Why does my golf cart smoke when I start it up?
How to Fix Golf Cart Blowing Out (White Smoke) White smoke usually means your engine is running hotter than normal. If there’s a bit of smoke when you’re just starting the cart, it might just be the cart warming up. Excessive amounts of white smoke might mean there’s a problem with your cooling system.
Why is my golf cart spitting gas?
Your car spitting gas could be caused by a few things such as a jumping timing belt or a stuck valve. Firstly, it could be a timing issue. As mentioned before, if your timing belt jumps, your cart might spit gas.
How do I Stop my Electric golf cart from smoking?
Just run your cart hard for 30 minutes to an hour to burn off the excess oil in the muffler and see if your smoking problem is solved. Cleaning the carb of your cart or replacing it with a new OEM carb can fix needle/float issues which cause smoking problems.
Why is my golf cart burning oil?
Your golf cart is burning oil because it has too much oil in the airbox. If your oil is overfilled, then drain it out and put in exactly one quart of oil into your cart engine. You may have overfilled your cart with oil because your dipstick has an incorrect full marking.
How do I stop my golf cart from smoking?
Cleaning the carb of your cart or replacing it with a new OEM carb can fix needle/float issues which cause smoking problems. Replacing the fuel pump, fuel filter, spark plug and air filter of your cart can also fix smoking problems.
How do you stop a golf cart from burning oil?
1993 Club Car is Smoking and Burning Oil When your 1993 Club Car is burning excessive oil, you can try draining out all the oil, get the filter replaced and clean the carburetor thoroughly. After completing this process, start the engine again and check if it is still burning oil.
How do you adjust the carburetor on a EZ Go golf cart?
2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.
What causes a gas golf cart to backfire?
The golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the scale is out of adjustment and, in turn, stops the vessel from closing when the microswitch makes contact with the ignition.
Why is my electric golf cart smoking?
Oil Problems With Your Cart The most likely trigger for a smoking golf cart is oil problems with your cart. These issues can vary depending on many factors, such as what type of oil you use, how much the oil has disappeared, and much more.
What is the best additive to stop oil burning?
8 Engine Oil Additives that Stop Burning OilArchoil AR9100 Oil Additive. What is this? ... Liqui Moly 2037 Pro-Line Engine Flush. ... Lucas 10001 Heavy Duty Oil Stabilizer. ... Sea Foam SF-16 Motor Treatment. ... Bar's Leaks Engine Repair. ... BG MOA Part # 110 Engine Oil Supplement. ... Tribo Tex. ... REV X Diesel Oil Additive & Fuel Kit.
How do you adjust an ezgo valve?
5:2111:54EZ GO Golf cart valve lash adjustment - YouTubeYouTubeStart of suggested clipEnd of suggested clipI'm adjusting the clearance between the valve and the rocker arm. Okay. So you screw that in until.MoreI'm adjusting the clearance between the valve and the rocker arm. Okay. So you screw that in until.
How do I clean the carburetor on my golf cart?
10:1218:51Carburetor cleaning on EZGO gas golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipFirst i'm trying to clean everything out scrape off all the gunk make sure all the passageways areMoreFirst i'm trying to clean everything out scrape off all the gunk make sure all the passageways are open this stuff has been released from the sides. And then spraying it with carb cleaner.
How do you make the ezgo gas golf cart faster?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
How fast can a gas golf cart go?
18 - 20 mphSpeed and performance: A gas cart can run up to 18 - 20 mph and there are not many speed upgrades you can do to one. In addition, electric carts will get up to top speed faster as well.
How do you adjust the throttle on a golf cart?
Pull the spring that is present around the plastic piece located behind the shifter. Spin it until it falls back. Loosen the throttle cable present in the cable box to adjust the extent to which you can take it out of the housing. Press the accelerator so that the golf cart starts up and begins to idle.
What causes a gas golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
Why does my golf cart blow out white smoke?
The white smoke is probably being caused by the oil being burnt by the engine and not the gas .
Why does my golf cart spilt gas?
The most likely cause of gas spitting from the golf cart valve is due to the needle valve in the carburetor of your cart not working properly.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
Why does my cart sputter?
Aside from that, your cart may have a sputtering engine because you have a fuel line problem. Check if your siphon tube needs to be blown out or just straight up replaced. A sputtering engine may also be a sign that you need to replace your fuel filter. Lastly, it might be that your carburetor is too dirty.
How to fix smoke in a cart?
Fill your engine with the correct amount of oil. If your carts muffler has oil in it, it will blow out smoke. If you’ve got this problem, run your cart hard on a long run to the oil out of the muffler. You can also just switch out your muffler with a new one to solve this problem.
How to check oil in a car?
First things to check is that you have the correct amount of oil in your engine as you might be overfilling it. Check it using the dipstick in your cart. If your cart has been lifted though, you can’t go by the full mark on the dipstick. You’ll need to use the specified amount of oil for a refill in that case.
Why does my carburetor smoke?
Excessive amounts of white smoke are a sign that you have a problem with your cooling system. It could also be a sign that you have water in your cart system, so make sure you take the time to clean the carburetor.
Why does my golf cart stop moving?
This Golf cart is very temperamental, and even things like over-tightening a stud can make it stop moving. Check the F/R switch stud for overtightening. If it is over-tightened, the contact will not connect with the switch. Adjust this, and your golf cart will start working.
Why won't my TXT golf cart charge?
A TXT golf cart may not charge because of loose or broken wires, a dirty charging port, a blown fuse, or problems with the auxiliary contact.
Why is my cart sluggish?
If your cart has a dirty carburetor, it may be sluggish during acceleration. You can prevent these issues by regularly cleaning the carburetor.
Why are my golf cart drum brakes stuck?
Drum brakes can get stuck due to rust and corrosion. To remove your E-Z-Go golf cart drum brakes, follow these steps.
What to do if your charger is defective?
If your charger is defective, replace it with a DPI charger.
What does it mean when your cart has blue exhaust?
If you have blue exhaust, something is wrong with your cart. It can be a sign of a problem with your engine oil. Address this problem immediately, as it could lead to an engine fire.
Why does my Yamaha golf cart smoke?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why does my golf cart burn oil?
Your golf cart is burning oil because it has too much oil in the airbox. If your oil is overfilled, then drain it out and put in exactly one quart of oil into your cart engine. You may have overfilled your cart with oil because your dipstick has an incorrect full marking. Fill in your cart then mark the correct full position on your dipstick.
Why is there oil in my Yamaha golf cart?
Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine. To fix this, drain out all the oil in your engine then fill in exactly one quart of oil.
How to fix a muffler on a golf cart?
There are two ways to fix this problem; the first is to run your cart long and hard for 30 minutes to an hour and then let the cart cool off. The second is to remove your muffler and burn it out on a bonfire to clear up all the oil and soot in it.
Why is my Yamaha G9 smoking?
Your Yamaha G9 might be smoking because your oil rings are stuck on a piston due to engine sludge buildup. If this is the case, your engine needs to be rebuilt to fix it. Your G9 might be smoking because of oil in the muffler. Run your cart hard for 30 minutes to an hour or cook your muffler in a bonfire to fix this.
How to fix a G16 airbox?
Fix this by draining your G16’s oil and then filling in exactly one quart. Clean out the excess oil in your airbox as well.
Why does my golf cart have oil in the airbox?
Oil in the airbox of your golf cart could be because of a bad needle or float valve in the bowl of your carburetor. The float setting in your carburetor is off and needs to be fixed. Bad needle valves in the carburetor need to be fixed because they cause unburned fuel to contaminate and dilute your cart’s oil.
Why does my golf cart backfire?
Golf Cart Backfires Because Fuel Mixture Is Too Rich. Always check the air and fuel ratio to make sure your engine is not receiving too rich of a fuel mixture. The following adjustments are an example of most carburetors, but you should look up the proper number of screw turns your model requires.
What is the ignition system on a golf cart?
Older golf carts used a set of points and a condenser to produce the spark needed to run the engine, but the more modern carts have a solid-state ignition system . The solid-state system utilizes an internal magnetic pickup device inside the engine that sends an electrical signal down the line to the igniter.
How to adjust a golf cart?
Adjustment is made by loosening the nut or screw, pressing the throttle closed, and then retightening the nut. Some golf carts may not have accelerator cables but instead will have a series of rods between the gas pedal and the carburetor.
What happens when the throttle cable is out of adjustment?
When the throttle cable is out of adjustment, the throttle plate never completely closes, allowing unburned gasoline to accumulate in the exhaust system before the spark plug fires. Here are a few tips for adjusting your golf cart engine to keep it from backfiring.
Why is my throttle plate not closing?
If none of these accelerator cable adjustments solve the problem, then the throttle plate may not be closing all the way due to an obstruction or internal mechanism being bent. Unfortunately, the only way to find out if this is true is to remove the carburetor and inspect it.
How to uncook a muffler?
It sounds crazy, but the common method of un-coking a muffler is to remove it from the cart and barbecue it over a fire for about half an hour. This will burn off all of the debris inside the muffler and turn it to ash.
How to clean a carburetor?
(it might be a good idea to take a picture of it with your cell phone.) Using a can of carburetor cleaner, spray all the ports and jets thoroughly. Use a bristle brush to remove the heavier deposits inside the fuel bowl and outside the carburetor body.