What is the battery bank size of the EZGO medalist?
The EZGO Medalist and Txt carts are based on a 36 volt battery bank. Consisting of six 6 volt golf cart batteries. We will be installing a new set of our PowerPro Golf Cart batteries.
Can I install batteries on an EZGO golf cart?
Today I will be doing a basic golf cart battery installation on an older Ezgo Golf cart. This is really a straight forward job nothing difficult here – maybe just lifting the batteries themselves in and out of the cart during the installation process.
What is the forward/reverse switch on an EZGO golf cart?
When you position the Forward/Reverse switch neutrally and disconnect the battery cables, the reverse current flow stops and prevents damage to the electronics as well as batteries of the golf cart. The ideal size for the trailer used to a tow a EZGO golf cart has a size of 5 to 10 feet. The trailer and golf cart must face the same direction.
Do I need an EZGO rear seat?
Another good reason why it's good to have an EZGO rear seat, is that you'll have more room on your golf cart! If you can seat two more people with the seat flipped up, you can get a flat bed for your stuff when it's flipped down. Yup --- that means you'll have more room for your groceries after a trip to the local farmer's market.
How do you put a golf bag in the cart?
0:311:52Golf Tips : How to Arrange a Golf Bag - YouTubeYouTubeStart of suggested clipEnd of suggested clipGenerally. Speaking you'll put the clubs in a descending order on the front to the back you'll haveMoreGenerally. Speaking you'll put the clubs in a descending order on the front to the back you'll have your short irons in the front in the first slide pocket.
How do you store golf cart batteries in the winter?
Keep them in a cool area and stay away from areas that are near heat sources such as radiators or heaters, since hot temperatures accelerate battery self-discharge. In addition, al- ways avoid areas where freezing temperatures are expected during the storage pe- riod.
Should you leave a golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How often should you add water to golf cart batteries?
about once every 30 daysAlways fill the batteries after charging. The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
Does cold weather drain golf cart batteries?
The cold winter months can slow down the rate of charge/discharge on your vehicle, golf cart and equipment batteries. In addition to affecting rates, colder temperatures also carry the risk of freezing the electrolyte if the battery is not stored properly.
Should I take the batteries out of my golf cart for the winter?
Simple, regular maintenance of your 6 volt golf car batteries during the off-season ensures that your car is ready to run when the time comes, but neglecting to care for them will leave you with a car that can't make it out of the garage, let alone 18 holes.
How long will a 36 volt golf cart run?
A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.
Should I charge my golf cart batteries every day?
Still, golf cart batteries should be recharged after four hours of use. Nobody likes to be stranded. It takes several hours to re-charge golf cart batteries that have gone completely dead. To lengthen the lifespan of batteries, make sure they are fully charged before each use.
How long does it take to charge a 36 volt golf cart?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.
What happens if you put too much water in your golf cart batteries?
Over watering is just as bad. As you operate an electric golf car, the electrolyte level in the cells will drop. This is a normal occurrence in the chemical reaction to produce the electrical current. When you charge the batteries the chemical reaction is reversed and the electrolyte level in each cell will rise.
What happens if you don't use distilled water in golf cart batteries?
The chemical balance inside of a battery will become compromised by adding tap or well water into them. Overtime this lessens the effectiveness of the sulfuric acid inside of the battery cell.
Do you put distilled water in golf cart batteries?
Adding water after charging prevents acid from spilling over. You'll want to add water to 1/2 inch from the top of the battery. 2) We recommend service once or twice a year. 3) Always use distilled water so you don't add additional minerals into your battery.
A look-over first
We will want to look over the golf cart first because with older carts you will want to check over the battery bank and all connections for corrosion and deterioration. To insure good performance you will always want to replace all cables that need it.
Get the right batteries
The EZGO Medalist and Txt carts are based on a 36 volt battery bank. Consisting of six 6 volt golf cart batteries. We will be installing a new set of our PowerPro Golf Cart batteries. One of the few batteries available today that are still manufactured in the good ole’ US of A.
Do a test
I always start with a quick golf cart battery test of the system in general. Overall voltage available, then voltage of each individual golf cart battery. While testing voltage I can also run a load test on each golf cart battery.
Check the connections
Once I determine the batteries are in need of replacement I begin the relatively straight forward process. First I will make note of any obvious connection issues (battery cables or terminals with corrosion or defect), replacing anything that does not look fit for continued use or if I feel it will effect the performance of the cart.
Retaining system
Then I remove retaining system, in this carts case it is just the basic plastic spacer/retainer hold down. Secured by two nuts usually 9/16′. Next I will advise you to take your cell phone and snap a few pictures of the battery bank. This will help you in the re-install phase placing the battery jumper cables in the correct location.
Pull out the old batteries
Next you can begin pulling out the old batteries. Once complete I will inspect the battery area and frame for obvious signs of leakage and corrosion buildup.
New batteries go in
Next I will begin to install the new batteries, and reconnect the battery cables to their respective locations. After doing so I will also apply a corrosion preventative to the terminal connections on each individual battery.
How many volts does a golf cart battery pack have?
The battery pack is pretty basic. It could be anywhere from 6 to 48 volts, but it’s usually 36 or 48 volts on most newer electric golf carts. The battery pack’s power is routed to the motor, but along the way, it is changed by a solenoid and a speed controller to give you only the power you’re asking for and only when you’re asking for it.
How do golf cart batteries work?
Batteries work by changing chemical energy into electrical energy. Different types of batteries use different types of chemical reactions to do this, but for the most part they’re all very similar. We did a whole article on golf cart batteries ...
What is a golf cart solenoid?
We did a write up on golf cart solenoids if you want to get deeper knowledge, or learn how to test them. Like I said before, a solenoid is basically a switch, but more specifically, it’s a relay, meaning that it’s a switch that uses one circuit to control another.
How does an electric golf cart work?
How Does a Golf Cart Work. In the most basic sense, your electric golf cart works by providing electric power from a battery pack to a motor that turns your wheels. Everything else involved is just a way of controlling when and how much of that power is being delivered. The battery pack is pretty basic.
How long have electric golf carts been around?
Electric motors have been around for a couple hundred years, and honestly after around the 1890s, not a whole lot has changed.
Can electric golf carts be throttled?
Unfortunately for electric golf carts, electricity can’t just be throttled or dripped in the same way air and fuel can. No matter how hard you pinch a cable, it’ll still send the same amount of electricity. Because of this, the people that made your electric golf cart had to come up with a different speed control system.
Can you use an AC motor on an electric golf cart?
Of course, batteries only put out DC power, so for an electric golf cart to use an AC motor, it has to convert the power. This is usually done in the speed controller. The conversion will create a three wave AC signal.
Where is the run/tow switch on an EZGO golf cart?
The Run/Tow switch in an EZGO TXT golf cart is located below the seat on the passenger side of the cart. The toggle switch is usually protected with a black cover above it.
What to do if your golf cart doesn't run?
Remove the wire connections from the switch and try running the golf cart. If it doesn’t run, the switch could have become faulty and needs a replacement. However, if the cart continues to run, you have a problem with the wiring harness. As a safety measure, you can remove the negative cable from the battery pack.
How much weight can a golf cart tow?
Golf carts can be used for towing when you have to haul small items between two places. Often, the towing capacity of a golf cart is close to 1,000 pounds. It’s worth noting that some golf carts can tow between 3,000 and 5,000 pounds without any problem.
What is a run tow golf cart?
Almost all golf carts have a Run-Tow switch that helps to switch the cart from Run mode to Tow mode and vice versa. The cart must be set to Tow mode when it cannot move with its power. Your EZGO golf cart is operated in this mode when it has to be pushed or pulled to get moving.
How fast can a golf cart go?
You can tow a golf cart with a roof safely at a speed of 60 to 70 mph. Strapping the top of the roof to keep it in place can help you to tow the cart without having to worry about the roof. The windshield of the cart may tend to snap off during the towing process.
Does an EZGO golf cart have a run tow switch?
An EZGO golf cart doesn’t have a run-tow switch unlike PDS and most other golf carts. The following steps can help you to tow an EZGO golf cart safely without any damage. Keep the Forward/Reverse switch in a neutral position. Remove the battery connections from the motor.
Is it safe to have a golf cart in tow mode?
The switch can be in Run position when charging the golf cart. However, it’s always safer to have it in Tow mode. This prevents damage to the controller in case of unexpected power surges when the cart is getting charged. Remove the switch cover and turn the switch at an angle of 180 degrees.