In a 1997 Club Car, the fuse is located in the electrical components black box that is present near the battery. On the other hand, in a 2005 Club Car Precedent, the fuse is connected to a blue wire under the golf cart seat. Why your Golf Cart Fuse Keeps Blowing
Full Answer
Can you replace the battery in a club car golf cart?
With a cart that has been used for a while, it may be necessary to replace the batteries. A new cart may not have batteries. Connecting a battery to your Club Car golf cart is a pretty easy task, as the wiring system for the batteries is fairly basic.
Where is the fuse on a golf cart?
In a 1997 Club Car, the fuse is located in the electrical components black box that is present near the battery. On the other hand, in a 2005 Club Car Precedent, the fuse is connected to a blue wire under the golf cart seat. A golf cart fuse can blow for many reasons such as a faulty relay switch, loose connections or a naked wire.
Where is the battery light on a golf cart?
This light is usually located on the dashboard of the golf cart. The drive time you get out of charged batteries depends on two parameters. One aspect is the weight of the loaded golf cart.
Do golf carts have fuses and breakers?
Yes, all golf carts have fuses and breakers. Most controllers like Alltrax come with a fuse because having a fuse on the battery pack offers many advantages. One major advantage of having the fuse is that it offers protection against fire or a short.
Where are fuses located on golf cart?
Locate the service panel of the golf cart. This is usually found behind the battery on the driver's side on the rear fender. Make a note of the current ratings supported for each fuse at the highest voltage.
Is there a fuse in an electric golf cart?
Yes, golf carts contain fuses just like those found in a car or truck.
How do you change a fuse on a golf cart?
0:000:52Changing the Fuse - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou can remove the fuse. Simply by pulling it out of the socket. Looking at the fuse itself the fuseMoreYou can remove the fuse. Simply by pulling it out of the socket. Looking at the fuse itself the fuse should not be discolored. And this small area in the middle.
Does a club car battery charger have a fuse?
If the Club Car's computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse. If you check the fuse and it is okay, then you could also have a damaged relay, although this is rare.
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
Where is the fuse box?
The interior fuse box is underneath the steering column. The under-hood fuse box is in the engine compartment next to the battery. If something electrical in your vehicle stops working, the first thing you should check for is a blown fuse.
Why does my electric golf cart have no power?
If you're lucky, the problem could be as simple as a loose wire or a broken coil. In some cases, corrosion can also be a factor. If you suspect a faulty solenoid, your best bet is to take your cart to a repair shop. A mechanic can diagnose the problem and replace the solenoid if necessary.
What would cause an electric golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
What size fuses for a golf cart?
Replacement ATC-10, 10 amp fuse. This fuse is commonly used for 12VDC, 10Amp accessory loads in Club Car gas & electric DS & Precedent model golf carts as well as Yamaha gas & electric G9-Up model golf carts. However, this fuse can be used in many other applications for accessory loads.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
What do you do if your golf cart won't charge?
Golf Cart Won't ChargeCheck our outlet to make sure that you're getting power to your electrical outlet.Check the water level in your batteries, using distilled water to refill only. ... Check for corrosion or any loose cables on the batteries.Check the condition of your charger's cables (AC and DC cables).More items...
Why does my club car not charge?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
Where to check fuses in car?
Check the fuses in the battery bay under the seat. If you find any blown out fuse, make a replacement with the same current rating. Similarly, remember to replace any broken switch.
What is a golf cart battery light?
A golf cart’s battery light is undoubtedly an indispensable accessory of any battery-operated golf cart. This light notifies you when your golf cart battery or batteries are low on charge. It saves you the hassle of worrying whether you would be stranded because of a drained battery.
Why Won’t My Golf Cart Lights Work?
There are different types of lights on your golf cart. The reason why one light doesn’t work may not be the same reason for another faulty light . However, in general terms, a few reasons why golf cart lights tend to fail are given below:
What happens if your golf cart battery is low?
Weak Battery Voltage. One or more of your golf cart batteries are likely to have a low voltage. This can stop the batteries from being able to pick up charge. Check the voltage of each battery separately. When you find a battery with a low charge, try charging it to its full voltage using a smaller auto charger.
Why does my golf cart light flash red?
The light, usually red, starts flashing when the battery has got less than 10 percent charge left, in an electric golf cart or less than 10 percent fuel in a gasoline-powered golf cart. The golf cart has several other warning lights. For example, there is a warning light to indicate if there is any problem with the engine of your cart.
Why is my battery light flashing?
One reason why your battery light is flashing could be because the batteries are not getting a full charge from the charger. The flashing indicates that the charging is less than 90 percent.
What is the warning light on a golf cart?
The warning light on an electric golf cart is the battery light . True to its name, this light gets illuminated to warn you of a low battery or low batteries. It serves as a signal for you that it’s time for battery recharge.
How to access battery compartment on golf cart?
Lift the seat of the golf cart in order to access the battery compartment. You may need to use a rope or bungee cord to secure the seat in the open position so that you can work freely within the compartment.
What is the color of the battery terminal?
The positive terminal will be marked with a "+" sign and is usually denoted by red color-coding. Connect a cable from the negative terminal of the first battery, which will be marked with a "-" sign and black if color coded, to the positive terminal of the second battery in the sequence.
What is the best way to prevent corrosion on battery terminals?
Coating the battery posts and terminal connections with petroleum jelly will help combat corrosion.
Can you replace a golf cart battery?
With a cart that has been used for a while, it may be necessary to replace the batteries. A new cart may not have batteries. Connecting a battery to your Club Car golf cart is a pretty easy task, as the wiring system for the batteries is fairly basic. Lift the seat of the golf cart in order to access the battery compartment.
Do you need batteries for a golf cart?
Golf carts have becoming increasingly popular for personal use in recent years. Many people now own their own golf carts for recreation. Electric golf carts require minimal maintenance. Batteries are the power source for the cart and these need regular charging.
What happens if your golf cart battery fails?
Obviously, for electric golf carts, the battery is what provides power to your motor. If your batteries start to quit on you, the golf cart won’t move, or will drastically decrease in range. With a gas motor, the battery is what starts the motor and keeps it running by providing electricity to the spark plugs. Without it, your motor won’t crank.
Why is my golf cart battery failing?
The most common thing that leads to early golf cart battery failure is corrosion. The problem goes deeper, too. It will ruin your cables, terminals, and even cause damage to battery trays and tie downs. Replacing a whole battery cable can be costly and difficult, so it’s best to avoid that problem.
How to clean corroded battery posts?
Undo the terminals from the battery posts and soak the corroded area in the cleaner or baking soda solution for about 5 or so minutes, then put on some gloves, grab your wire brush, and keep scrubbing until it’s all gone. Repeat as necessary, then rinse with a lot of water.
How to protect battery terminals from corrosion?
Connect the terminals back to the post and then use your coating solution somewhat liberally to protect the area from future corrosion. You can use any store bought battery protection product you like, or just petroleum jelly, dielectric grease, or even bearing grease. As long as it will stay there and keep the metals insulated from the atmosphere.
How to clean a battery with corrosion?
First, you’ll want to clean off all of the corrosion. You’ll need corrosion cleaner and a stiff wire brush. You can get any type of battery cleaner in a store to perform this job, or you can use hot water and baking soda in a pinch.
Why is my battery puddled?
If your battery gets dirty, muddy, grimy, or anything else, make sure to clean that off too. These things can cause extra resistance in your electrical system, putting an unnecessary drain on your battery and shortening its life.
What happens when hydrogen gas is released from a battery?
Look for corrosion often, and neutralize it immediately. It’s a long and never ending war, but your wallet will thank you. Corrosion happens when hydrogen gases, released from your battery, mix with other chemicals and gasses in the atmosphere, and then bond to the metals of cables, terminals, and battery posts.
Where is my User’s Manual for my golf cart battery charger?
Our manufacturer does not provide owner’s manuals. Here are the links to the Lester charger manuals (they are also linked to on our product pages):
What is “Storage Mode” on my golf cart battery charger?
"Storage Mode" is a feature that comes with every Lester Electrical golf cart battery charger that we sell (except for the 48V Club Car Charge r - That battery charge r is ONLY automatic, meaning it will charge to full charge and then shut off. It will not come back on like the new Summit II battery chargers). When you plug in your charger to your cart it will fully charge the batteries. Once fully charged, the charger goes into its "storage mode" feature so long as it is connected to the golf cart and the wall. When in storage mode, it will charge your batteries only when the following two situations occur (1) the battery voltage drops to a certain predefined voltage AND (2) 10-15 days have elapsed. Once these two criteria are met, the charger will do a refresh charge to bring up the volts again to 100% fully charged. So, unlike a trickle charger that charges non-stop, the Lester charger charges only when the batteries need a good charge.
How Do I Troubleshoot My Golf Cart Battery Charger if It Isn't Working?
Just so you know, this situation happens EVERYDAY. The first question we always ask is, how long has it been since you've charged your batteries? We ask this because often times if it has been a while (a couple weeks or more), or if you just got brand new batteries, or if your batteries have been really run down recently, it is possible that the batteries may not have enough voltage in them for the charger to start working. An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
What are some symptoms of a bad golf cart battery charger vs. bad batteries?
Bad Batteries: IN GENERAL, if the charger doesn't kick on or show any signs of life when you plug it into your cart, this is most likely a battery/connection issue. Learn more about the signs of a bad golf cart battery.
Will the golf cart charger automatically stop charging once the batteries are fully charged?
Yes. All automatic chargers are designed to charge your batteries until they are fully charged and then stop charging. So you do not need to manually shut off the charger or worry about overcharging your batteries. All Lester chargers are made with a number of internal safety mechanisms that ensure that they will never overcharge batteries.
What if I charge my batteries until my battery charger stops charging, but my golf cart won’t drive very far?
You probably need to test your batteries and likely will need to get new golf cart batteries.
How long does it take to charge a golf cart?
It depends on three factors, 1) the quality of your batteries, 2) how discharged your batteries are and 3) the quality of your charger. If you have 5 year old batteries that are very discharged and you have a lightweight 2-5 amp charger, it may take a very long time (10 hours or more). If you have brand new batteries, they are 20-30% discharged and you've got a heavy-duty charger, it can be pretty quick (1-3 hours). Again, it depends on all of the above factors, so it really could vary quite a bit.
What is an OBC golf cart?
All Club Car golf carts newer than 1995 have an OBC or ” On Board Computer ” in the charge circuit to monitor and control several functions on the golf cart. The tutorial below explains a little about the OBC, how to reset it after charging problems, and what to do if its completely failed.
Can OBC reset fix a club car?
There is always a chance the OBC has completely failed and the reset process will not fix the problem. Consult your Club Car manuals or call your local dealer.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
Do golf carts need batteries?
If you find that your golf cart won’t go very far on a full charge, then you probably need new batteries. Test them to make sure that the power on them is low; if indeed it is, then you need new batteries.
Can a club car monitor battery charge?
Only the club car can monitor the charge of your batteries, but it bears mention because these computers can fail, thus requiring a replacement. If the Club Car’s computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse.
Series vs. Parallel
Two simple statements govern the rules for series versus parallel battery bank wiring. In a series circuit, the current through each of the batteries is the same. Also, the voltage across the circuit is the sum of the voltages across each component. In a parallel circuit, the voltage across each of the components is the same.
36V Battery Bank
If connected properly in a series circuit as shown, you should be able to test across the battery bank main positive and main negative terminals with a voltmeter and get a reading equal to the sum of each battery. In this example, your reading should equal 36 volts (6×6 = 36).
48V Battery Bank
A 48 volt golf cart battery bank wired in a series circuit is also very common in this industry. However, there are several combinations of individual battery voltages which can provide 48 volts. These combinations include the following:
