This means the cart engine shuts down when going at max speed and comes back to life when engine RPM’s slow down. This usually happens because you adjust the governor too much or the governor spring is zip tied; adjusting the governor correctly and removing any zip ties will fix this problem.
Full Answer
Why does my golf cart shut down when I Go Fast?
This means the cart engine shuts down when going at max speed and comes back to life when engine RPM’s slow down. This usually happens because you adjust the governor too much or the governor spring is zip tied; adjusting the governor correctly and removing any zip ties will fix this problem.
Does your golf cart cut out at high speeds?
Have you been experiencing any of the above issues with your golf cart? Some people have experienced these issues where the golf cart works properly at normal speeds, but cuts out when driven at high speeds. If your golf cart cuts out at high speeds, then you might have to take a look at the internal mechanism to figure out what the issue is.
Do your golf carts die after driving for some time?
One of the most common complaints with golf carts is that it dies after driving for some time. Have you ever experienced this? You may have tried to make it run by getting the choke on.
How to fix a golf cart that won’t start?
If you are replacing your old magnet, you can buy a new high-speed magnet that can help enhance the speed of your cart. Another reason why golf carts can cut out is due to problems with the battery voltage or water levels. Check if the voltages in both the batteries are at the designated levels.
Why does my golf cart shut off while driving?
Why Does My Golf Cart Keep Shutting Off? When a Golf Car is shutting off without warning, it's because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly.
Why does my electric golf cart lose power while driving?
For example, you must make sure that your batteries are fully connected to ensure that they are able to send power. If their connections are loose, the power flow may not be properly connected and may cause your cart to sputter and drive poorly as it rides, losing power and stopping sporadically during each trip.
Why does my golf cart keep stalling?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. What is this? The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
How do you know if you have a bad solenoid on a golf cart?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do you remove the speed limiter on a electric golf cart?
0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
How do you check the voltage regulator on a gas club cart?
Testing the voltage regulator on a gas Club CarConnect the voltmeter to the battery and get the golf cart running. ... Check if the voltage rating is between 14 volts and 16 volts. ... Use a jumper and connect it from the ground of the cart to the stud of the starter generator.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my club car controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Will an electric golf cart run with a bad solenoid?
The ability of your golf cart to function properly depends largely on the solenoid. If the solenoid is broken and not working correctly, you may notice your golf cart won't start, picking up speed, or even working at all (issues with acceleration could also be caused by a bad speed controller).
How do I know if my ezgo golf cart solenoid is bad?
If You Have an Electric Golf Cart The main sign of an issue in an electric cart is a lack of any “click” noise at all when you turn on your cart's ignition. Usually, you'll be able to hear the solenoid clicking both on and off whenever you switch your ignition.
Why does my golf cart keep turning off?
When a Golf Car is shutting off without warning, it’s because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly. It is best to use a voltmeter and check if the voltages ...
What happens if the voltage goes down on a golf cart?
Again, when the voltages go down, it will hit minimum and all the power that is gained shall be lost.
Why does my Yamaha G2 keep shutting off?
Yamaha G2 golf cart keeps shutting off: The Yamaha G2 Golf Cart may keep shutting off due to one of the following reasons: Loose solenoid wiring: The first check should be done whether the wiring on the golf cart is in right condition.
How to fix an EZGO golf cart?
The ways to fix a EZGO are stated below: Check the Solenoid contacts: The wires connecting the solenoid may not have electricity flowing due to which the Golf cart is getting abruptly shut off. It is recommended to change the wires connecting the solenoid and check if the problem gets sorted.
Why does my golf cart cut out?
A golf cart may cut out at full throttle due to a faulty solenoid that needs replacing, or having too low of a battery voltage. Solenoid needs replacing: It may be that the solenoid of the Golf Cart may have developed some glitches due to which it is not responding at full throttle.
Why is my controller not connecting to the solenoid?
It is advisable to check the connections out there to check if the wires are getting disconnected.
Can you replace solenoid on golf cart?
Replacing the solenoid helps in most cases but it is advisable to get it checked at an authorized service center. Battery voltage is too low: In many instances, the batteries may not be carrying adequate amounts of voltage to keep the Golf Cart in running order. The voltages of the batteries should be checked via a voltmeter to see ...
Why does my golf cart spin out?
The brake bub will spin out when there is too much load to prevent any damage to the rear axles, causing the golf cart to stall on hills. Remove the covers from the rear wheel. Notice the castle nuts that are holding the hub to the axles. Apply the brakes.
Why does my EZGO golf cart hesitate?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt. In case it has worn out too much, you can replace the carburetor.
How to check for leaks in golf cart?
You can check for any leaks by following these steps: Crank up the golf cart and check every seal for leakage. You can also spray wd40 at the clutch to find leaks. When the cart becomes hot, the voltage also drops. So, make sure you provide enough voltage to the batteries so the cart can run.
Why is my EZGO RXV hesitation?
In most cases, the hesitation problem occurs due to bad batteries. If you have bought new batteries for your EZGO RXV, make sure to fully charge them before the first use. Batteries should then be charged after every use. To keep the batteries in check, get a Digital MultiMeter to measure the individual voltage.
Why does my golf cart stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. Batteries have lost charge. Faulty ignition. Problem with the direction switch. Faulty speed controller. Bad solenoid. The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
Why does my cart stutter?
If you change the battery, change the charger as well; otherwise, the battery will keep running down. If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor.
What causes a cart to heat up?
Weak batteries. Bad connection between the batteries. If there are loose connections, it will cause heating in the battery. To check, you can drive your cart for a while and feel the temperature in the cables and connections. If there is no heating, then check the individual voltages.
What happens if your golf cart doesn't accelerate?
Bad Solenoid. If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why is my golf cart not accelerating?
When your electric golf cart does not accelerate, the first thing you need to keep in mind is that it is not a regular vehicle like your car . That's why the methods and solutions you use to get your car to start are not the same as the solutions you can apply to your cart.
Why is my golf cart speed controller not working?
There are many reasons behind a speed controller malfunction. The most common problem that happens in the controller has aged due to infrequent use. These are just some of the issues that could be affecting your vehicle's acceleration. If you have trouble finding the issue of your golf cart accelerator, don't be afraid to take it to the mechanic.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What is a speed controller?
Speed Controller. The speed controller manages the speed of the golf cart. There are some situations when the speed controller fails, but the cart will still start and move ahead. But, as it runs for a while, it will start malfunctioning.
1. Speed Sensor Issues
The speed sensor is an essential and critical part of golf cart operation that helps to ensure that cart runs smoothly and efficiently. It operates by measuring how fast you are driving and how much electricity is needed to maintain that speed. When the speed sensor ends up running into trouble, chances are your cart may end up running slowly.
2. Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
4. Bearing Encoder Issues
The bearing encoder is an essential part of your golf cart that provides you with careful electrical charge distribution throughout your cart. It works by encoding various elements of your cart's operation and translating them to different impulses to keep the power running smoothly.
5 Ampacity Controller Fault
The Ampacity controller is a part of your cart that helps to manage the amperage that produces and uses as your cart drives. When this particular part malfunctions, you're going to run into some issues with your cart operation.
How to Increase your golf cart speed?
Are you looking to increase your golf cart speed? Learn more about how to make your golf cart go faster.
Why does my golf cart blow out?
How to Fix Golf Cart Blowing Out (White Smoke) White smoke usually means your engine is running hotter than normal. If there’s a bit of smoke when you’re just starting the cart, it might just be the cart warming up. Excessive amounts of white smoke might mean there’s a problem with your cooling system.
Why does my golf cart spit?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
How to tell if your carburetor is dirty?
Lastly, it might be that your carburetor is too dirty. If your carburetor is dirty, your cart engine will sputter.
Why is my cart blue?
It might be a leaking valve which could lead to fires in your engine. Blue smoke might be caused by damaged rings in your engine. Check if the rings in your cart engine are busted and if they are, do a ring job and replace them.
What to do if your golf cart is spitting gas?
Lastly, if your golf cart is spitting gas, you may need to replace your air box. A relatively common problem is getting replacements that aren’t the stock air box for your cart. Something that most people don’t know or forget about is that if you’re using aftermarket filters, you absolutely must reset your carburetor.
Why does my EZGO golf cart stop?
Why your EZGO golf cart stops suddenly? The main reason why a EZGO golf cart stops suddenly is because of a bad solenoid or low voltage levels causing a thermal cut.
What is the red wire on a golf cart?
The red wire with the connector is the bypass. Ensure that the solenoid gets started at one go and all wirings connected to it are in perfect order. In case of any sort of loose wirings or broken wires, that may cause the golf cart to malfunction and it may come to sudden halts at frequent intervals.
Do you need a key switch on a golf cart?
The key switch or the solenoid should be in perfect order to ensure the golf cart is working perfectly. Ensure there are no loose wirings in the solenoid, if the wirings get damaged then it is recommended to change the wirings. The RXV has been known to be very sensitive to battery voltage.