Depending on the make and model of your cart, you can identify motor rebuild kits on golf cart parts and accessories websites. These are typically available for older model golf carts and are available for the likes of Club Car and Yamaha models.
Full Answer
What can go wrong in an electric golf cart?
Why your EZGO golf cart stops suddenly?
- Diagnostic mode: Try out the Diagnostic mode in the golf cart. ...
- Voltage readings: Check out the voltages that are being recorded by the batteries. ...
- Low voltage: The low voltage levels may also cause excess amperage which may end up in the controls to return to thermal cut.
How to modify golf cart?
- Fraction of power per weight compared to gas
- Possibility of fires or explosions if overcharged or overheated
- Can take hours to charge
Can You rebuild a golf cart motor?
It is possible to rebuild a golf cart motor for $300 to $500, while a brand new motor can cost between $600 and $1,000 without including the labor involved. How Long Do Gas Golf Cart Engines Last?
How to solve electric golf cart problems?
What can go wrong with electric golf carts?
- Troubleshooting Batteries. Like any electric vehicle, the battery is often the root of the problem.
- Ignition or Motor Issues.
- Solenoid Woes.
- Faulty Direction Switch.
- No Speed Control.
Can golf cart motors be rebuilt?
When the engine becomes difficult to start or you experience a loss of power and oil compression, you may need to rebuild the club car motor. By rebuilding the motor, you can avoid having to buy a new one. Disconnect the muffler, cables and any other component that attaches to the club cart motor.
How do you rebuild an electric golf cart motor?
1:005:27golf cart electric motor rebuild - YouTubeYouTubeStart of suggested clipEnd of suggested clipWell I'm going to show you quickly my technique for putting them on in case you're fixing your motorMoreWell I'm going to show you quickly my technique for putting them on in case you're fixing your motor and you're just having the hardest time. With this and it's pretty simple let me show.
What kind of motor does an electric golf cart use?
Electric golf carts have two different types of motor options: DC and AC motors. The first type was the most commonly used for years, but a growing number of cart manufacturers are shifting to AC motors.
How long do electric golf cart motors last?
Golf Cart Motor Just like solenoids (mentioned above), your golf cart motor works HARD. When properly taken care of, the typical gas or electric golf cart motor can last many, many years (20 to 30+).
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you test a Club Car electric motor?
13:2337:53Club Car 48 Volt Powerdrive Testing 1995-2013 - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition place the red positive probe on the speed controller M minus terminal place the blackMorePosition place the red positive probe on the speed controller M minus terminal place the black negative probe on the s2 motor terminal your vom should display continuity.
Are electric golf cart motors interchangeable?
The motors and controllers are in no way interchangeable between a series and separately excited system, so be sure to educate yourself prior to ordering.
What size electric motor is in a golf cart?
If you have an Electric Golf Car: Change the field coil in a 2-hp motor (a standard in golf cars) and it can become a 3.5 hp motor.
What would cause an electric golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
How do you test a golf cart motor?
4:0210:28Testing 36 volt golf cart motor with 12 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou're going to take the negative. And put it on the a1. Again i'm going to take the jumper cableMoreYou're going to take the negative. And put it on the a1. Again i'm going to take the jumper cable from a2 to s1 you're going to take the positive cable from the jumper.
Do golf carts hold their value?
Golf cart everywhere A product that is accepted by the majority in a market will hold its value because there will always be someone interested in buying what you have. The golf cart has universal application as it can be used by both old and young, rich and poor.
How many miles will a 48V golf cart go?
The maximum range of this new battery when powering a 48V E-Z-GO RXV golf cart is approximately 20.5 miles when moving at 12 miles per hour. In golfing terms, this equates to around 3 rounds or 54 holes.
How do you test a golf cart motor?
4:0210:28Testing 36 volt golf cart motor with 12 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou're going to take the negative. And put it on the a1. Again i'm going to take the jumper cableMoreYou're going to take the negative. And put it on the a1. Again i'm going to take the jumper cable from a2 to s1 you're going to take the positive cable from the jumper.
How do you remove an armature from a golf cart motor?
0:301:56How To Remove The Motor Armature - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what you want to do is get a hammer just like this and a flathead screwdriver. You want to justMoreSo what you want to do is get a hammer just like this and a flathead screwdriver. You want to just tap on the end no the front end. Oh. Coming out you guys what a wiggle. The armature gently.
How do you remove a golf cart electric motor?
3:169:45EZGO High Torque Electric Motor Swap | How To Install Golf Cart MotorYouTubeStart of suggested clipEnd of suggested clipOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock thatMoreOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock that gives you direct access. So you can unbolt it loosen everything and put it right out the side.
Do golf cart motors have brushes?
0:001:21Servicing golf cart motor / brushes - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo here's our motor of both car tension. And apart and you can see the end with the brushesMoreSo here's our motor of both car tension. And apart and you can see the end with the brushes commutator the housing with the magnets.
Mophorn 1800W Electric Brushless DC Motor Kit – 48V 5200rpm Brushless Motor with 32A Speed Controller and Throttle Grip Kit for Go Karts E-Bike Electric Throttle Motorcycle Scooter
Mophorn 1800W Electric Brushless DC Motor Kit – 48V 5200rpm Brushless Motor with 32A Speed Controller and Throttle Grip Kit for Go Karts E-Bike Electric…
ENGWE Mobility Scooter 4 Wheel Medical Scout Compact Travel Power Scooter
ENGWE Mobility Scooter 4 Wheel Medical Scout Compact Travel Power Scooter Product Description & Features: ☆The 4 wheeled moped is easy to disassemble and suitable…
Razor Ground Force Drifter Kart – Blue
Razor Ground Force Drifter Kart – Blue Product Description & Features: Recommended to use only on flat surfaces | Race-tuned chassis and super-slick rear wheels…
Kcvolro LifePo4 Battery 12v 100Ah Up to 7000 Deep Cycles, Built-in BMS, Lithium Iron Phosphate Battery, Perfect for Trolling Motor, Solar, Panels, RV, Bass Boats, Golf Carts and Off Grid Applications
Kcvolro LifePo4 Battery 12v 100Ah Up to 7000 Deep Cycles, Built-in BMS, Lithium Iron Phosphate Battery, Perfect for Trolling Motor, Solar, Panels, RV, Bass Boats,…
10L0L Motor Brake Assembly for EZGO RXV 2008-up Electric Golf Cart, OEM 610065 605867
10L0L Motor Brake Assembly for EZGO RXV 2008-up Electric Golf Cart, OEM 610065 605867 Product Description & Features: Motor brake assembly for EZGO RXV 2008-up…
How many batteries does an electric golf cart have?
Electric golf carts will have up to six batteries which will need frequent cleaning to keep them in great condition ( here’s a video to show you how to clean them with baking soda ). However, you may have to visit a golf cart service shop if you need any of the battery or battery cables replaced.
When will golf carts be repaired in 2021?
February 23, 2021. As a golf cart owner, you want your golf cart in tip-top condition. To achieve this, it is imperative that you maintain parts often and repair whenever your golf cart breaks down. For this, you need a local golf cart repair shop that caters to maintenance and repair needs as you might not always do these fixes on your own.
Do you need to have your tires inspected for golf cart alignment?
Wheel alignment is also an essential service offered by golf cart repair shop staff for both electric-powered golf carts and gas-powered golf carts. It is also important that you have your tires inspected and replaced if they are worn out.
Can you service a golf cart by yourself?
While you can service some parts and components of your golf cart by yourself, you may need to visit a golf cart service center near you for some fixes.
Can you tow a golf cart to a repair shop?
If a repair shop is far from your home, you may have to incur the cost of towing your golf cart to the shop. Some repair shops will also give their customers a rental before your cart is serviced or repaired. This is definitely convenient for most customers. Other shops may even offer mobile golf cart repair and is a convenient option ...
Do electric golf carts have electrical connections?
Both electric and gasoline-powered golf carts have electrical connections, which are vital for the powering and running of the golf cart. These connections need cleaning and tightening to avoid electrical shorts, which may damage other golf cart components. If you own a gas-powered golf cart, you may also need to visit your nearest golf cart shop ...