You will need to add a jumper from the ignition on /off switch to the tab on the bottom of the battery gauge which is a signal wire. This way the meter only comes on when you turn the golf carts ignition on. All of these meters are also clearly marked on back of the meter.
Full Answer
How do you hook up a battery gauge to a golf cart?
Now connect the signal terminal wire on the meter to the ignition. Add a jumper from the ignition switch to the tab on the battery gauge’s bottom. This signal wire will ensure that your meter starts working only when you turn on your golf cart.
Why won't my golf cart Charger charge?
If your cart's batteries aren’t hooked up in the correct way, or there's a weak connection between them, it can lead to a loss of power and cause your charger to fail. You should try and check each battery terminal for regularly for things like corrosion and buildup; these impede the flow of electricity, and could also cause problems.
How many amps does it take to charge a golf cart?
With that said, for a 48 volt golf cart, 13 amps has been found to be the right balance between charging speed and long-term battery stress. For a 36 volt battery charger, 21 amps is standard. You'll want to avoid purchasing a charger with low amperage (2-5 amps) as it will take forever to charge your batteries.
How do I know when to charge my golf cart battery?
Golf cart battery meters tell you when to recharge your batteries, so you do not end up draining them completely. There are two types of golf cart battery meters – Analog and Digital (usually LED). The analog meter uses voltage to move its needle to indicate the level of charge.
How do I know if my golf cart battery charger is working?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do you reset a golf cart battery meter?
Battery Meter Always Shows Full Reset the battery meter. Unhook power to the battery meter for 10 minutes. This will reset the battery meter.
Why is my golf cart battery charger not working?
If your batteries aren't hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
How do you reset an electric golf cart?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you tell if EZ GO charger is bad?
2:447:01Fix Golf Cart Ezgo Powerwise Charger - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd you only need to unscrew one of them and you can actually do a continuity test throughout to seeMoreAnd you only need to unscrew one of them and you can actually do a continuity test throughout to see if the power is going in both directions or not on top of that you also have a fuse here.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do I know if my battery charger is working?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
Can you leave golf cart charger plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
Where is the reset button on an electric Club Car golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
How many amps should my golf cart charger show?
The ammeter on a 36-volt charger should show at least 15+ amps when the charger is plugged into the golf car, even if the batteries have not been used for a short while. A 15+ amp reading shows that the charger is actually charging, not just humming (humming is NOT an indication that the charger actually works).
Why will my Club Car golf cart not charge?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
Do golf carts need batteries?
If you find that your golf cart won’t go very far on a full charge, then you probably need new batteries. Test them to make sure that the power on them is low; if indeed it is, then you need new batteries.
Can a club car monitor battery charge?
Only the club car can monitor the charge of your batteries, but it bears mention because these computers can fail, thus requiring a replacement. If the Club Car’s computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse.
How to get battery bank voltage on golf cart?
Note: Some models of golf carts will require wires run from the positive and negative terminals on the battery bank to get the battery bank voltage. An alternative is tracking down the input voltage on a golf cart voltage reducer that are on some custom golf carts that have other 12v accessories like stereo or lights.
How many volts should a battery meter indicate?
Should indicate approx. 48v or 51 volt or so if fully charged battery bank. Sometimes you can use those wires directly to the meter. If you mount the meter close enough to the switch, the factory wires will reach.
Why do we do a lot of Club Car Precedent model carts?
We do a lot of Club Car Precedent model carts because I like the aluminum frames and lower plastic accessories that are easy to replace and are readily available in the event of damage.
What is Club Car Precedent?
If you own a Club Car Precedent it will have an extra set of wires coming off the wire harness behind the dash and ignition switch. These wires are designed exactly for this type of battery indicator gauge or battery meter and will reflect the current battery bank voltage… Check with your multi-meter/digital voltage meter to be sure before connecting the prepared wires you are grabbing the correct wires.
Who installs golf cart battery meter?
Installing a golf cart battery meter should always be performed by a professional.
What does a golf cart battery meter tell you?
Golf cart battery meters tell you when to recharge your batteries, so you do not end up draining them completely. There are two types of golf cart battery meters – Analog and Digital (usually LED). The analog meter uses voltage to move its needle to indicate the level of charge.
How many volts does a golf cart battery need?
If your golf cart battery won’t hold a charge at all, and you see the meter flashing, this is cause for concern. EzyGo golf carts generally need at least 24 volts in the battery bank; otherwise the charger won’t even start. If you’re using a 12 volt charger, you’ll need to charge 2 batteries at a time to get the 24 volts of power.
How to reset battery meter?
Reset the battery meter. Unhook power to the battery meter for 10 minutes. This will reset the battery meter. If the meter sis still showing a “full status”, continue on to step 2.
What type of battery meters are used in golf carts?
Generally, there are two types of battery meters that go into a golf cart-Analog and Digital (usually LED).
Why is my Ezygo charger flashing red?
This could be due to a defective battery charger.#N#First make sure the connections are clean and attached tightly to the battery. You’ll then want to isolate each battery and check the voltage of each.
What does a digital meter do?
A digital meter uses LED to display the state of charge. A series of lights are shown on the display indicating the level of charge. More bars or lights indicate more charge while fewer bars or lights indicate a lower level of charge.
How to install a golf cart battery meter?
Steps to install a golf cart battery meter are: Select and obtain your battery gauge meter. Once you have the meter of your choice, select the mounting location. Disconnect the positive terminal on the battery bank. Prepare the opening if you are mounting in the dash. Run the wires from the meter location to the battery terminal points.
How does a battery meter work?
Battery meters indicate the voltage level of your battery bank and inform you when it is time to recharge. They act as a battery charge indicator as well and give a visual confirmation that the batteries are charging. The input voltage comes directly from the battery bank through the signal wires, and in the case of analog meters, move the needle from empty on the far left too full on the far right. The digital meters will give you a number or a moving bar display a partial charge to a full charge.
What is the C terminal on a battery meter?
Typical battery meters come with either two or three contacts on the back. One of these is a common or a “C” signal terminal and the other two are the positive terminal and the negative terminal (See illustration below). the “C” provides power to the meter to operate and doesn’t involve measurement input voltage at all. It is best to wire this terminal to the Power contact on the ignition switch. This will allow the key to switch the meter on and off when the cart is in use.
What is a battery meter?
A battery meter (or battery gauge) is a device you add to your electric golf cart to read the state of charge level for your battery bank. They come in either analog or digital, square or round, surface or in-dash mount. Battery meters indicate the voltage level of your battery bank and inform you when it is time to recharge.
How many wires are needed for a battery meter?
LED and digital style battery meters only come with about 6 to 12 in of wire pigtails, so you will need to add extra wire to reach the terminals necessary to power the meter.
Where do the positive and negative wires go on a switch?
Watch closely to make sure the positive wires go to positive terminals, and negative wires go to the negative terminal or ground. A lug connector crimped on the terminating end of the wire makes a professional connection on the switch and battery connection terminals.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.
How to choose a golf cart battery charger?
How to Choose the Best golf Cart Battery Charger. You must choose a battery charger according to the voltage of your cart to prevent the possibility of damage to your batteries. Check the charging receptacle of your golf cart and select your charger accordingly.
Where to check golf cart battery voltage?
Check the voltage at the plug point or receptacle on the cart. This must ideally be your golf cart battery pack voltage.
How Long Does it Take to Charge a Golf Cart Battery?
A new golf cart battery that is fully discharged will take 2-4 hours to completely charge. On the other hand, a 5 year old battery may take up to 10 hours to fully charge.
How to turn off golf cart battery?
Turn the ignition key of the golf cart to the OFF position. Although there is no battery draw when the key is left on, doing this is considered to be a safe practice.
How many volts does a golf cart charger have?
There are about 8 different types of charger plugs that you can find across various golf cart models. While some of plugs are exclusively for either 36 volts or 48 volts carts, others will work with both voltages.
What is the power of a golf cart generator?
The generator can charge the batteries that supply the power to an electric motor responsible for moving the cart. The 48 volts system in a golf cart usually features an onboard computer (OBC) that controls the battery pack charging process and restricts the charging when the cart is moving.
How to keep golf cart from accumulating?
Keep the golf cart where there is good ventilation to prevent gases from accumulating during the charging process.
Why is my golf cart charger not turning on?
This is because golf cart chargers get commands to turn on and off by receiving voltage back from the cart when plugged in. So, if your batteries have been run down all the way or left without charging for a long while, your charger may not activate when plugged in.
What happens if your cart battery isn't hooked up?
If your cart's batteries aren’t hooked up in the correct way, or there's a weak connection between them, it can lead to a loss of power and cause your charger to fail.
Why does my charger spark?
If the charger is active or plugged in before connecting the batteries, it may cause sparks to occur. Charging of batteries can give off flammable gas… so we want to avoid causing arcing or sparks during this process. Ideally, your charger will match your batteries individual voltage and you can charge them one at a time, just like so.
How many batteries does a golf cart have?
Because golf carts can have 6, 8, or 12 Volt batteries, you’ll want to pay attention to match that voltage on your charger if possible by setting it to the correct voltage or connecting it to the right number of batteries at a time to equal its voltage.
Can you charge a battery one at a time?
Ideally, your charger will match your batteries individual voltage and you can charge them one at a time, just like so. There is no need to disconnect battery cables, you’ll simply be sending low amp voltage into one battery at a time. Some owners may have to do some math here.
Can you charge two golf cart batteries?
You can charge two of them using this method, because you’ll be doing it for a short period of time on each battery or pair. We’re not charging the batteries all the way here, we’re just trying to get enough voltage in them to get your normal golf cart charger to do it’s job. Remember to turn the charger off or disconnect it from power each time you move the charger to the next battery.
What happens if the voltage is low on a charger?
Glad you got it going! Just a note though. If the incoming 110 volts to the charger is low, The efficiency of it's output is drastically effected. P=IxE, and so if E is low the charger tries to supply more I to produce it power to the battery back. This often happens with the use of long extension cords (or ones with to light of wiring) to supply the power to the charger. Just something you might want to take a look at. May not have anything to do with your situation, but just worth noting. I've had it happen myself. I was blaming the charger, and didn't realize that the incoming voltage to the charger was dropping down in the 90's. Another thing I would do, is ALWAYS start with a meter to determine the charge state of the battery pack first. You need to see what you are dealing with in there first. You can use the same meter (on AC instead of DC) to look at the 110 coming into the charger under it's load. Just a thought.
How long to charge a 12V battery?
The batteries are low you need to charge them with a 12 V charger 20-30 minutes each then try the charger again
Does EZGO golf cart have reed switch?
Your cart doesn't have a reed switch. EZGO uses them to prevent the golf cart from running while the battery charger is plugged in.
How to access battery compartment on golf cart?
Lift the seat of the golf cart in order to access the battery compartment. You may need to use a rope or bungee cord to secure the seat in the open position so that you can work freely within the compartment.
What is the color of the battery terminal?
The positive terminal will be marked with a "+" sign and is usually denoted by red color-coding. Connect a cable from the negative terminal of the first battery, which will be marked with a "-" sign and black if color coded, to the positive terminal of the second battery in the sequence.
What is the best way to prevent corrosion on battery terminals?
Coating the battery posts and terminal connections with petroleum jelly will help combat corrosion.
Can you replace a golf cart battery?
With a cart that has been used for a while, it may be necessary to replace the batteries. A new cart may not have batteries. Connecting a battery to your Club Car golf cart is a pretty easy task, as the wiring system for the batteries is fairly basic. Lift the seat of the golf cart in order to access the battery compartment.
Do you need batteries for a golf cart?
Golf carts have becoming increasingly popular for personal use in recent years. Many people now own their own golf carts for recreation. Electric golf carts require minimal maintenance. Batteries are the power source for the cart and these need regular charging.