Why is my golf cart pulling left?
If it’s off on the left side, that misalignment will contribute to the golf cart pulling left. Issues with steering and suspension components like spindles and tie rods can affect all of these measurements.
How to fix a golf cart that won’t run?
You can also try to apply duct tapes over the air box to see if its remains air tight and prevents air moisture to get inside the tank. The hose may also be taken off to check if the golf cart ends up running smoothly. The air box gasket can be replaced with a new once to check if the problem persists.
Why is my golf cart not charging?
Sometimes you might have had this happen to your golf cart. You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.
How do you remove a motor from a golf cart?
Use a jack and lift the golf cart on the right axle side. Slide the motor off and catch it as it reaches the end of the shaft. Remember to set the motor down lightly on the surface. Use a small standard screwdriver and pull out the middle pin of the fastener by about one-quarter of an inch.
How do you get a stuck motor out of a golf cart?
To solve this problem, apply a few coats of WD-40 or PB Blaster around the spline and spline coupler and let it stay overnight. Shake, pull and tap on the armature a few times the next day until it comes off. The other option is to remove the rear tires and axle from the cart.
How do you remove an electric golf cart motor?
2:005:58EZGO RXV Golf Cart Motor Removal & Installation How-To - YouTubeYouTubeStart of suggested clipEnd of suggested clipTo remove the motor. Give it a little twist and up-and-down motion and then slide it directly allMoreTo remove the motor. Give it a little twist and up-and-down motion and then slide it directly all the input shaft.
Why wont my golf cart go forward or reverse?
The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you access a golf cart motor?
3:169:45How To Install Golf Cart Motor | Episode 3 - YouTubeYouTubeStart of suggested clipEnd of suggested clipOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock thatMoreOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock that gives you direct access. So you can unbolt it loosen everything and put it right out the side.
How do you change an ezgo electric motor?
0:1612:391996+ EZGO TXT 36v/48v Motor Swap / Install ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipBut the motor will come off the same so we're going to take off this seat. Now we've got the seatMoreBut the motor will come off the same so we're going to take off this seat. Now we've got the seat off we're going to remove the motor cover which it has one two screws right there. And then three on
Why does my golf cart click but not move?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How does a golf cart forward reverse switch work?
0:139:43Golf Cart Forward and Reverse Switch Direction Selector Tutorial - YouTubeYouTubeStart of suggested clipEnd of suggested clipThat is brand new it simply cables connect to the bright copper colored contacts. And the switchMoreThat is brand new it simply cables connect to the bright copper colored contacts. And the switch rotates through a hand action and that changes the polarity.
Do all golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I reset my club car motor?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you remove the motor from a Yamaha golf cart?
2:418:33Yamaha G5 Golf Cart, engine and transaxle removal, only 4 boltsYouTubeStart of suggested clipEnd of suggested clipIf it's rusty you can cut it across here. If it's um if you want to save. It. Right if you want toMoreIf it's rusty you can cut it across here. If it's um if you want to save. It. Right if you want to keep it alive. You undo this bolt tap it out right.
How do you remove a Yamaha golf cart engine?
1:388:59Yamaha Drive G29 Golf Cart - Body Removal - YouTubeYouTubeStart of suggested clipEnd of suggested clipBuild we are going to be replacing. This top with a black top so i'm going to just go ahead andMoreBuild we are going to be replacing. This top with a black top so i'm going to just go ahead and unbolt the top from the top supports. And remove the top by itself. And then i'll come back and unbolt
What are the 4 terminals on a golf cart motor?
If you're unsure if it is working, it is simple to test. There are four terminals on a solenoid: usually two large and two small. The small terminals are connected to the battery, and the large terminals are connected to the motor. Disconnect all wires from the two large terminals.
Why is Your Golf Cart Pulling in One Direction?
If when you release the wheel, your golf cart drifts in one direction, or your golf cart steering pulls to one side, it’s likely one or more components in the following systems is the culprit:
What to check if your golf cart is pulling to one side?
Improper front tire pressure or worn tires should be the first things you check for if your golf cart is pulling to one side or the other. The kind of tires you have on your cart will, of course, be specific to its use; if your cart is designed for off-road, then their tread will be specific to that context. If you use your golf cart on a golf course, then the tires will be “turf approved.”
Why do golf cart tires need to be aligned?
Proper front wheel alignment ensures that the golf cart tires turn in unison and travel in the same direction. In addition to keeping your cart from pulling in one direction or the other, correct alignment of the front end protects your cart’s suspension system. Improper alignment can damage the cart’s suspension components and lead to excessive wear on the tires.
How much pressure should I put on my golf cart tires?
You can find the proper pressure for your golf cart tires by looking at the tire sidewall. Usually, the pressure will be between 15-25 PSI (pounds per square inch), with most tires noting 20-22 PSI. Note that the tires should never be overinflated. Beyond the resulting rough ride, over-inflated tires mean less traction, which can be dangerous.
How are the wheels on a golf cart positioned?
The way the wheels on your golf cart are positioned is determined by camber, caster, and toe.
What brakes do golf carts use?
Most golf carts use a rear drum brake system . If the brakes wear unevenly, this can contribute to a cart pulling to one side. An inspection of the brake system will include brake pedals, cables, and linkage, brake drum, and shoes.
What is the spindle on a golf cart?
Spindle: component between the wheel and steering gear mechanism. In golf carts, the spindle pivots on a component called a king pin—resulting in the steering system turning the cart from side to side.
Why is my golf cart running so slow?
It may be that the air box is not sealed properly due to which air would enter inside the tank. That would result in the golf cart running very sluggishly and causing tons of problems.
Why is my golf cart starving for fuel?
Why is your golf cart not getting fuel? A golf cart can be starving for fuel because of old gas in the engine, or because the flow of gas to the fuel tank is blocked.
Why does my EZGO stop?
If you have a EZGO and it has come to an abrupt stop, then it may be because of the golf cart not getting adequate fuel supplied to its tank. Check if all fuel pipe hoses are properly connected and there is no crack or hole in it. The brass vent needs to be absolutely clean.
What is the G16 golf cart?
The G16 model of Yamaha golf carts suffers from the glitch of not receiving the required levels of gas, which ends up hampering the overall performance of the golf cart.
Why does my golf cart have a dirt filter?
Some of the possible causes are stated below: There could be dirt filled in the carburetor, potentially stopping the gas flow from the tank to the engine. If the air filter can be opened from the golf cart and around 2 ounces of fresh gas get drilled in to the pump, then the issue may get sorted.
Why is my carb pump not getting sorted?
If the problem still does not get sorted, then chances are that the pump is faulty and the vacuum line has got clogged.
What causes a vacuum tube to drain?
Chances are that the vacuum tube is cracked or damaged which may drain the fuel off the tank. In such case, the best bet would be to replace the tube.
Why does my golf cart keep powering off?
If the cart starts powering off after a new installation, then you will know that the issue is caused due to errors with the installation.
Why does my golf cart cut out?
Another reason why golf carts can cut out is due to problems with the battery voltage or water levels.
What does the first beep sound on a cart mean?
The manual will have the list of beeps and their respective fault codes. The first beep sound will indicate the performance factor.
How to check battery water level in golf cart?
How to Check Battery Water Levels in a Golf Cart. Check if the voltages in both the batteries are at the designated levels. Also, if the water in the batteries has dried up, it could cause this issue. Check for the electrolyte and water levels in the batteries. Make sure that you are not overcharging or undercharging your batteries as these could ...
Why does my cart have a loose solenoid?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch.
What causes a cart engine to die?
If your cart engine dies suddenly, it may be the carburetor causing the issue. Read the following steps to fix it:
What happens if you charge your golf cart?
You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.
Why is my golf cart not moving?
The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs of a problem with the speed controller of the vehicle. Here are a few things you can do to fix the issues associated with your speed controller.
What happens when a golf cart is not working?
When the speed controller malfunctions or does not work properly, the cart will move but with several breaks in between. The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs ...
How to slow down a golf cart?
If you wish to have control over the speed of your golf cart, you have to ensure that the speed controller is in good condition. Apart from ensuring that the vehicle runs fast, the speed controller also helps in slowing it down.
Why EZGO gas golf cart won’t accelerate?
The EZGO gas golf cart is known to be one of the most sturdy and durable golf carts out there. If it does not accelerate at some point in time, there is a possibility of some damage to its solenoid. The solenoid can be defined as the primary or the most basic electrical switch present in the EZGO gas golf cart. Its main function is to enable the flow of electricity from the battery into the motor.
How to tell if a Yamaha golf cart is going to start?
Your Yamaha G1 golf cart may start up easily and you hear the solenoid making a click sound when you press the pedal . Despite this, if the vehicle suffers from acceleration problems, you could try pushing and releasing the pedal several times.
How does a speed controller work on a golf cart?
Once you do this, the brake should release and the cart will start accelerating once again. The speed controller works towards regulating the speed of the golf cart. There are instances when the speed controller fails but the vehicle will still start and move ahead.
Why is my golf cart solenoid not working?
If you encounter a problem with the solenoid of your golf cart, then you must know that it could be because of a faulty speed controller. To check the condition of your vehicle’s solenoid, you will be required to take a reading of the voltage and check if it is the same as the reading from the battery.
Why won't my golf cart start?
Your golf cart won’t start if there is a problem with the fuel, airflow, or electrical system. Any one of these areas can cause your golf cart to fail to start. Try these steps to troubleshoot and pinpoint the exact failure point.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
How Do You Troubleshoot a Gasoline Golf Cart?
Check the fuel level, regardless of what the gauge says. I have seen a stuck fuel tank float baffle a mechanic for three hours while looking for a reason for a “full” tank not delivering the fuel.
How Do You Know When Golf Cart Batteries Are Going Bad?
As batteries start to lose their health and take longer to accelerate, you find that you can’t hit the top speed anymore or have problems climbing hills.
Why Does The Golf Cart Battery Drain When Everything Is Off?
Disconnect the negative battery cable ground wire and connect your multimeter set to measure the voltage between the battery terminal and the ground wire. If you’ve turned everything off and are still getting a reading, then you have a faulty component in the electrical system. At this point, we’ll need to start pulling fuses and disconnecting things one of the time to find out what is draining the battery.
How Do I Know If My Golf Cart Solenoid Is Bad?
Older golf carts used a series of solenoids to drive the cart forward and backward and set the speed of that motion.
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
