The fuel tank is located on the driver’s side of the vehicle and the filter can be removed with a pair of pliers. Squeeze the spring clip and slide it further up the rubber fuel line, then pull the filter free. Note the direction of flow to prevent installing the filter backward.
Full Answer
What is the fuel pressure for a Yamaha G2 golf cart?
An electric fuel pump in a Yamaha G2 cart often has a low pressure of 3 to 5PSI with 1/4-inch lines. In some cases, the fuel pump gets activated when the fuel pressure is lower than 2PSI. It gets turned off when the pressure reaches 4.5PSI. The best fuel for golf carts is 87 octane fuel.
What should I do if my Yamaha golf cart runs out of gas?
If the fuel filter of a Yamaha golf cart is empty, disconnect the fuel line coming from the carburetor followed by a turnover of the motor. This should release a stream of fuel. After this, consider pulling the vent out and sucking through it. This will help to clear blocks in the vent if any. What Happens If my Golf Cart Runs Out of Gas?
Why does the fuel filter of the golf cart not stay full?
The fuel filter of the golf cart may not stay full because of a fault vacuum tube. Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full.
Why is the fuel tank on my EZGO golf cart empty?
If the fuel tank of an EZGO golf cart is empty, there is likely to be a problem in the vacuum tube that connects the crankcase and the fuel pump. The tube may either be completely damaged or have just a hairline crack that drains off the fuel. Consider replacing this tube.
Where is the fuel filter on a Yamaha golf cart?
0:444:11Yamaha Fuel Filter Replacement on Golf Cart | How to Install - YouTubeYouTubeStart of suggested clipEnd of suggested clipThanks right here on the seat passengers on running front of the fuel tank.MoreThanks right here on the seat passengers on running front of the fuel tank.
Do Yamaha golf carts have fuel filters?
For All of Your Fuel and Air Filtration Needs The Yamaha air filter has the same functionality, and simply blowing it out regularly will keep your cart performing well. We carry these filters for Yamaha: G1, G2, G3, G5, G8, G9, G11, G14, G16, G20, G22, and G29 "The Drive" golf carts.
How do you change a fuel filter on a golf cart?
0:100:48How to Change the Fuel Filter in your Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt points towards the carburetor. You're gonna do first we're going to loosen our clamps here on theMoreIt points towards the carburetor. You're gonna do first we're going to loosen our clamps here on the hose. We're gonna slide the hose off and then simply install the new filter.
Is there an oil filter on a Yamaha G2 golf cart?
Yamaha golf cart engines do not have oil filters like many other makes.
Does Yamaha drive 2 have an oil filter?
6:059:12Yamaha G29 Drive/Drive 2 - OIL CHANGE - Service - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo do not put car engine oil in these but these just hold one quart. So you're going to remove theMoreSo do not put car engine oil in these but these just hold one quart. So you're going to remove the fill cap.
Should the fuel filter be full in a gas golf cart?
Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, facing a glitch.
Where is fuel filter located?
The fuel filter will be located either inside the fuel tank or fitted into the fuel line between the tank and the fuel pump. Some engines have internal, non-serviceable fuel filters.
How do you install a fuel filter?
2:314:26How To: Replace Your Vehicle's Fuel Filter - YouTubeYouTubeStart of suggested clipEnd of suggested clipFilter. Use the clips that came with the filter to attach it to the fuel. Line. And secure the clampMoreFilter. Use the clips that came with the filter to attach it to the fuel. Line. And secure the clamp to hold it in place reinstall the fuel pump relay or fuse.
How do you remove a fuel filter?
Disconnect and Remove the Old Filter Put on your safety glasses, then drive your vehicle up on ramps if your filter is housed underneath your vehicle and you need extra clearance. Position your drain pan under the filter. Find, loosen and remove the fuel lines connected to either end of the filter.
How much oil does a Yamaha gas golf cart hold?
The engine oil capacity in Yamaha golf carts is usually greater than 1.0 L or 1 US qt. When the engine oil is completely drained out, a Yamaha golf cart can take in around 0.9 L or 1 US qt. It is important to ensure that the engine oil is not overfilled.
What oil goes in a Yamaha golf cart?
YAMAHA LUB-10W30-GG-12 Yamalube Golf Car and Generator Oil 10W-30 - Quart.
How often should you change the oil in a golf cart?
If your golf cart is used often, you'll want to check on it more than that. You'll need to replace your engine oil and filter semi-annually, generally once it hits around 125 rounds or 600 miles of usage. For new engines, your initial oil change should be after 8 hours of run time.
What happens if a golf cart runs out of gas?
If your golf carts runs out of gas, the engine will stop running. This in turn stalls the cart and makes it difficult to control the braking and steering. The fuel line will be filled with air causing the fuel injectors to get clogged or the fuel pump to get damaged.
How to test a golf cart fuel pump?
How to Test a Fuel Pump on a Golf Cart. Check the vacuum and fuel lines if the carburetor fails to get sufficient fuel. These lines are made of rubber and tend to deteriorate over time. Gas leaks or gas odors are signs of faulty fuel lines.
How many diaphragms are there in a gas engine?
There are two diaphragms that separate the inlet, outlet and pulse from one another. When the diaphragms start pulsing, the fuel is moved from the gas tank to the inlet chamber. From here, the fuel gets transferred to the outlet chamber and then to the other parts of the engine.
Do golf carts need fuel?
However, golf carts that are used extensively, carry heavy loads or operate in high altitudes may require a higher-octane fuel. But this can be detrimental to the life of the golf cart as mentioned above. To overcome the problems, you can consider fitting a fuel stabilizer to the golf cart.
Can you put an electric fuel pump on a golf cart?
Yes, it’s possible to install an electric fuel pump on a golf cart. The fuel pump must be powered from that side of the solenoid, which features the starter motor. In other words, it must be connected from the large post of the solenoid that goes towards the starter. This ensures that the pump operates only when the starter gets running.
Can you fix a golf cart on your own?
Under NO circumstances should you attempt to fix your golf cart on your own. Doing so is dangerous and could result in serious bodily harm. The information on this website has not been verified for accuracy and should only be used for general information purposes only. Use this information at your own risk. The author (s) and owner of of golfstorageguide.com are NOT trained electricians, mechanics or technicians. The webmaster of golfstorageguide.com and the author (s) is not responsible for any loss in damages, financial loss, personal injury, or death. By using the content on this website, you agree to the terms outlined in this disclaimer.
Why does my golf cart have a dirt filter?
Some of the possible causes are stated below: There could be dirt filled in the carburetor, potentially stopping the gas flow from the tank to the engine. If the air filter can be opened from the golf cart and around 2 ounces of fresh gas get drilled in to the pump, then the issue may get sorted.
Why is my Yamaha G9 getting out of breath?
The Yamaha G9 has been recorded to be getting out of breath due to lack of enough fuel levels in the tank. Some of the reasons for the glitch along with possible solutions are stated as below: It may be that the air box is not sealed properly due to which air would enter inside the tank.
What is the G16 golf cart?
The G16 model of Yamaha golf carts suffers from the glitch of not receiving the required levels of gas, which ends up hampering the overall performance of the golf cart.
Why is my golf cart starving for fuel?
A golf cart can be starving for fuel because of old gas in the engine, or because the flow of gas to the fuel tank is blocked. If the engine was running smooth until a few days ago, then it can be presumed that there is no glitch with the engine. Some of the possible causes are stated below:
Why is my golf cart not full?
The fuel filter of the golf cart may not stay full because of a fault vacuum tube. Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, ...
Why is my carb pump not getting sorted?
If the problem still does not get sorted, then chances are that the pump is faulty and the vacuum line has got clogged.
What happens if there is no air in the pump?
If there is no air in the pump, then fuel should be pumped at any cost. The hose should be taken off the carb which should give out fuel at every revolution on starter. If there is any sort of leakage detected, that would only end up multiplying the issue.