Golf-FAQ.com

where is the starter solenoid on club car golf cart

by Prof. Eulah Considine Sr. Published 3 years ago Updated 2 years ago
image

Full Answer

Where are the solenoids on a golf cart?

In all golf carts, new and old, the solenoids can be found under the seat or in the engine well and are easily identifiable by the wires that lead to them. Banks of heavy duty solenoids, as in the previous illustration, are mounted on the side or back panel near the electric motor.

What happens when a starter solenoid goes bad on a golf cart?

In a gas cart, a bad solenoid prevents the starter from being engaged and therefore results in the engine not turning over. You will hear a series of futile clicking sounds indicating that the solenoid is faulty. Can you Bypass Solenoid on a Golf Cart?

How do you disconnect a golf cart starter cable?

Disconnect the cable attached with solenoid terminals from the starter or controller. Make sure to use electrical tape to seal the cable ends to avoid any circuit accident. Double-check that your golf cart is turned off and switched to neutral.

What is a starter solenoid?

Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor that piggybacks on the starter … as that smaller motor contains a wire coiled many times around a metal bar.

image

Where is the solenoid located on a Club Car golf cart?

0:095:38Replace Solenoid in Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipCart um your solenoid could be located in a bunch of different places but almost always underneathMoreCart um your solenoid could be located in a bunch of different places but almost always underneath the seat.

How do I know if my solenoid is bad on my golf cart?

4 Signs of a Bad Starter SolenoidEngine Doesn't Crank or Start. ... No Clicking Noise When Trying to Start the Engine. ... Starter Spins Without Fully Engaging the Flywheel (Rare) ... Engine Cranks Slowly (Rare) ... Test the battery. ... Check That Power is Getting to the Starter Solenoid. ... Test the Starter Solenoid Itself.

How do you bypass the solenoid on a Club Car golf cart?

Bypassing Golf Cart Solenoid Method If you do decide to bypass the solenoid, this is what you need to do: Take the two larger wires that connect to the solenoid and connect them directly (keeping all safety precautions in place). This should do the trick and if it does not work then the solenoid is not the problem.

Will an electric golf cart run with a bad solenoid?

The ability of your golf cart to function properly depends largely on the solenoid. If the solenoid is broken and not working correctly, you may notice your golf cart won't start, picking up speed, or even working at all (issues with acceleration could also be caused by a bad speed controller).

Where is the starter solenoid located?

The starter solenoid is above the starter motor. The threaded terminal at left would connect to the battery through a heavy cable. At the right end of the solenoid coil, a linkage inside the housing would engage the pinion visible in the housing at the right side of the motor.

What happens when a starter solenoid goes bad?

When you have a bad starter solenoid, the starter motor won't work. This means the engine won't start when you turn on the starter switch or press the start button. However, if your vehicle has an automatic transmission, the engine could sometimes not crank because of the neutral safety switch.

Can a golf cart solenoid click and still be bad?

Usually, you'll be able to hear the solenoid clicking both on and off whenever you switch your ignition. But if you don't hear anything? It's likely that the solenoid can no longer send electricity out to power the golf cart. In some cases, this happens because the coil of the battery is worn out or is too old.

How do you jump a starter solenoid?

1:035:14How To Test A Car Starter With A Screwdriver And Jumper Cables!YouTubeStart of suggested clipEnd of suggested clipAnd what you want to do is you want to jump this to the s part of the small stud. Okay now once youMoreAnd what you want to do is you want to jump this to the s part of the small stud. Okay now once you do this you're activating a solenoid and a starter. And you should see the gear pop out and spin.

How do you test a club car solenoid?

Turn on the engine of the cart and press the pedal downwards. If you hear a clicking sound, then it means that the low side voltage is working. But, if there is no such sound, it means that either there is no low side voltage or there is a problem with the solenoid. Use a voltmeter and engage the solenoid.

Where is the reset button on a Club Car golf cart?

It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.

Will a bad solenoid click?

A single “click” sound comes from the engine compartment or from under the car. This could mean that the solenoid is trying to engage but that the internal components are stuck and unable to work properly. Repeated “clicking” sounds usually indicate a dead battery.

How do you check if a solenoid is working?

0:441:43How to use a Multimeter: Solenoid Testing - Purkeys - YouTubeYouTubeStart of suggested clipEnd of suggested clipShould not get a reading so the coal resistance is inspect and also it is not a grounded coil so IMoreShould not get a reading so the coal resistance is inspect and also it is not a grounded coil so I know that part of this max which is good why is important he's a multimeter if you use a multimeter.

What is a solenoid on a golf cart?

A solenoid, for our purposes, is a type of relay. A relay is a type of switch that uses a low power circuit to operate a high power circuit. A solenoid uses a magnetic coil (the actual solenoid) on a low power circuit to push a rod that closes a high power circuit. On your golf cart, this high powered circuit is either your ignition on ...

Why does my golf cart have no solenoid?

Golf cart solenoids are also typically one of the first components to fail in your golf cart, because they work very hard, turning on and off every time you stop and go in your golf cart. If you have an issue with no start or no go then your solenoid should be pretty high on your list of things to check.

What is a golf cart go switch?

On your golf cart, this high powered circuit is either your ignition on a gas golf cart or your electrical motor power circuit for an electric golf cart. Basically it’s your golf cart’s go switch, and it’s absolutely essential to your golf cart’s ability to do its job. Golf cart solenoids are also typically one of the first components ...

What happens if a solenoid reads infinity?

If it reads infinity or open lead, then the solenoid has an internal fault and requires replacement. Your solenoid should also have a range that it operates in, and if the resistance reads outside of that range, you should replace the solenoid even if it works to avoid damaging other components.

What is the most important part of a golf cart?

One of the most important components of your golf cart is the solenoid. It is one of the main components of your golf cart that allows it to move. Whether you have a Yamaha, E-Z-GO, or Club Car golf cart, and no matter if it is an electric or gas golf cart, you need a properly operating solenoid to get anywhere. Contents [ show]

What to do if your solenoid doesn't work?

Before you run out and get a solenoid, you’ll have to test the entire ignition system this way to find out what’s not working, and it is a bit of a pain.

What is a micro switch on a gas pedal?

This switch is what sends the low power to the solenoid. The solenoid uses this to create a circuit between the battery and the starter, thus starting your motor and getting you grooving.

Why do golf carts have solenoid?

The solenoid is simply there to allow electricity to flow freely to the controller and motor which will result in a running golf cart. RELATED: 4 Signs you need to Replace your Golf Cart Batteries.

How to check if a golf cart solenoid is silent?

On an electric golf cart, if the solenoid is silent – no clicking – use the setting voltmeter to DC volts using the 200 range. First, turn on the ignition while looking for a reading on the smaller terminals. If nothing is appearing, then press on the accelerator. If the needle doesn’t move, then the problem is not with the solenoid.

Why is my golf cart not clicking?

On an electric golf cart, the most common symptom is the solenoid is not delivering electricity to the controller when the vehicle’s ignition is turned on. In normal operating conditions, the solenoid clicks on and off with the ignition switch. A failing solenoid will generally not click. Two things could be going on here.

What does it mean when a golf cart solenoid goes bad?

Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor ...

What does a solenoid do when you turn the ignition?

Step by step, it looks like this: When you turn the ignition key, a small amount of electricity goes to the solenoid. The solenoid uses that small amount of juice to close two heavy-duty contacts that allows a large jolt of electricity to pass through the starter. The solenoid also sends a pinion gear forward, which is the device ...

Why won't my solenoid click?

The solenoid might not be getting enough electricity to do its work – which could be caused by loose connections, a weak battery or the coil wearing out.

Why do you use electrical tape on a solenoid?

When you do this, use electrical tape to seal the cable ends, so they won’t form a circuit by accidentally touching each other or connecting through a metal conductor inadvertently. Doing this will ensure the vehicle will not run while testing the solenoid.

What is a solenoid in golf carts?

Simply put, a solenoid is a device that can transform electrical energy into mechanical energy. It's a coil of wire which is used as an electromagnet. The solenoid has the capability of creating a magnetic field with the help of an electric current. Solenoids work as the “go switch”, which is a must for any golf cart.

How to tell if golf cart solenoid is bad?

One of the most common and obvious signs of the bad solenoid is the golf cart's failure to start when you initiate the ignition process. Once you click the accelerator and turn on the ignition switch, it is supposed to send a signal to activate the solenoid and start the cart. If the cart does not start, there is a big possibility ...

Why is my golf cart not starting?

If the cart does not start, there is a big possibility of a damaged solenoid. Another reason for a bad solenoid is that the contacts are starting to get damaged due to overheating or high current passing through them. Note: You may not necessarily experience all of these issues to recognize bad solenoids on your golf cart.

Why won't my golf cart turn over?

For a gas golf cart, the most common symptom is the starter failing to engage, so the engine doesn't turn over. Starters have the responsibility of activating the flywheel. When the flywheel starts to work, the starter is supposed to disconnect.

What is a solenoid in a golf cart?

A golf cart solenoid is one of the major components of any golf cart. This part is essential regardless whether you own an electric or gas golf cart because both types primarily rely on a solenoid for their movement. What this means is whichever brand or model you choose for your cart, a solenoid is truly an indispensable part of the vehicle.

What is a solenoid wiring diagram?

A solenoid wiring diagram can be very helpful in guiding you about the various connections made to and from the solenoid. This can come in handy when you set out to troubleshoot a problem in your cart on your own. The solenoid wiring diagram is generally very simple, straightforward and self-explanatory.

How to get a golf cart going without a glitch?

To get your golf cart going without a glitch, you most definitely need the solenoid of your cart to be functioning properly. Thus, it goes without saying that you must check this component occasionally to monitor its performance so that you don’t get stranded mid-way.

What does the inductive throttle sensor do on a golf cart?

When you push down the pedal of the golf cart downwards, the inductive throttle sensor sends out the first low power signal to activate the solenoid on its low side and the speed controller. The low side is the steel rod of the solenoid.

How often do solenoids work?

Since solenoids need to work very frequently; turning on and off each time you use the cart, they are prone to wear and tear easily. This is not surprising as they can switch on and off as much as 1,500 times a day). One of the first indications that a solenoid is faulty is when your cart fails to start.

Why is my golf cart not clicking?

This may be because the safety reed switch is not working properly in the charger socket. There could be a loose connection of the MOLEX plug.

What does it mean when your car doesn't start?

If the cart does not start, then it is a clear sign that your solenoid does not have a problem. However, if it does, this does not indicate that the solenoid is the cause of the problem. You will have to check out the complete ignition system.

Special offers and product promotions

Amazon Business: Make the most of your Amazon Business account with exclusive tools and savings. Login now

What other items do customers buy after viewing this item?

Pages with related products. See and discover other items: club car precedent, club car® precedent, Gas Carts

How to Tell if a Golf Cart Solenoid is Bad

Many golf cart owners had solenoid problems and delay as a result of them. To examine and repair a golf cart, you must first know what a solenoid is.

What Happens To Your Golf Cart When The Solenoid Goes Bad?

The large contacts in a gas golf cart may refuse to release, causing the starter to run even after turning off the ignition. Furthermore, the springs that pull the gear back to its resting state may start to break down, making the starters remain disengaged all of the time. (Starters are designed to get the engine running, then disconnect.)

How Do You Test A Golf Cart Solenoid?

The following steps will tell you how you can test a golf cart solenoid.

Can You Replace The Solenoid On A Golf Cart?

Changing the solenoid on your golf cart is normally easy, but you need a few types of equipment and a basic understanding of how the system operates. The ignition circuit connects to the solenoid, in the engine bay. When turning the key, the solenoid acts as a switch, energizing the ignition coil and igniting the fuel-air mixture.

How Often Does A Golf Cart Solenoid Go Bad?

Your solenoid is prone to overheating as a result of its regular use. As a result, you may notice irregular operation after a while — it may work one time, but not the next. Loose cables or dusty interiors could cause your cart’s inability to start.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9