Why does my golf cart keep running but not shut off?
1994 Club Car golf cart keeps running This kind of problem with shutting down can occur in both gas and electric golf carts. There are different reasons why it can happen; some of them are discussed below: May be the starter is still operating because the spring, which pulls back the pinion to the rest pose, is not doing its job correctly.
Why does my golf cart cut out at high speeds?
Some people have experienced these issues where the golf cart works properly at normal speeds, but cuts out when driven at high speeds. If your golf cart cuts out at high speeds, then you might have to take a look at the internal mechanism to figure out what the issue is.
What are the problems with a club car golf cart?
The problems with a club car golf cart appear when either the OBC or the solenoid is not functioning correctly. OBC regulates the car’s batteries’ charge, and the solenoid supplies the electrical current from the battery to the entire vehicle. Resetting the OBC should solve the problem but if not, check whether the solenoid is okay.
Why does my golf cart stutter when I drive?
Coil of solenoid: The coil attached to the solenoid of the Golf Cart may get too hot and bypass the functioning of the solenoid. That may cause a glitch which may end up in the Golf cart causing stutters while being used. Change of batteries: Are your batteries running for almost 10 years?
What causes a golf cart to just stop running?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch. If the micro-switch is faulty, it can also cause the cart to suddenly stop midway.
What causes a golf cart to stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. What is this? The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
What causes a gas golf cart to stop running?
Your golf cart may stop frequently while running in case of a faulty spark plug, defective TCI/carburetor, or improperly seated internal baffles and airbox lid. Sometimes, an empty or close-to-empty fuel filler, low battery charge, a binding linkage, or a bad fuel pump can cause a golf cart to stop running.
Where is the reset button on a golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
How do you know if your golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you test a fuel pump on a golf cart?
A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you've enjoyed out tutorial on golf cart fuel pumps.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How do you adjust the carburetor on a Club Car golf cart?
Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.