the thermostat housing is normally found where the top radiator hose connects to the engine. it is normally held on with 3 bolts and the thermostat is inside. do not forget to use a new gasket as well when replacing the thermostat and to top up the coolant with a water and antifreeze mix rather than just water. Mar 30, 2011 • 2002 Volkswagen Golf
Where is the thermostat on a VW Golf?
5:3611:23How to Replace the thermostat on a Volkswagen Golf 2004 to 2008YouTubeStart of suggested clipEnd of suggested clipAnd pull it from the cover remove the old seal and clean the mating face of the cover locate the newMoreAnd pull it from the cover remove the old seal and clean the mating face of the cover locate the new seal on the cover then insert the thermostat.
How do you change a thermostat on a VW?
1:4112:12Thermostat Replacement and Cooling System Upgrades - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd that'll help it come off a little bit easier once you release the spring clip gently pry theMoreAnd that'll help it come off a little bit easier once you release the spring clip gently pry the hose. Away from the radiator. You may have to rock it back and forth a little bit to get it to come.
How do you change a thermostat on a Golf TDI?
1:056:11VW Golf TDI Coolant Thermostat-How to Easily Replace without removing ...YouTubeStart of suggested clipEnd of suggested clipSo a lot of people say you need to remove the alternator to get access I'm going to have a goMoreSo a lot of people say you need to remove the alternator to get access I'm going to have a go initially.
How much is a VW thermostat?
between $10.99 and $419.99VW thermostat typically cost between $10.99 and $419.99.
Where is a car thermostat located?
Most cars have a top-mounted thermostat located close to the water pump on the cylinder head. The top radiator hose feeds coolant through the thermostat into the engine. If you can't locate the thermostat, simply follow the hose until you see the housing containing the thermostat where the hose joins the engine.
Where is the thermostat on a mk5 Golf?
The thermostat (red arrow) is hidden behind the throttle body intake tube, the lower radiator hose (blue arrow), the charged air intake tube (yellow arrow), the additional coolant hoses (purple arrow) and the intake hose (green arrow).
How do you change a thermostat on a VW Golf mk4?
1:4015:38Mk4 Volkswagen Golf GTI Thermostat Replacement DIY (1998-2006 VW ...YouTubeStart of suggested clipEnd of suggested clipAnd also i'd recommend having some pension oil such as pb blaster.MoreAnd also i'd recommend having some pension oil such as pb blaster.
How do you change a thermostat on a golf 4?
4:1012:20VW Golf mk4 TDI ALH thermostat removal and install - YouTubeYouTubeStart of suggested clipEnd of suggested clipOff you're just going to pull it straight out towards you and now that exposes the thermostat. AndMoreOff you're just going to pull it straight out towards you and now that exposes the thermostat. And you can see that rubber o-ring is around there we'll have to get that off.
How do I change the thermostat on my ALH TDI?
2:295:47VOLKSWAGEN ALH TDI THERMOSTAT REPLACEMENTYouTubeStart of suggested clipEnd of suggested clipSo first I used two channel locks to remove. This hose clamp pull it back and then that just slidMoreSo first I used two channel locks to remove. This hose clamp pull it back and then that just slid right off that. Once I raise this up a little bit more cooling trained.
What are the signs of a faulty thermostat?
Thermostat failure symptoms that you should knowHigh temperature readings. The main symptoms of a failing thermostat are related to engine overheating. ... Erratic changes in temperature. ... Leaking coolant. ... Increased fuel consumption. ... Unusual noises.
How do you diagnose thermostat problems?
Bad Thermostat SymptomsOverheating Engine. If the thermostat stays closed, the engine's coolant cannot reach the radiator and, therefore, cannot cool down. ... Temperature Fluctuations. ... Heater fluctations. ... Possible Leakages & Steam from engine. ... Rising Temperature and Full Expansion Tank.
How much is a engine thermostat?
But for the average car owner, you can expect to pay between $140 and $300 for a professional mechanic to replace the thermostat in your vehicle for you. The cost of the actual thermostat unit itself is usually between $20 and $80 but can be more for luxury or sports cars.
The thermostat helps control the engines temperature
If your car is running too hot and there is the proper amount of coolant in the car and it is not leaking, or your car is taking a long time to warm up, there is a very good chance your thermostat is bad and needs to be replaced.
Project Photos
Figure 1 Begin by safely jacking up and supporting your car. With the car safely off the ground you will need to remove the engine tray. A great many of these car have had the engine trays and front side shields removed over the years and not replaced.
Why does my golf club temp gauge spike?
But, it’s not the only reason. Other things that can cause the temp gauge to spike are: Low Coolant- If your Golf has been losing coolant, it’s possible that you’ve finally leaked out enough that the cooling system can no longer do its job.
Is it cheaper to replace a thermostat?
Replacing a thermostat is a relatively affordable repair . If you have reason to believe it’s gone bad, ignoring it will only end up costing a lot more money in the long run.
URO Temperature Switch URO-000172
Notes: Coolant Temperature Sender. 4-Pin, 20mm - Dual Temperature Sender/Auxiliary Fan Switch. To Assure Proper Temperature Reading and Connection, Cleansing of Plug Connector Pin is Also Recommended
URO Temperature Switch URO-000173
Notes: GTI 1.8T Model. Coolant Temperature Sender.4-Pin-Green-20mm, Dual Temperature Sender/Auxiliary Fan Switch.
