Another possibility (though less likely) reason for your golf cart backfiring can be a buildup of carbon on the piston, also known as coke. This material glows red hot after the engine runs for a while and ignites the fuel without the spark plug being turned on.
Why does my golf cart battery run out so fast?
As previously stated, overusing your golf cart will cause overheating which leads to low water levels in your battery. Avoid going pedal to the metal with your golf cart and stay away from steep hills that will put added stress on your vehicle. If you do need to traverse a steep incline, do it slowly. 6. Cold Weather is a Battery Killer
What should I do if my golf cart does not start?
On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge. If there is no click when the pedal is pushed, then there is no solenoid activity.
Why does my golf cart keep shutting off?
There may be various reasons of the Club Car Precedent to keep shutting off, let us discuss on few of the common ones: Check voltage of the batteries: Use a voltmeter to check if both batteries are showing the minimum voltage requirements to keep the golf cart in running condition.
Do your golf carts die after driving for some time?
One of the most common complaints with golf carts is that it dies after driving for some time. Have you ever experienced this? You may have tried to make it run by getting the choke on.
Why does my golf cart keep shutting off?
Why Does My Golf Cart Keep Shutting Off? When a Golf Car is shutting off without warning, it's because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly.
Why does my gas golf cart stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. What is this? The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
Why does my ezgo gas golf cart lose power?
The main reason why a EZGO golf cart can lose power is because the battery is not charging due to loose cables or the corrosion of the connecting terminals. If they become loose or some of the electrical circuits' connecting wires snap, the battery loses power.
How do you reset a gas golf cart?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you check the voltage regulator on a gas club cart?
Testing the voltage regulator on a gas Club CarConnect the voltmeter to the battery and get the golf cart running. ... Check if the voltage rating is between 14 volts and 16 volts. ... Use a jumper and connect it from the ground of the cart to the stud of the starter generator.
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do you troubleshoot an EZGO gas golf cart?
0:001:28Ezgo golf cart troubleshooting tips - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnother thing you want to check is your gas make sure the gas is full. Make sure you have fresh gas.MoreAnother thing you want to check is your gas make sure the gas is full. Make sure you have fresh gas. And then check your filter. Make sure it's you see gas in it. Now you could check your pump.
Can a golf cart solenoid overheat?
Your solenoid is prone to overheating as a result of its regular use. As a result, you may notice irregular operation after a while — it may work one time, but not the next. Loose cables or dusty interiors could cause your cart's inability to start.
What does a pulser coil do on a golf cart?
What does a pulser coil do on a golf cart? In order to start any golf cart, there is a requirement for a sudden spark that will ignite the engine. The purpose of the Pulser coil is to give ignition signals to the engine and ignition system.
How do you adjust the governor on a gas golf cart?
0:545:06How to Adjust an E Z Go Golf Cart Governor - WikiVideo - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you are curious this is your carts carburetor loosen the small nut and tighten the larger nut.MoreIf you are curious this is your carts carburetor loosen the small nut and tighten the larger nut. The more you tighten the larger nut the faster your cart will.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you adjust the carburetor on a Club Car golf cart?
Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.
Why Does My Golf Cart Keep Shutting Off?
When a Golf Car is shutting off without warning, it’s because of low battery voltage, dead batteries, or because the solenoid coil is overheating.
What happens if the voltage goes down on a golf cart?
Again, when the voltages go down, it will hit minimum and all the power that is gained shall be lost.
Why does my golf cart cut out at full throttle?
A golf cart may cut out at full throttle due to a faulty solenoid that needs replacing, or having too low of a battery voltage.
How to Fix a EZGO golf cart that keeps shutting off?
EZGO Golf Carts may sometimes turn off while being operational. The ways to fix a EZGO are stated below:
Why does my Yamaha G2 keep shutting off?
Yamaha G2 golf cart keeps shutting off: The Yamaha G2 Golf Cart may keep shutting off due to one of the following reasons: Loose solenoid wiring: The first check should be done whether the wiring on the golf cart is in right condition.
Why does my golf cart stutter?
Coil of solenoid: The coil attached to the solenoid of the Golf Cart may get too hot and bypass the functioning of the solenoid. That may cause a glitch which may end up in the Golf cart causing stutters while being used.
How to keep engine in neutral?
Keep the engine in neutral: Change the engine output to “Neutral” and try applying less degree of throttle inputs. It has to be made sure that the throttle gets closed when the gas is let off.
How Do You Troubleshoot a Gasoline Golf Cart?
Check the fuel level, regardless of what the gauge says. I have seen a stuck fuel tank float baffle a mechanic for three hours while looking for a reason for a “full” tank not delivering the fuel.
Why won't my golf cart start?
Your golf cart won’t start if there is a problem with the fuel, airflow, or electrical system. Any one of these areas can cause your golf cart to fail to start. Try these steps to troubleshoot and pinpoint the exact failure point.
How Do You Know When Golf Cart Batteries Are Going Bad?
As batteries start to lose their health and take longer to accelerate, you find that you can’t hit the top speed anymore or have problems climbing hills.
Why Does The Golf Cart Battery Drain When Everything Is Off?
Disconnect the negative battery cable ground wire and connect your multimeter set to measure the voltage between the battery terminal and the ground wire. If you’ve turned everything off and are still getting a reading, then you have a faulty component in the electrical system. At this point, we’ll need to start pulling fuses and disconnecting things one of the time to find out what is draining the battery.
How Do I Know If My Golf Cart Solenoid Is Bad?
Older golf carts used a series of solenoids to drive the cart forward and backward and set the speed of that motion.
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
Golf Cart
Support for gas-powered and electric golf carts, sometimes referred to as golf cars or club cars after the Club Car Golf Cart brand.
3 Answers
The information in this link may be of some help in finding your problem. I realize that you have replaced the fuel pump but this link describes other factors which may be relevant
Why is it harder to start a gas engine?
Temperature. When a gas powered engine is cold it is harder to start. Once they warm up to the regular engine temperature they run like they are suppose to. So the answer is temperature.
How much power does a golf cart have?
Golf Carts and other small EVs use a motor with a power of around 5–10kW (maximum). How can that power be controlled?
What causes a battery to drain?
Draining your battery can be caused by several things, If your battery is actually draining you have something on or a parasitic load on the battery. Second if your battery is aged you could have a short in the battery or a cell going bad. That battery is a 12 volt battery and fully charged should read 12.7 volts. Take the battery out or at the minimum disconnect the ground wire and charge the battery. After it is fully charged (I like to at least charge the battery on low for several hours) and then let it rest with the charger off and take a voltage reading. It should be above 12.4 volts up
Why won't my engine start if the valve clearances are off?
Engine intake and exhaust valves out of adjustment: this will affect your engine’s compression release, making it VERY hard for the starter to spin the engine. All of the jump starting and new batteries won’t start the engine if the valve clearances are way off!
Is it safe to drive a golf cart?
The high torque is what give you the immediate acceleration from the golf cart but you can forget about high speed driving on the cart as the horsepower is limited by the rpm of the motor powered by the size/voltage/amperage of the battery. That is why it is a safe transport medium on golf courses.
Do electric engines need a carburetor?
Electric engines are not like combustion engines. You do not need a bigger engine, or carburetor. You just need more juice. Serial wire a couple more batteries together to add more voltage. But be careful that the wiring can handle the amount of electricity or you could burn them out and catch on fire. So check how to wire the batteries together to increase your voltage and hook it up.
Who owns the majority of golf carts?
About more than 90% of golf carts on golf courses, both private and commercial, are owned by a foundation called “Stichting Handicart”.
Why is my starter not turning?
Is the motor turning? Only one fuse and the starter will not turn if it is bad. If the motor is not turning, make sure the belt is not slipping. If it is not slipping, make sure the engine will turn by hand. MAKE SURE KEY IS OFF BEFORE YOU PUT YOUR HANDS IN. If it seems free, you either have a weak battery or the brushes in the starter have worn out. I change at least 20 sets of brushes a year on Club Cars.
Is a golf cart considered an electric car?
There is a custom Golf Cart that looks like a Jeep and is considered an electric club car. If you get a chance there is a show called Barter Kings and one of the shows actually shows one. They are not cheap.
What generator will fire up second and die?
Honda eu1000i generator will fire up second and die.
Does a 96 club car run?
I have a 96 gas club car. It runs fine until it gets warmed
Why does my golf cart battery keep going dead?
The reason why your golf cart battery keeps going dead may be due to loose connections, incorrect battery wiring, or having a faulty voltage regulator. The voltage regulator is at fault and tends to affect the starter solenoid.
How to check if a golf cart battery is dead?
There are four methods of checking whether your golf cart battery is dead. Use a multimeter to check the voltage of each battery in your golf cart. Use a hydrometer to check the gravity of the electrolytes in the batteries. Use the Load Testing method.
Why does my golf cart battery drain so quickly?
The reason why your golf cart battery keeps losing charge or drains quickly, may be due to loose wires, corroded connectors or an insufficient amount of water in the battery. The battery connections may have become loose or the connectors are corroded.
How many amp hours does a golf cart battery last?
A bigger voltage drop is a sure sign of a failing or faulty battery. A golf cart battery comes with a specific amp hour rating at 20 hours. This is usually mentioned in the battery information sticker.
How to check the specific gravity of a golf cart battery?
Using a Hydrometer. You can use a hydrometer with a thermometer to check the specific gravity of the electrolyte in the golf cart batteries. If this value lies between 1.1 and 1.2, you must consider recharging the battery. Alternatively, if the value is between 1.225 and 1.265, you can continue testing your battery.
Why are my batteries getting overcharged?
The batteries are getting overcharged because the charger is continuously on. Consider using an automatic charger that turns off the charging once the desired charge has been achieved. Similarly, you should not wait to charge them until they have become very low.
How far can a golf cart go?
You have taken the golf cart for several long trips. With a fully charged good battery, you should be able to travel seven miles.