why does my golf cart stop and go

by Willard Bartoletti Published 3 years ago Updated 3 years ago

In some cases, this happens because the coil of the battery is worn out or is too old. It can also be a sign of a faulty battery or even loose connections within the solenoid. Additionally, you could be dealing with overheated contacts. This is an issue you need to take seriously.Oct 29, 2018

How do I know if my golf cart solenoid is bad?

If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.

Why is my electric golf cart sputtering?

The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.

Why does my electric golf cart stop?

The problem may be as simple as loose wires, or you may be looking at a broken coil or corrosion. If solenoids are the issue, you'll want to bring your golf cart in for repairs.Aug 17, 2017

What causes a gas golf cart to sputter?

Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. Next, your spitting and sputtering woes might be because of worn out spark plugs.Mar 10, 2019

How do you diagnose a golf cart problem?

There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.

Test the wall socket where you charge your cart. ...
Expose your golf cart batteries. ...
Test the batteries for voltage. ...
Replace dead batteries. ...
Expose the motor for inspection. ...
Reset the motor. ...
Test the cart.

How do I know if my electric golf cart motor is bad?

You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.May 14, 2021

How do you reset an electric golf cart?

Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button. Push the button to reset the motor.Jan 20, 2011

What do you do if your golf cart won't go?

If you've charged and cleaned your battery and you're still having electric golf cart problems, your next step is to check the motor. Believe it or not, it may be as simple as pressing a reset button. Use a screwdriver to expose the motor. Look for a small red button located near the main power supply.

Where is the reset button on an electric golf cart motor?

First, you'll want to reset your motor.

It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!Feb 12, 2018

How do I know if my golf cart fuel pump is bad?

Even if you can't see deterioration, a telltale gasoline smell will let you know that they may have begun to fall apart. Remember: a pin hole or other small area of damage may not be visible, so make sure to check for the fuel smell. Engine problems. Fuel issues aren't always caused by the fuel pump.Sep 28, 2016

How do you adjust the carburetor on a gas golf cart?

Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.

How do I stop my gas golf cart from smoking?

Start out by carefully removing the valve's screws and taking them out of the engine. Remove the valve with gloved hands to avoid getting stained by excessive grease or oil. Clean off the area where you are installing the valve and put the new valve in place. Tighten it down and your engine should stop smoking.

Why your EZGO golf cart stops suddenly?

The main reason why a EZGO golf cart stops suddenly is because of a bad solenoid or low voltage levels causing a thermal cut.

How to Fix EZGO RXV that stops suddenly?

The RXV from EZGO is one of the most popular golf carts doing the rounds. Unfortunately, many users have complained that they have situations in which the EZGO RXV suddenly stops to a standstill.

Why your EZGO TXT has stopped running?

The main reasons why a EZGO TXT keeps stopping can be due to burnt wires, or low battery voltage.

Why Electric EZGO stops suddenly?

An electric EZGO golf cart that stops suddenly can be due to leaking batteries or loose wiring from the F/R switch.

Why EZGO PDS stops suddenly?

The PDS from EZGO from the year 2008 stops suddenly due to one or more of the following reasons:

Why my EZGO golf cart stops and goes?

EZGO golf carts starting from the year 2006 to latest models have seen the trends of the golf carts getting to sudden halts and not being mobile for long.

Why EZGO golf cart stops on hills?

A EZGO golf cart may stop on hills due to a bad solenoid or using a very old battery.

What happens when the voltage goes down?

Again, when the voltages go down, it will hit minimum and all the power that is gained shall be lost. Be easy on the throttle to keep the voltage at minimum level. Dead Batteries: post completion of charging if the batteries do not hit the minimum level of voltages, chances are that one or both batteries are dead.

Is the 2002 EZGO shutting off?

The 2002 model of the EZGO has been reported to be getting shut off and the same feedback has come from a lot of customers across the USA. But don’t worry, as following a few easy steps is all that’s needed.

What causes a golf cart to stall?

The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller.

How to fix a golf cart stalling on a hill

The first thing you need to check is the brake hub. It might be spinning out. The brake bub will spin out when there is too much load to prevent any damage to the rear axles, causing the golf cart to stall on hills.

Why do golf carts stall when accelerated?

If a golf cart runs in reverse, but stalls when running forward and accelerating, this indicates a faulty f/r switch.

Why EZGO Gas golf cart hesitates when accelerating

The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor.

EZGO RXV stalling problems

Too much load on the EZGO RXV can cause a stalling problem, especially when going uphill. The voltage can drop because of the heavy load, and that’s why the cart starts to stall.

Club Car DS hesitates when accelerating

The most common problems that cause hesitation in the club car DS are:

Club car precedent hesitates when accelerating

Start with the basics and check these to find out why your club car is hesitating when accelerated:

What are the problems with electric golf carts?

These carts can start to show signs of wear and may fail just like any other vehicle over time. Learn about some of the more common issues associated with electric golf carts. 1. Solenoid Wear. The solenoid is the primary electrical switch in your golf cart and is designed to ensure the current from the battery flows into the motor. ...

What is the solenoid on a golf cart?

The solenoid is the primary electrical switch in your golf cart and is designed to ensure the current from the battery flows into the motor. When you press down on the gas pedal and hear a tapping-like sound, this is the sound of the solenoid activating. When there is a disruption in the flow of the electrical current, your cart will not operate.

Is an electric golf cart durable?

Electric golf carts are convenient, efficient, and especially durable, but understand that long-lasting does not mean invincible. These carts can start to show signs of wear and may fail just like any other vehicle over time. Learn about some of the more common issues associated with electric golf carts.

What is a direction switch?

The direction switches, sometimes referred to as the forward and reverse switches, may also wear and fail over time. As the name suggests, the direction switches manage the cart's ability to move backward and forwards and operate similarly to a transmission.

Why does my golf cart backfire?

Golf Cart Backfires Because Fuel Mixture Is Too Rich. Always check the air and fuel ratio to make sure your engine is not receiving too rich of a fuel mixture. The following adjustments are an example of most carburetors, but you should look up the proper number of screw turns your model requires.

Why is my throttle plate not closing?

If none of these accelerator cable adjustments solve the problem, then the throttle plate may not be closing all the way due to an obstruction or internal mechanism being bent. Unfortunately, the only way to find out if this is true is to remove the carburetor and inspect it.

What is a golf cart?

Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... Continue Reading.

How long does it take for a muffler to burn off?

It sounds crazy, but the common method of un-coking a muffler is to remove it from the cart and barbecue it over a fire for about half an hour. This will burn off all of the debris inside the muffler and turn it to ash.

Where is the microswitch located?

The microswitch is usually located at the pedal or just inside the engine compartment. The throttle plate should not have moved before the click was heard, but if it did, then you need to adjust the throttle cable.

Club Car Precedent 48v Intermittent Problem Question

I have a 2012 Club Car Precedent 48v electric cart that will suddenly stop working. It has brand new batteries, and seems fine, but randomly will not move when pushing the pedal. It will lurch forward then stop again, or it may work normal after changing the f/r switch, key switch, or even the run/tow switch.

Answer

It sounds like you are dealing with what we classify an intermittent problem. So, first things first, we need to reproduce the problem. Most likely, you are dealing with a connectivity issue. Essentially, what you are describing is a power outage to the system. The clicking noise you are hearing is the solenoid disengaging due to lack of power.