Double check all the wires going back to the batteries… work your way backwards with the volt meter until you can narrow down the fault.
When it makes sense to replace a charger?
When it makes sense to replace. When it comes to spending time and money on something that you find yourself just standing there afterwards with your fingers crossed hoping it will work – it is best to just replace the charger. Now this comes with a few other caveats because when customers call over the phone and try to explain ...
How much does a power surge save in South Florida?
The power surge will just pop the breaker on the power strip but save you about $500 – $1000 dollars depending on what kind of cart you own.