Fuel pump began leaking again June 11, 2003 at @ 30,000 miles. Fuel pump had already been replaced after severe leakage due to cracked plastic housing September, 2000 at @ 19,000 miles. Fuel pumps should not routinely fail in such hazardous fashion each 15,000 miles -- under warranty or no.
Full Answer
How to replace the fuel pump on a Volkswagen GTI MkIV?
Replacing the fuel pump on a Volkswagen GTI MkIV can be done without removing the fuel tank. There is an access panel under the rear seat cushion that allows servicing. To access the pump you will need to first remove the rear seat. Please see our article on removing your seats.
Are there any problems with the fuel pump on a Volkswagen Golf?
Volkswagen Golf owners have reported 13 problems related to fuel pump (under the gasoline fuel system category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Volkswagen Golf based on all problems reported for the Golf.
Where is the fuel pump on a Toyota Corolla?
Figure 1 The fuel pump is located in the right side of the fuel tank. With the seat removed you will see the access panel to the fuel pump on the right hand side (red arrow). The carpet in our project car was going to interfere removing the access panel (yellow arrow) so I cut it back to give myself more room to work.
Where is the fuel pump on a Ford Ranger?
You can refill the tank with this fuel when the job is complete. Figure 1 The fuel pump is located in the right side of the fuel tank. With the seat removed you will see the access panel to the fuel pump on the right hand side (red arrow).
How long does a VW fuel pump last?
It takes gas from the gas tank and sends it to the engine so your car, truck, or SUV can start and run. Your vehicle's fuel pump should last at least 100,000 miles or more.
How do I know if my fuel pump is good?
The fuel pump should make an audible noise if it's working properly. Whack the fuel tank: Have an assistant crank the engine while you hit the fuel tank with a rubber mallet. If the vehicle starts during this procedure, it's a pretty clear sign the electric motor inside the pump is bad.
How long does the average fuel pump last?
The average fuel pump will last for about 100,000 miles, although I've seen my fair share of cars that still have their original fuel pump working just fine even after 200,000 miles.
When should the fuel pump be changed?
100,000 milesWhen to Replace a Fuel Pump. Fuel pumps are not a standard maintenance item. There's no set replacement interval, and many should last for 100,000 miles and beyond. If you're lucky, your fuel pump may last for the life of the vehicle.
How do you diagnose a bad fuel pump?
5 Bad Fuel Pump SymptomsYour car dies immediately after starting.Your car hesitates or is rough when accelerating.Your car dies/shuts off randomly while driving.You can hear your fuel pump making unusual noises.Your car won't start.
What causes a fuel pump to go bad?
The biggest reasons for a fuel pump to go bad are contamination, overheating, and wear. It's quite common for debris and dirt to make their way into a fuel tank, which can then get through the filter and into the fuel pump. These contaminants end up blocking the flow and puts an unwarranted load on the fuel pump.
Will a fuel pump throw a code?
Bad Fuel Pump, Fuel Pressure Sensor Can Trigger 'Check Engine' Light, P0087 Code. Your car's “Check Engine” or “Service Engine Soon” light can flash on for more than 1,400 different reasons.
Can a bad fuel pump damage engine?
Because the fuel pump is responsible for supplying the engine with fuel, issues with it can lead to major performance problems and costly auto repairs. Most fuel pumps eventually require replacement. A damaged or failing fuel pump will produce one or more of the following symptoms.
How do you maintain a fuel pump?
How to Make Fuel Pumps Last LongerJob of the fuel pump. Every modern car has an electric fuel pump located in the fuel tank. ... Taking care of the fuel pump to ensure its long life. ... Never keep the fuel pump empty. ... Do not get fuel with dirt. ... Change fuel filters. ... Add anti-ethanol agent.
How do I know if my fuel pump or fuel filter is bad?
When you turn your car on, it's completely normal for your fuel pump to make a low humming noise while it runs. If you sit near the fuel tank and listen, you may be able to hear it when it's running normally. However, if the fuel pump is working overtime to compensate for a bad fuel filter, it will start to wear down.
Why is my 1999 Volkswagen Golf fuel pump leaking?
1999 Volkswagen Golf, fuel pump was leaking because the supply fitting was cracked. This was caused by a manufacturer's defect, which caused a pool of fuel to form under the back seat. Also, fuel was leaking out of the vehicle onto the ground. The consumer found various websites that there had already been a recall 05v154000 concerning this problem. In addition, the consumer had found that there was a letter from NHTSA to Volkswagen of America, pea-04-079. Consumer contacted the dealership, they indicated that they did not know anything about the recall. When the consumer contacted the manufacturer, they told consumer that there was no recall. Fumes were causing the consumer and passengers headaches and dry eyes. Vehicle leaked fuel when the ignition was in the on position, when the driver's side door was opened and when the vehicle was running. D. Patrick motoplex located on 200 north green river road evansville, in, 47716, ph. No. 812-473-6500, was the dealership working on this problem.#N#See all problems of the 1999 Volkswagen Golf .
Why is there a recall on a 2000 Volkswagen Golf?
There exists a recall on this model for a problem with the fuel pump cracking due to a design fault. This recall was not honored because the vehicle was purchased in mexico. Volkswagen of America doesn't deal with any vehicles not purchased in the united states or canada nor do they attempt to deal with any other segment of Volkswagen worldwide.#N#See all problems of the 2000 Volkswagen Golf .
