Where is the tow run switch on a golf cart?
They are not used in traditional golf carts with a series wound motor. The tow run switches are typically found inside the battery compartment of the cart in plain sight. The tow run switches are used in golf carts with separately excited motor and corresponding controller.
How to tow a EZGO TXT/RXV golf cart?
How to Tow a EZGO TXT/RXV Golf Cart. To tow an EZGO golf cart, use the Run-Tow switch to set your golf cart into Tow mode. This will allow you to tow your golf cart. Almost all golf carts have a Run-Tow switch that helps to switch the cart from Run mode to Tow mode and vice versa. The cart must be set to Tow mode when it cannot move with its power.
What does the Run switch do on an electric golf cart?
The Run / Tow switch on most newer golf cart like the E-Z-Go PDS, RXV or Club Car IQ, Precedent models use a switch for protecting the On Board Computer (OBC). This toggle switch is used to temporarily “kill” the brain of the electric cart for towing, maintenance, and long-term storage.
Where is the micro switch on an EZGO golf cart?
In most of the EZGO models, it is located on the bottom side of the cart near the accelerator pedal. Unscrew the outer covering and access the two terminals of the micro switch.
Where is the tow switch?
Most likely, the tow run switch for your golf cart is located in the battery compartment. As you are probably aware, this compartment is almost always under a golf cart's seat. The tow run switch should be in plain sight.
What is a run tow switch?
TOW / RUN switches are basically kill switches designed to disable the golf cart. there are several reasons for this switch. Usually, a TOW / RUN switch is only used on electric golf carts, specifically those with a separately excited electrical system with regenerative braking.
Where is the reset button on EZGO motor?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
What happens if you tow an electric golf cart in run mode?
First of all, leaving your cart in run mode during storage will cause your battery to slowly drain, as your cart's computer and its regenerative braking system will be active, causing a slow drain that will leave your battery dead after a long-term storage situation.
Should I charge my golf cart in run or tow mode?
Your golf cart needs to be charged in Run. Tow should only be used in long term storage or if you are going to remove the battery.
How do you tow an electric golf cart?
Easiest Way to Tow a Golf CartUse a ball reciever to attach the trailer to your towing vehicle.Use the latch to secure the ball receiver and keep the trailer from falling off when you hit the highway.Attach the wiring harness to the hitch.Open the trailer gate, and place a ramp at the edge.More items...•
Where is the reset button on electric golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Do all electric golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
Why won't My EZGO start?
Check Ignition Wire If it has, reseat the wire into the solenoid. If the wire appears corroded, wear your work gloves and wipe down the wire and attempt restarting the golf cart. If the cart will not start, then you will need to replace the ignition wire.
What is freedom mode on a ezgo golf cart?
Flip the run-tow switch back to "tow" and then "run" to escape the diagnostic setting mode. This enables freedom mode and allows the cart to reach a maximum speed of 19 mph.
Is it okay to tow an electric golf cart?
Whether your golf cart is gas-powered or electric, moving the cart just takes a few steps and can be done easily. Any time your golf cart needs towed or dies, you must use the “tow-run” switch on the cart and switch it to the “TOW” position.
How do I unlock my EZ Go golf cart?
0:441:49How to disengage E-Z-GO RXV intellibrake - YouTubeYouTubeStart of suggested clipEnd of suggested clipSome more difficult another. Pull out the rivets. It's tucked underneath like that. These twoMoreSome more difficult another. Pull out the rivets. It's tucked underneath like that. These two connections right here labeled one two four and three you're going to unplug them and switch. Them.
When should I use my tow button?
The Tow/Haul mode is an option that causes your vehicle to move in a lower gear, allowing the engine to brake to slow down, in addition to the use of the brakes. We suggest you press it at any time if you need more traction, stop, or power the power steering to compensate for a heavy trailer or load.
What does tow mode do?
The tow/haul mode changes a vehicle's transmission shift patterns. Pulling a heavy load requires a lot of power. The tow/haul mode reduces shift cycles. Depending on the truck, it may also boost torque and engage an engine braking mode to help drivers maintain control while driving up and down hills.
Should I always use tow haul mode?
When driving in hilly areas, towing a trailer, carrying a heavy load, etc., and frequent transmission shifting occurs, push the TOW/HAUL switch to activate TOW/HAUL mode. This will improve performance and reduce the potential for transmission overheating or failure due to excessive shifting.
Can you switch to tow mode while driving?
Yes, you can turn on tow haul while driving; however, it might not be necessary. Anytime you turn on your car's tow haul feature, it essentially shifts your engine to a lower gear, meaning that it will make it easier for you to stop or brake if needed.
Where is the run/tow switch on an EZGO golf cart?
The Run/Tow switch in an EZGO TXT golf cart is located below the seat on the passenger side of the cart. The toggle switch is usually protected with a black cover above it.
What is a run tow golf cart?
Almost all golf carts have a Run-Tow switch that helps to switch the cart from Run mode to Tow mode and vice versa. The cart must be set to Tow mode when it cannot move with its power. Your EZGO golf cart is operated in this mode when it has to be pushed or pulled to get moving.
What to do if your golf cart doesn't run?
Remove the wire connections from the switch and try running the golf cart. If it doesn’t run, the switch could have become faulty and needs a replacement. However, if the cart continues to run, you have a problem with the wiring harness. As a safety measure, you can remove the negative cable from the battery pack.
How much weight can a golf cart tow?
Golf carts can be used for towing when you have to haul small items between two places. Often, the towing capacity of a golf cart is close to 1,000 pounds. It’s worth noting that some golf carts can tow between 3,000 and 5,000 pounds without any problem.
How fast can a golf cart go?
You can tow a golf cart with a roof safely at a speed of 60 to 70 mph. Strapping the top of the roof to keep it in place can help you to tow the cart without having to worry about the roof. The windshield of the cart may tend to snap off during the towing process.
What does a golf cart manual tell you?
Your golf cart manual will give you an idea of how much your golf cart is capable of towing.
How to secure a golf cart on a trailer?
Activate the trailer’s parking brake and secure the golf cart on the trailer using tie-down straps or a ratchet.
Tow Run
The tow run switch, also sometimes called a tow maintenance switch, is present in many brands and models of modern golf carts. This switch is only installed into golf carts with a separately excited motor which produces regenerative braking. They are not used in traditional golf carts with a series wound motor.
Separately Excited Systems
The tow run switches are used in golf carts with separately excited motor and corresponding controller. The electronic speed controllers used in this application have a bit of logic memory within, similar to your automobile’s stereo when it saves your favorite preset stations.
Roll Away Feature
There is also another use for the tow run switches used in golf carts with a sepex controllers and motors. Most carts with this type of system also have a special feature built into the programming of the controller, called the “Roll Away” feature.
