The balancer marks both point to the 1 oclock position with black links on each and the 3rd black link will be facing a mark to the 7 oclock position on the crankahaft gear. Everything is done with the piston at TDC no 1 cylinder so get it there before you put the cam shafts in position or you will bend valves.
Full Answer
What type of cartridge is present in Yamaha G2 golf cart?
Three-stage; internal primary, urethane-foam pre-cleaner plus high-capacity paper filter cartridge is present in Yamaha G2 Golf Cart. it helps to improve the performance of the cart.
What kind of engine does a Yamaha G2 have?
Yamaha G2 Golf Car has a 357cc single-cylinder 60-degree inclination overhead valve engine with an 8:1 compression ratio, forced air cooling, and splash oil lubrication system. With a fuel tank size of 6.3 gallons (24.0 liters) and a consumption rate of 23.5 mpg (9.41 km/liter), this vehicle is ideal for long trips.
How fast does a Yamaha G2 golf cart go?
Yamaha G2 golf cart has a speed of 12 mph (19.0 km/hr), which is an industry-standard for old golf carts before the 2000s. However, there’s always an option to increase your cart’s speed by following the tips mentioned below: Improve the golf cart tires.
How much compression should a Yamaha G2 golf cart have?
The vast majority of gas engines should have a compression of about 150 psi. If your golf engine is new then your compression should be between 150psi – 160psi.
How do you adjust the governor on a Yamaha G2 golf cart?
Yamaha G2 Governor AdjustmentLocate the lever present above the transaxle. This lever houses a 10mm nut.Tighten the nut or move it inwards as much as you want based on the desired speed using a 1/4″ drive ratchet with a 10mm deep socket.
How do you work a Yamaha golf cart?
1:502:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
What engine is in a Yamaha golf cart?
At 357cc and 11.4 horsepower, it is Yamaha's most fuel-efficient carburetor engine. The PowerTech AC enables muscular hill climbing and a smooth ride. At 48 volts, its output is 5.0kw (6.7hp) for up to 60 minutes before recharging.
How can I make my Yamaha g2 gas golf cart faster?
0:291:37How to make your Yamaha Gas Golf Cart go faster. 2007-2018 - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou can bend the spring make it go a little faster.MoreYou can bend the spring make it go a little faster.
What does removing the governor do?
Removing the governor will increase the maximum rpm of the engine, but the internal parts of the Predator 212 are designed for 3600 rpm. Generally, this isn't an issue with just the governor removal, the internal parts can usually withstand 5000 rpm without breaking apart (unless you go full throttle for too long).
What year did Yamaha drive 2 come out?
2017In 2017 Yamaha introduced the current model, the Drive2.
How much is a 2020 Yamaha golf cart worth?
between $5,000 and $10,000Yamaha – NEW When purchasing a brand new Yamaha golf cart, you can expect to pay anywhere between $5,000 and $10,000.
How do I tell what model Yamaha golf cart I have?
Usually found under the seat, under the driver side glove box area or on the chassis towards the rear of the golf cart. Under the bumper area usually. Once you have located this you can use the chart below to cross-reference those numbers and determine the year and model of your Yamaha Golf Cart.
What year is a G2 Yamaha golf cart?
Yamaha Electric & Yamaha Gas Golf Cart Serial Numbers:Yamaha G1 to G11Yamaha's Longest Running Cart Model. The G-Series.JA2-000001G2 GAS1988J55-000101G2 GAS1989J55-100120G2 GAS199084 more rowsWhat Year & Model Is My Yamaha Golf Cart?https://www.golfcarttiresupply.com › what-year-is-my-ya...https://www.golfcarttiresupply.com › what-year-is-my-ya...
What's the horsepower of a Yamaha golf cart?
11.4 horsepowerOur Yamaha-built engine brings you over 60 years of proven performance featuring a filterless oil system for ease of maintenance. At 357cc's, producing 11.4 horsepower, it's the most fuel efficient carbureted engine in the industry with all the great features built into the Drive2 line of cars.5678_Fleet BrochureReprint_v2 LR.pdf - Yamaha Golf Carhttps://www.yamahagolfcar.com › Images › docshttps://www.yamahagolfcar.com › Images › docs
How fast does a Yamaha golf cart go?
Most electric golf carts are faster than gasoline golf carts. Although, new gasoline and electric golf cart versions of Yamaha all have the same top speed. The top speed of both versions of Yamaha golf carts is 19 mph (31 kph).Gas vs Electric Golf Carts - Eco Planetahttps://ecoplaneta.com › gas-vs-electric-golf-cartshttps://ecoplaneta.com › gas-vs-electric-golf-carts
How do you adjust the governor on a Yamaha?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipItself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.
How do you adjust the governor on a Yamaha electric golf cart?
1:132:57Yamaha G29/DRIVE Governor Speed Increase | ASK DAVE | Golf Cart ...YouTubeStart of suggested clipEnd of suggested clipAnd locating the governor under the service panel in the rear above the engine. For reference it'sMoreAnd locating the governor under the service panel in the rear above the engine. For reference it's just opposite the driven clutch at the rear of the engine. Compartment.
Can you make a Yamaha electric golf cart faster?
Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart's motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart's speed dramatically.
Where is the governor on a Yamaha gas golf cart?
1:003:57How to Adjust Governor on Yamaha G29 Drive Gas Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipLet us set this inspection panel here just to give you an idea of where to look. So on your car youMoreLet us set this inspection panel here just to give you an idea of where to look. So on your car you take the rear inspection panel off right underneath it here. You will have a spring actuated
Yamaha Golf Cart won't start
did you leave the key on and kill the battery or a light or something double ck that battery , they will still light up the ignition and lights and ll but does not have enough to crank the starter , that is what is sounds like to me be put a jump on it or charge it and try again , when you turn on the ignition does the lights light up on the dash panal if so the batter is low.
Oil and fuel blowing out through top of motor in yamaha golf cart 4 stroke engine
Engine got to much oil in it? Worn engine allowing fuel down into engine diluting the oil and raising the oil level? Blocked engine breather, pressurising the crankcase. Oil change and clean the breather. Worth a try
How do i set the timing on a yz450
Set the piston to TDC (top dead center) this is the higest point the piston will rise before moving on to the down stroke, either by lining up the marks on the crank rotor or a long screw driver (large handle so it wont fall in) down the plug hole and watch for the highest point lock or hold at this point.
Yamaha 4 stroke golf cart back fires all the time..Replaced coils and the carby but no change
Very important... valves get out of adjustment and are easy to set. This is where I would start FOR SURE. Check out www.buggiesgonewild.com and an example of how to do it on EZ GO 295 http://www.buggiesgonewild.com/ezgo-gas-tech/1196-ezgo-295-350-engine-valve-adjustment.html
Vw golf 1.4 16v after changeing timing belt car idles eratticaly or not at all. Timing marks correct at crankshaft, cam pulleys locked as per haynes manual!
The timing could be 180 degrees out you will have to do it all over again. Bring #1 cylinder upto TDC check the distributor rotor arm that it is pointing to #1 plug wire, It is important that the cams are on the intake stroke and not on the exhaust stroke. The crank is no big deal just make sure the marks are lined up.
Will not start up I have no compression but i have fire and fule. It is a Yamaha 2 stroke engine in a yamaha golf cart . Just wondering if it has a compression release on it that i'm not seeing. Garry
I find with two stroke engines the carb gets all gummed up if you store it for the winter. A good carb cleaning usually does the trick
Geting the timing right for my 85 xj 700
86 nissan 4×4 3.0. V6 distributor set with number 1 tdc but timing marks on pulley are about 180 degrees off engine starts and runs