Your golf cart engine is most likely sputtering is a fuel issue: your engine is likely getting too little or too much. Check your air box to make sure the choke isn’t getting stuck and the spring isn’t broken or getting sucked closed.
Why is my golf cart engine sputtering?
Your golf cart engine is most likely sputtering is a fuel issue: your engine is likely getting too little or too much. Check your air box to make sure the choke isn’t getting stuck and the spring isn’t broken or getting sucked closed.
Why does my golf cart run only when the choke is on?
The cart runs only if the choke is kept on throughout the runtime due to sediment accumulation in the carburetor. The cart shows signs of poor gas economy because the choke opens only partly.
Why is my golf cart blowing smoke?
This oil then goes into the vent tube back into the carburetor and blows oil into the intake of the carburetor causing your cart to blow smoke. Fill your engine with the correct amount of oil. If your carts muffler has oil in it, it will blow out smoke. If you’ve got this problem, run your cart hard on a long run to the oil out of the muffler.
Why does my golf cart show poor performance at low speed?
The cart shows poor performance when running at low speed because the choke is on or pulled out. The spark plugs of the cart get damaged due to choke seizure when the choke is closed. • Push choke inwards. Wait for at least 15 minutes so that fuel is drained and start the engine again.
Why does my golf cart only run with choke on?
Dwight Coleman there are usually only a few possibilities if it only runs with the choke. One cause could be an air leak on the carb, head gasket, crankshaft seal. The other could be a clogged low speed and idle circuit.
Why does my golf cart backfire when I let off the gas?
The golf cart backfires when you let off gas is because the carburetor butterfly isn't getting closed completely. Air suction from the exhaust gasket is another possible cause. Checking the carburetor and adjusting the return spring to its original position so that the carburetor is closed solves the problem.
Why does my gas golf cart hesitation?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt.
How do you stop a golf cart backfiring?
One of the simplest ways to reduce backfiring while operating a golf cart is to adjust the throttle plate so the controller does not apply fuel when the motor is idle. This makes it more difficult for residual pressure to build inside of the manifold and cause backfiring.
Why is my golf cart sputtering?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
How do you adjust the carburetor on a Yamaha golf cart?
How to Adjust Yamaha Golf Cart CarburetorPull out the pilot adjustment screw. ... Rethread the screw back until it's slightly seated.Turn the screw outwards by 1-1/2 turns.Push the throttle stop screw backward until the throttle shaft is closed completely.Turn the screw in by a 1/4 turn.
Why does my engine bog down when I give it gas?
An engine that hesitates when accelerating is either sucking too much air, not getting enough fuel, or misfiring.
What causes hesitation upon acceleration?
An engine that is hesitating to accelerate is most likely dealing with a fuel/air mixture that is too lean. Engine's that are running inefficiently will begin to show signs like hesitation which will only become worse over time.
How do you fix hesitation when accelerating?
0:169:09How To Fix Engine Hesitation During Acceleration - Easy Fix! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you do not have a diagnostic scanner. Then take the vehicle to an auto parts store which willMoreIf you do not have a diagnostic scanner. Then take the vehicle to an auto parts store which will normally perform this service for free engine hesitation is due to something that's become faulty.
How do you adjust the governor on a Yamaha golf cart?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipItself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.
What causes a gas golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
How do you adjust the throttle on a golf cart?
Pull the spring that is present around the plastic piece located behind the shifter. Spin it until it falls back. Loosen the throttle cable present in the cable box to adjust the extent to which you can take it out of the housing. Press the accelerator so that the golf cart starts up and begins to idle.
Why do golf carts get fouled up?
The spark plugs and valves of the cart may get fouled up due to the richness of the engine. They will have to be removed and cleaned using a brake or carburetor cleaner followed by their reinstallation. The speed of the golf cart tends to reduce considerably if it has been driven with the choke on for a long time.
When to use a golf cart choke?
A golf cart choke is often used when a cold engine is started. It controls the airflow when fuel is moved to the engine. The choke is released when the mixture is stabilized and the engine can operate by itself without any restriction of air.
Why does my car have air leaks?
There may be air leaks because of cracks in the adapter plate housing the carburetor, carburetor, spacer, gaskets or air hose from the fuel pump to the engine. A missing plug in the bottom of the air box also causes the problem.
Why does my gas cart show poor gas economy?
The cart shows signs of poor gas economy because the choke opens only partly. The engine of the cart tends to lose power or run rough due to incorrect choke adjustment. The cart shows poor performance when running at low speed because the choke is on or pulled out. The spark plugs of the cart get damaged due to choke seizure when ...
How to fix a carburetor?
To fix it, Check the cable of the carburetor to see if it’s in good condition. Press the accelerator and check if the engine begins turning over before the carburetor gets opened up by the cable. If this is not happening, the accelerator cable that is present inside the electrical component box must be adjusted.
What is a dirty check valve?
Dirty or damaged valve in fuel tank. The fuel tank has a dirty or damaged check valve. Alternatively, the check valves under the Welch plug is at fault. Inspect the fuel tank for a dirty or faulty check valve. Also, check the one under the Welch plug.
Why does my carburetor heat up?
The carburetor needs cleaning or is missing a component. Check for dirt accumulation in the carburetor and clean it up immediately. The dirt build-up can cause the carburetor to heat up. Inspect the carburetor closely to see if all components are present. The absence of parts like fuel filters can trigger this problem.
Reasons Why You Have to Choke Your Golf Cart to Get it to Start
The choke is used to inject fuel into the engine so that it can start. There are a few reasons why you have to choke your golf cart in order for it to start. Some of the most common are:
7 Common Fixes for having to Choke your Golf Cart all the Time
There are a few problems that you may experience with golf cart chokes. Being able to diagnose these problems and fix them will have your golf cart working better and result in you having to choke your golf cart less. Here are some common problems you may be experiencing with choking your golf cart:
Why Do You Need to Choke a Golf Cart all the time?
Your golf cart will not start on its own because no fuel flows into the engine until it’s running, so you need to choke your golf cart before it will start. A new engine should fire right up when flooded with gas. If you live in an extremely cold climate, the choke is critical for getting your golf cart to start.
How Many Times Should I Have to Choke My Golf Cart Before It Starts?
It depends on outside conditions and how much fuel is in the carburetor already. If your thermometer reads below freezing, choking will help get your golf cart’s engine going. If it isn’t that cold, but still cool, you should be able to start up normally as long as there’s enough gas in the carburetor.
When Should I Choke My Golf Cart?
Whenever necessary outside conditions call for it. If it’s cold or you haven’t started it in a while and your golf cart won’t start right away, you might need to choke it. Choking gets more important when temperatures are low since colder air contains less oxygen which makes starting engines more difficult.
Hans Pearson
With the engine running at about half power/speed, put a volt meter across the battery terminals. The meter should read somewhere around 14.5 volts. If it is below 13 volts it is definitely not charging. Consider that the battery, unless new, could also be failing.
Marvin
You may have this posted in the wrong product category.
I need to buy all three wheels for my tourtrek push cart. My car was stolen and I had detached the wheels to store the cart
You question is very vague as to what type of push cart your needing wheels for.
What could be causing my golf cart to lose power? In the morning, it barely goes up the hills. It seems to run normally at night, but when I hit the gas pedal the lights go completely out
Have the battery checked. Especially make sure they do a shunt regulator test on the cells. Sounds light a shorted cell in the battery.
Should the solenoid have increasing voltage across the main terminals, 9.0vdc to 30vdc. Master switch in tow, key switch off
My answer is I don't know regarding golf carts but generally a designer would arrange for a solenoid to be actuated by as constant a voltage as possible, especially if it is to be engaged for long periods. That is the only method to ensure consistent operation without danger of overheating.
YAMAHA OLF CART GASOLINE OPERATED CHARGED BATTERY WHENi TURN KEY ON AND TRY TO GO IT WONT MOVE AND A SLIGHT WHINE
Check the starter solenoid, but sounds like the starter is bad. If it is draining the battery when you try to start it, then it is the starter. Check for a bad ground first though. The starte requires a great deal of amperage and a weak ground could be the problem.
1982 e-z go electric golf cart needteck sheet
I have a 96 EZ GO gas golf cart with loose steering. What parts are normally needed to correct this problem and are special tools required for me to replace the parts.