Golf-FAQ.com

why does my club car golf cart jerk

by Myrl DuBuque Sr. Published 3 years ago Updated 2 years ago
image

Why does my Club Car golf cart jerk when taking off?

  • Faulty MCOR. Get the Club Car checked for a faulty MCOR and have it replaced. ...
  • Low battery charge. Check the overall battery pack charge and also the charge of each battery separately. ...
  • Wiper arms and contact out of adjustment. ...
  • Clutch problem. ...
  • Melted contacts on the F/R switch. ...
  • Solenoid is stuck. ...
  • Worn-out or drive belt that is out of alignment. ...

The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.

Full Answer

Why is my golf cart jerking from the front end?

A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking. So, make sure that all the tires are of even length and width when you buy your desired golf cart.

How to fix jerky acceleration on a club car golf cart?

Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk. Faulty MCOR. Low battery charge. Wiper arms and contact out of adjustment. Clutch problem. Melted contacts on the F/R switch. Stuck solenoid.

Why does my 2013 Club Car Jerk when I accelerate?

One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn't help, getting a new battery …

Why does my golf cart shake when I stop?

The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or …

image

What makes a golf cart sputter?

Could be some water in the gas. Water is heavier than gas and goes to the bottom of the tank. If you cart sits for a while with gas in it it can loose some of its volatility.Mar 17, 2018

How can I make my club car go smoother?

6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.May 18, 2021

Why does my electric golf cart go slow uphill?

The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.

How do you test a golf cart MCOR?

To test the MCOR, look for the line item that says THROTLE. With the cart in neutral, slowly depress the gas pedal. You should verify that the throttle moves from 0% to 100% in a smooth manner. If you see it jump around (ie.

How can I make my Gas Club Car golf cart go faster?

0:361:31Club Car Precedent Speed Increase SUPER EASY!!! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt slows it down. And if you turn it that way or clockwise it speeds things up. Very. Very simpleMoreIt slows it down. And if you turn it that way or clockwise it speeds things up. Very. Very simple loosen that bolt. Turn the pin one way or the other to make it faster or slower.

How can I make my electric golf cart go faster without upgrading?

How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.

Why is my club car so slow?

Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.Jul 14, 2021

Where is the speed sensor located on a Club car golf cart?

Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.

How do I know if my golf cart motor is bad?

You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.May 14, 2021

How do you troubleshoot an electric club car?

There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.

Where is the MCOR located on Club Car?

2:3313:00How to install an MCOR (Motor Controller Output Regulator) on a ...YouTubeStart of suggested clipEnd of suggested clipThis is where just MCOR is located once you get that there's a trapdoor right here that's usuallyMoreThis is where just MCOR is located once you get that there's a trapdoor right here that's usually held down by a little plastic Christmas tree you open that up.

What year did Club Car start using MCOR?

This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator". There are four different MCOR models from different years and cars: MCOR1 - This was used on all DS & Carryall cars from 2000.5 until 2011-2012.

What to do if golf cart has multiple limit?

If the golf cart is a speed switch/multiple limit style, check for proper engaging action of the wiper arm and contacts and take the necessary action for this to happen if they don’t.

Is the Ping G25 adjustable?

Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...

Why does my golf cart jerk?

The most common reason why are golf cart jerks could be that the water has entered some of the components . There are a sensor and a micro-switch under the driver’s side floor mat. If water enters these components, especially the switch, it could cause the cart to jerk while starting.

Why does my clutch jerk?

Well, the issue could be related to the clutch. The primary clutch weights could be broken, which might be causing the jerks. It would be a good idea to get your clutch checked to help resolve the problem. Another cause of this issue could be the accumulation of dirt or dust particles in the clutch.

Why does my golf cart shake?

If your golf cart is shaking at high speed, it may be because of damaged springs in the cart and broken solenoid. To fix this issue, you have to replace the springs if it’s often due to excessive use. You can also use a steering stabilizer to control your speed and manually change the gear.

Why does my Club Car DS shake?

The Club Car DS shakes while accelerating due to various reasons that include low & dead batteries, bad motor controller output regulator, and other issues. It’s usually because of a lousy adaptor and clutches.

How to fix a golf cart tire?

To fix the issue, you should align the tires. Check the tire’s height, and both tires need to place in the same position. Remove the tires and clean them if there are any particles stuck in them. Check the engine of your golf cart, steerings, and solenoids. Install a new tire if it needs, and then go for a test driving.

Is the Ping G25 adjustable?

Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9