Full Answer
Where is the oil drain plug on a Yamaha G16?
The drain plug is right under the driver seat in the Yamaha G16 cart. You can un-screw that using a 17mm drain bolt. Once the engine oil is completely drained out, screw the drain plug back in its position. Open the oil filler cap on the top side of the engine.
Where can I get fuel tank repair parts for my golf cart?
Golf Car Catalog offers fuel tank repair parts for a variety of EZGO, Club Car, Yamaha, Columbia, and Harley golf cart models. Regardless of your golf cart model, Golf Car Catalog can supply fuel tank repair parts for most modern applications. Grommets to seal the vent valves.
How do you drain the gas from an EZGO golf cart?
Blow air into the tank using the air blow gun until the gas flows downwards through the hose. Collect the drained fuel in the catch pan or any other vessel that has been approved for this purpose. You will have to remove the body of your EZGO golf cart to take out the gas tank.
How do you remove a fuel tank from a Yamaha golf cart?
Take off the fuel line and vent tube from the fuel tank. Loosen the straps holding the fuel tank in place by taking off the screws on the speed nuts. Lift the fuel tank from its position out of the vehicle. Removing the gas tank from the Yamaha golf cart is a relatively simple process.
How do you drain the gas tank on a Yamaha golf cart?
Cover the opening of the gas tank using a rag. Insert an air blow gun into the tank through the rag. Push the air inwards until the gas begins to flow out of the hose. This action will siphon the fuel from the tank into the catch pan on the floor.
Where is the drain plug on a Yamaha golf cart?
2:208:18Yamaha golf cart oil change - YouTubeYouTubeStart of suggested clipEnd of suggested clipAlright got a flashlight you see here on the bottom of the motor that is your drain port.MoreAlright got a flashlight you see here on the bottom of the motor that is your drain port.
Where is the fuel filter on a Yamaha golf cart?
0:464:11Yamaha Fuel Filter Replacement on Golf Cart | How to Install - YouTubeYouTubeStart of suggested clipEnd of suggested clipThanks right here on the seat passengers on running front of the fuel tank.MoreThanks right here on the seat passengers on running front of the fuel tank.
How do you winterize a Yamaha gas golf cart?
Winter Storage Tips for Your Golf CartClean the vehicle. Before storing, it is imperative that you clean your golf cart, inside and out. ... Drain the fuel. Drain the gas from your cart. ... Perform a full check up. ... Prepare the battery. ... Inflate the tires. ... Ensure the cart won't move. ... Park the vehicle in the proper position.
How do I speed up my Yamaha gas golf cart?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipAnd the throttle cable on your yamaha g29 to get maximum. Speed.MoreAnd the throttle cable on your yamaha g29 to get maximum. Speed.
Do Yamaha golf carts have an oil filter?
Yamaha golf cart engines do not have oil filters like many other makes.
Do Yamaha golf carts have fuel filters?
For All of Your Fuel and Air Filtration Needs The Yamaha air filter has the same functionality, and simply blowing it out regularly will keep your cart performing well. We carry these filters for Yamaha: G1, G2, G3, G5, G8, G9, G11, G14, G16, G20, G22, and G29 "The Drive" golf carts.
How does a Yamaha golf cart fuel pump work?
The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart.
Should the fuel filter be full in a gas golf cart?
Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, facing a glitch.
Do you need to winterize a gas golf cart?
Winterizing your golf cart is crucial if you store it and hope for a quick start up in the spring. While the procedures are a bit different for a gas vs. an electric model, you must clean it and attend to the fuel source and tires for best results.
Can you use a gas golf cart in the winter?
For gas golf carts, drain gasoline from all plumbing and parts from the carburetor to the fuel tank. Any fuel left in the cart over the winter can gum up small parts in the carburetor or the fuel pump. If your golf cart has a shut-off valve, make sure it is in the off position.
How do you store a golf cart for the winter?
Electric Golf Cart Winter Storage TipsClean the vehicle.Park the vehicle in a covered, dry location.Fully charge the battery.Disconnect battery cables.Check the tire pressure.Turn the key switch to the OFF position and remove the key.Turn the power switch under the seat to the TOW position.
Step 1: Air Filter
The air filter is cylindrical with a foam prefilter sleeve that fits over the paper element.
Step 3: Fuel
Replace the spark plug and screw into place using the socket and your fingers to prevent cross-threading, because this is aluminum and strips out easily. Lightly tighten with the ratchet (20ft/lbs) and push the wire connector back on to the spark plug. Inspect the connector boot and wire for any cracking or damage and replace if needed.
Step 4: Valve Adjustment
Put the vehicle in neutral and open the seat cowling pulling up on the lever in the gas filler hatch. Remove the 5 screws from the front and rear of the cowling and lift out.
In Conclusion
Yamaha engines are durable and because of the simple design, they can be successfully rebuilt 3 or 4 times. Initially, the Yamaha G1 2-cycle gas was the standard-bearer and in 1985 the G2 4-cycle single-cylinder gas engine was introduced as the new standard.
How to drain gas in a golf cart?
You can drain the gas tank of your golf cart using a simple siphoning action. This becomes essential if you plan to clean the tank. The siphoning can be done using a hose and air blow gun in an EZGO cart. Insert a hose down into the fuel tank as far as it will go.
How to collect drained gas from a gas tank?
Place a rag over the opening of the tank and a catch pan on the floor to collect the drained fuel. Blow air into the tank using the air blow gun until the gas flows downwards through the hose. Collect the drained fuel in the catch pan or any other vessel that has been approved for this purpose.
How many gallons of gas in 1992 Club Car?
The 1992 Club Car gas tank has a capacity of seven gallons. However, you should get started with six gallons if your cart has a sled engine to avoid fuel leakage through the vented cap.
How to remove gas tank from 1987 G2?
The steps given below will guide you on how to remove the gas tank from the 1987 Yamaha G2 golf cart. Remove the engine and seat from the golf cart. Remove the three bolts holding the fuel tank in place. Unscrew the knob present at the bottom of the tank. This helps to detach the fuel line from the fuel tank.
How to get gas out of a gas tank?
Stick a five-foot-long 5/8-inch heater hose into the gas tank. Make sure it goes down as much as possible. Place a catch pan on the floor. Cover the opening of the gas tank using a rag. Insert an air blow gun into the tank through the rag. Push the air inwards until the gas begins to flow out of the hose.
How to get rid of water in gas tank?
Put some water and cleaning agents into the tank. Use the air flow gun once again to circulate the cleaning agents to all parts of the gas tank. You may need to run the air for about 20 minutes. Pump out the water to get the tank dry. Use simple green or shop vac to get rid of the water that doesn’t get pumped out.
How to clean a gas grill?
Clean the outside of the gas tank with a degreaser that is used to clean grills. Siphon out the old gas fuel from the tank as mentioned above. Spray some of the siphoned fuel along with a little carb cleaner into the tank. Put a lint-free towel over a coat hanger and use it to wipe the inside of the tank.
Where is the drain plug on a Yamaha G16?
The drain plug is right under the driver seat in the Yamaha G16 cart. You can un-screw that using a 17mm drain bolt. Once the engine oil is completely drained out, screw the drain plug back in its position. Open the oil filler cap on the top side of the engine.
How much oil does a Yamaha G16 hold?
The oil capacity of Yamaha G16 is lower than the Yamaha G2 and it can hold only around 1.16 US qt. The type of oil to be used remains the same; 10W-30 non-synthetic.
How to check oil level on a cart?
With the cart on a level surface and engine a little warm, take the dipstick out. Clean it with a dry piece of cloth and dip it in to check the oil level. If the oil level is below the safe range, operating the cart without an oil change can leave the engine damaged.
How long does it take to change the oil on a golf cart?
If you are a regular cart user, 150-250 hours of operation should take around 6 months. The timeframe for changing the oil in any golf cart depends on the time for which the cart is operated. If you can’t keep a track of your cart’s running hours, you can always turn to the dipstick oil level indicator.
Can you use synthetic oil on a Yamaha golf cart?
The synthetic oil can prove to be too thin for Yamaha’s splash system mechanism. There are several synthetic oil options available in the market with the YamaLube being the most popular for Yamaha golf carts. Mobil 1 non-synthetic oils can also be used and are quite good with golf cart engines.