Why Golf Cart Batteries Lose Charge / Drain Quickly
- The battery connections may have become loose or the connectors are corroded. ...
- The water level in the golf cart batteries is far below the desired level. ...
- The golf cart is kept in a very cold area. ...
- The battery charger is at fault and not charging the batteries properly. ...
- The batteries are getting overcharged because the charger is continuously on. ...
Why is my golf cart not charging?
- It would be advised to have a multi-meter to check your battery pack voltage and the individual battery voltages.
- You will have the possibility of 3 different voltage batteries: 6-volt, 8-volt, or 12-volt.
- You’ll plug your golf cart charger into the wall and the cart and leave it in there.
How long does it take to charge a golf cart?
So, How long it takes to fully charge a golf cart depends on the battery. Charging your golf cart for 8 to 14 hours is a good rule of thumb, but it can be as short as 4 to 6 hours or as long as 20 to 24 hours.
Why are golf cart Chargers not waterproof?
- Check for a clicking sound by the relay in the charger when it’s plugged to the golf cart. ...
- Inspect the charger to see if it clicks occasionally and flashes the red light twice. ...
- The charger may not kick on because the batteries do not have any voltage. ...
How far will golf cart go on full charge?
Originally Answered: How far will a golf cart go on a full charge? By comparison a gas golf cart tank usually has a 6 gallon capacity and this will enable you to travel approximately 250 miles. An electric cart will go between 25 and 40 miles depending on your battery configuration.
Why is my golf cart battery draining so fast?
The reason why your golf cart battery keeps losing charge or drains quickly, may be due to loose wires, corroded connectors or an insufficient amount of water in the battery. The battery connections may have become loose or the connectors are corroded.
How long should golf cart batteries hold a charge?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge....Our Hours.Mon:CLOSEDSun:CLOSED5 more rows
Why does my cart battery keep dying?
There are several reason why your e-cig battery might be dying so quickly. Over charging, over discharging, incorrect storage, low resistance atomizer coils and wattage being set too high can all contribute to an e-cig battery not lasting as long as you might expect.
Why is my electric golf cart losing power?
If the coach goes without charge for a long time, the battery may lack the minimum voltage required to restart. Batteries also lose their efficiency with age. Golf Carts will run for approximately five years before the battery needs to be replaced or the charger will need replacement.
How can you tell if golf cart batteries are bad?
8 Signs You Need to Replace Your Golf Cart BatteriesCharge Times Are Out of Hand. Just like any rechargeable battery, the repeated cycles of draining and charging your battery can take a toll on it. ... No “Get Up and Go” ... You See Visual Signs. ... Driving Until They Die. ... People Are Always Running The Radio.
Should you leave your golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How do you fix a battery that doesn't hold a charge?
Answer provided by. If jumpstarting your car battery doesn't fix your problem, your battery might be dead. But if it's not, you may be able to repair a car battery that won't hold a charge by performing a few tests, cleaning the cells, and reconditioning the battery.
What would drain a golf cart battery?
Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly.
How do I find out what's draining my car battery?
4:3714:56How to Test and Find a Parasitic Battery Drain (Key Off) - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd remove the negative battery cable. And. Put one lead in that cable. Take the other lead andMoreAnd remove the negative battery cable. And. Put one lead in that cable. Take the other lead and touch it to the negative battery terminal.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Where is the reset button on a golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
Where is the reset button on a Club Car golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
How to check if golf cart battery charger is faulty?
The charger may be faulty. Check this by plugging the charger into the golf cart and see how much it charges the battery pack using a digital voltmeter. Alternatively, you can use another charger to do the charging and see if there is a difference. Allow the charger to charge the pack fully and shut down on its own.
Why won't my Ezgo golf cart charge?
Some reasons why an EZGO RXV golf cart will not charge could be because of a dirty charging port, loose or broken wire, a blown-out fuse or a problem with the auxiliary contact. Clean the charging port so that it’s free of dust and dirt accumulation. Sometimes, dust and dirt can prevent proper charging.
How many volts does an EZGO 2012 hold?
Check the battery pack voltage using a multimeter. For a 48-volt cart, this should be between 46 to 50 volts based on the charge level.
How many volts should a golf cart battery pack have?
Charge two batteries at a time with a 12-volt charger and then use the auto golf cart charger to resume the charging. The battery pack must have at least 28 volts for the cart charger to be able to kick in. Also, ensure that the battery plates have at least 1/4 inch of distilled water above them before charging.
Why is my Ezgo cart not charging?
It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries. A charger problem can also be associated with the charger making a loud clicking noise, failing to stop charging after the batteries have attained full charge ...
How to check if a voltage regulator is faulty?
To check if the regulator is defective, remove the green wire connecting the generator and the stator at the generator end. Get the engine running, ground the disconnected end and check the voltage rating using a voltmeter.
How long should I charge a 12 volt battery?
You can consider charging them two at a time if you have a 12-volt charger for around 20 minutes. The batteries should never be allowed to discharge below 20%.
Step 2. Unplug your golf cart charger from your golf cart
If your charger is currently plugged in to your golf cart. Unplug the charger from the golf cart.
Step 3. Check AC power from wall outlet
Starting the troubleshooting process begins with checking the simplest to correct stages of the charging process first. In this case, we’ll begin by checking the AC power from your wall outlet to the golf cart charger.
Step 4. Check the reset switch on charger (if applicable)
After you’ve confirmed that your wall outlet is energized and providing proper power, quickly check if your golf car charger has a reset switch.
Step 5. Confirm charger is properly plugged into golf cart
After unplugging your charger from the golf cart and making sure your outlet is providing power, wait at least 20 seconds before plugging the charger back into the golf car. This is particularly important for Club Car vehicles equipped with an on-board computer (OBC).
Step 6. Check Battery pack voltage
The most common reason a golf cart isn’t charging has to do with an issue with the battery pack, battery cables, or a single battery. Well run through how to check for each issue.
Step 7. Test the charging receptacle
If your golf car battery pack is within the ranges above, but your golf car is still not charging with the golf cart charger, you may have an issue with your charging receptacle on the golf car.
Step 8. Test On-board Computer (Club Car only)
At this point, there are only a couple of components left that could be preventing your golf cart from charging. On Club Cars only, one component is the on-board computer, or OBC. This component is involved in the charging system on your 48V Club Car on troubleshooting this component will be discussed in a separate article.
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
How to keep a charger from getting hot?
But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight.
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How many volts does a battery charger need to charge?
When your charger can’t tell that your batteries are hooked up, it often won’t even turn on. A base charge of 25-30 volts is usually sufficient to wake up your charger and begin charging. To get around this problem, specific chargers offer modes that keep your batteries charged even when you’re not using them.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
What to do if battery is stuck at no charge?
However, if you’re stuck at no charge, a small, manual charger should provide each battery with enough juice to activate your regular charger.
Why won't my club car golf cart turn off?
A Club Car golf cart will not shut off if the OBC is outdated or faulty. In this case, the reason depends on whether the charger is not shutting off when it is plugged into the device , or it is not plugged in but still not shutting off.
Why is my club car not charging?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
Why is my charger clicking?
If the charger is clicking while plugging it in, and doing nothing, examine your charger and probably replace it . If the “brain” of the charger fails , then it can cause several issues, and the batteries will not charge. Purchasing a new one or repairing the component can solve the problem.
What is the OBC on a 48V club car?
In the 48V club cars, the OBC is primarily responsible for the batteries’ charge. It controls the batteries charging, which is why the 48V requires a fully functional OBC all the time. Connect the batteries to a voltmeter and check if the charger is generating enough power.
What happens if your golf cart battery is low?
If the water level of the batteries is low, then the blade inside it will be dried, and you won’t be able to recharge your battery. Charging problems of golf carts are not something new. It can be quickly resolved. All you need to do is to examine the cart thoroughly and immediately replace the faulty parts.
How to keep car batteries charged when idle?
Try to keep specific chargers, which will help your batteries to stay charged even when the car is idle. Enough power supply is critical to keep the charger working and keep the batteries charging. Check your connections, and then turn on your charger.
What does it mean when a charger is bad?
Bad charger: if the charger turns on but there is no sign of charging. If the charger is making noises like a loud click, before kicking off. If the charger keeps charging even after turning the switch off then, without any doubt, it’s time to replace the charger.
Can you turn off the radio on a golf cart?
Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.
Can you use an automatic battery charger when it is fully charged?
It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.
Can you drive a golf cart up steep hills?
Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.
Should golf cart batteries be charged?
Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.
