Full Answer
Why does my golf cart Jerk when I stop?
Another common reason for the vehicle being jerky is due to bad clutches. If the clutch is bad, you could experience some jerking movement during the start or stopping stage of the golf cart. Consider getting the clutch checked and possibly replaced if any issues are there.
Why is my golf cart accelerating sluggish?
A faulty or failing solenoid could be the cause of your golf cart’s sluggish acceleration. It handles getting battery power to your starter, the golf cart’s generator, and the traction motor. Solenoids can fail more frequently on an electric cart than a gas powered one. A speed controller controls the golf cart’s speed and acceleration.
Why is my golf cart shaking at high speed?
If your golf cart is shaking at high speed, it may be because of damaged springs in the cart and broken solenoid. To fix this issue, you have to replace the springs if it’s often due to excessive use. You can also use a steering stabilizer to control your speed and manually change the gear.
Why is my golf cart making a grinding noise?
Normally, we find that the cart makes a kind of groaning and grinding noise that can be very irritating. This is usually due to a problem with one of the physical or mechanical parts. The bearings are important in any kind of motor set up. If your bearings are old or have some sort of damage, then the cart might give out the grinding noise.
How do you fix jerky in a golf cart?
One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn't help, getting a new battery or new batteries fitted should work.
Why does my golf cart jump?
Jerking electric golf carts are probably more common than a jerking gas model. That's because most “jerking” concerns are caused by battery issues or a poor flow of electricity from the battery to the cart. Typically, you'll start to notice this problem when your cart needs to charge up.
Why does my golf cart shake when I accelerate?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft. To fix this issue, you should check the CV joints of your golf cart. Check the driveshaft, whether this is in good condition or not. The CV joints should be well greased.
What causes a gas golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
Why does my gas golf cart hesitation?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt.
Why is my gas pedal vibration when I accelerate?
Gas pedal vibration when you accelerate is an indicator of an exhaust leak. Your car's exhaust system has a lot of individual parts that can fail. For example, failing hoses, gaskets, or pipes will cause an exhaust leak.
What can cause a car to jerk when accelerating?
10 Possible Reasons Your Car Jerks While AcceleratingDirty Fuel Injectors. Dirty fuel injectors are among the most common reasons for why an accelerator becomes jerky. ... Blockages. ... Worn Out Spark Plugs. ... Dirty Air Filters. ... Damaged Cylinders. ... Blocked Catalytic Converters. ... Damaged Gas Lines. ... Damaged Acceleration Cables.More items...
Why do my car shake when I press the gas pedal?
You could have a damaged or broken motor mount. Motor mounts are the things that attach the engine to your vehicle's frame. That sounds serious because it is, and damage to one or more of the motor mounts can allow the engine to vibrate and move around when you press the gas pedal.
Why does my golf cart jerk when starting?
There are a sensor and a micro-switch under the driver’s side floor mat. If water enters these components , especially the switch , it could cause the cart to jerk while starting.
Why does my clutch jerk?
Well, the issue could be related to the clutch. The primary clutch weights could be broken, which might be causing the jerks. It would be a good idea to get your clutch checked to help resolve the problem. Another cause of this issue could be the accumulation of dirt or dust particles in the clutch.
Why Do Golf Carts Bounce when Driving?
Have you been experiencing some bounce in your golf cart while driving? Well, in most cases, it could be due to the condition of the roads. However, there may be some issues with your cart which could be causing these bounces, that may require attention.
Why are my front tires bouncy?
If you do not use your cart much and it stays idle for weeks at a time, it could cause the tires to go out of shape due to the weight of the cart.
How to fix a cart that is wobbling at high speed?
Consider replacing the springs with harder ones . This could help solve the issue of the cart wobbling at high speed.
How to get a bouncy cart back to its original shape?
You can try driving the cart for a few miles to warm up the tires. This will cause them to get back to their original shape and help resolve the issue of the bouncy cart.
Why is my cart bouncing?
If the cart is still bouncing, you will know that the problem is not with the tire. Instead, the issue could be due to a bent wheel. In this case, you will just have to get the wheel replaced. If both these cases do not seem to be the cause, then it could be due to the axle or the wheel bearing.
Why does my Club Car golf cart jerk when taking off?
Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk.
Why does my cart jerk?
Low battery charge. Check the overall battery pack charge and also the charge of each battery separately. Sometimes, low charge batteries can cause the cart to jerk. Charging the pack or the concerned battery/batteries to full voltage is likely to help.
Why does my Club Car DS shake when accelerating?
Your Club Car DS may shake when accelerating because of an overly tight drive belt or a clutch issue. Sometimes, this problem happens when the carburetor fails to mix the fuel properly.
How to fix club car precedent?
You can fix a Club Car Precedent that jerks when taking off by checking and fixing the MCOR and batteries. These are the two key parts that often cause the jerking action.
Why does my club car jerk in reverse?
Your Club Car golf cart jerks in forward and reverse due to a sticky drive clutch or a high gear solenoid problem. A missing cable between the resistor and the forward/reverse selector can also cause the jerking in both directions.
How to fix jerk on 1985 club car?
If you have a 1985 Club Car, the jerk can be curbed by doing a high gear solenoid replacement. The solenoid will be in ON position when the cart moves both in forward and reverse directions. This solenoid is present on the passenger side of the golf cart.
How to fix a club car DS that jerks when taking off?
You can fix a Club Car DS that jerks when taking off by correcting the oil level. The following steps help to solve the jerking in 1988 lifted Club Car DS. Check the oil level of the golf cart and do a refill if needed. There is no need to overfill the oil. It’s enough if you fill it to just the required level.
Why does my golf cart jerk?
The golf cart may cause a jerk because of the solenoid issues. You need to check the voltage reading (normal range or not) of the solenoid. If the range is more or less than the normal range, then replace this.
What causes a golf cart to jerk?
A golf cart begins to jerk while starting due to the wrong alignment of ITS and when an excessive amount of water enters inside the components.
Why does my golf cart shake on takeoff?
If your golf cart shakes while taking off, it may be due to faulty batteries, adaptors, or resistors.
Why does my golf cart vibrate when accelerating?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft.
Why is my golf cart shaking at high speed?
If your golf cart is shaking at high speed, it may be because of damaged springs in the cart and broken solenoid.
Why ezgo golf cart shudders?
The EZGI golf cart shudders issues arise due to bad battery cable connections or a damaged spinning wheel.
How to fix EZGO RXV shaking?
The golf cart Ezgo RXV shaking issues that occur in your golf cart may be due to worn steering parts, loose lug nuts, and loose wheel bearings. This may be due to brake drums and tires.
Why does my golf cart beep?
In some cases, beeping sounds are heard when you are trying to reverse the golf cart. This is one of the most common problems faced by cart owners. This beeping sound may also be heard during a normal drive but most people have reported hearing it when the vehicle is being reversed.
Why does my golf cart make a whining noise?
If you can hear a whining noise coming from your golf cart, then it could be because of damaged motor bearings, or the fluid oil needs to be replaced .
What could have gone haywire in my F&P switch?
The buzzer wires could have gone haywire or may have gone into the F&P switch. This may need to be replaced for the issue to be solved.
Why does my controller beep?
If all these efforts fail, you could try checking the batteries or the motor. If either of these has shorted out or has had a malfunction , then the beep sound may be heard. Checking the battery pack and the controller can give you a good idea of whether the issue originates from them or not.
Why are my brakes tight?
Excess tension in the brake cables could also cause overloading of the brakes. Verify that the brake cables are not overloaded and are free to work efficiently. Sometimes the brake pedals become tight and do not function normally during a run.
Where is the spacer on a car?
There is a spacer attached to the vehicle under the rear tire on the driver’s side. This can be found between the transaxle and the tire. If the spacer is loose, it could cause some grinding noise from the rear end. Check whether the axle is spinnable by hand and if so, it is indeed loose.
Can a golf cart make a noise?
Golf carts can sometimes make some very weird noises. While these noises may not be particularly dangerous, they can be irritating and possible a sign of damage. If you want your golf cart to last you for many years to come, you’ll want to investigate and fix such noises. I have created this handy guide to help you troubleshoot any golf cart noises ...
Safety Notice
Before attempting any maintenance or repairs on your golf car it is imperative that you consult the owner’s manual and follow all the safety guidelines. The following are a few safety tips, but may not be all inclusive.
Check Battery Terminal connections
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Check Battery Voltage
Once you’ve cleared all the battery terminals of corrosion, you’ll next need to check that your batteries are providing the correct amount of voltage. This can be accomplished using a simple voltmeter.
Check Resistor Coil (For Older 36V Golf Carts)
If you have an older 36V golf car that doesn’t use a speed controller, and you’ve completed all the steps above and your golf car is still jerking in set to forward, but works fine when the direction is changed to reverse you may have a bad resister coil.
Why does my golf cart make clicking sounds?
On a gas golf cart, the most common symptom is the starter failing to engage – so the engine doesn’t turn over – while all you hear a series of very futile clicking sounds.
What does it mean when a golf cart solenoid goes bad?
Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor ...
What are the symptoms of a bad solenoid on a golf cart?
In addition, the spring that pulls the pinion back to its resting position could wear down leaving the starter engaged continuously. (Starters are supposed to get the flywheel moving, then back out of position – disengage.)
Why does my solenoid wear out?
Like any switch that relies on wiring, the solenoid could also just wear out due to overheating. This might cause it to fail to retrieve the pinion gear.
What does a solenoid do when you turn the ignition?
Step by step, it looks like this: When you turn the ignition key, a small amount of electricity goes to the solenoid. The solenoid uses that small amount of juice to close two heavy-duty contacts that allows a large jolt of electricity to pass through the starter. The solenoid also sends a pinion gear forward, which is the device ...
Why do starter contacts wear out?
Secondly, the contacts could begin to wear out from overheating or exposure to high levels of current. This needs to be fixed right away if possible, because this causes continuous use of the starter. If not caught in time, the solenoid and the starter will both need replacement.
Why won't my solenoid click?
The solenoid might not be getting enough electricity to do its work – which could be caused by loose connections, a weak battery or the coil wearing out.