Your golf cart may not be charging because you have a battery problem, your charger itself is faulty, the connections on the batteries, wiring, or charger cable are faulty, or there are faults with the golf cart electronics.
Why is my golf cart battery not charging?
Why is my EZGO golf cart not charging?
- No battery voltage
- No sign of life in the charger
- Lack of hydrogen in batteries
- Loud clicking noise in the charger
- The charger doesn’t stop charging or charge full
- No battery voltage: Often, this happens when the batteries have been used continuously for a long time. ...
What can go wrong in an electric golf cart?
Why your EZGO golf cart stops suddenly?
- Diagnostic mode: Try out the Diagnostic mode in the golf cart. ...
- Voltage readings: Check out the voltages that are being recorded by the batteries. ...
- Low voltage: The low voltage levels may also cause excess amperage which may end up in the controls to return to thermal cut.
How to fix an electric golf cart?
The following steps should allow you to determine the problem:
- Evaluate the circuit connection. ...
- Check the connections from wire to wire. ...
- Using a multimeter check the amount of power running to the lighting fuse. ...
- If the fuse is not the problem, you will need to now check your vehicle’s lighting switch. ...
- Replace the switch.
Why is my golf cart Charger not working?
- Inspect the condition of the charger, wire, and battery level prior to the recharge session
- Replace damaged or malfunctioning components as soon as possible
- Recharge the used golf cart battery when the unit still has energy left
- Confirm the components are functioning as intended before walking away
Why won't my electric golf cart take a charge?
If your batteries aren't hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How do I know if my golf cart charger is bad?
Bad Charger: IN GENERAL, if the charger kicks on, but doesn't charge fully or kicks off soon after, this is likely a charger issue. If the charger makes a loud clicking noise, this is likely a battery charger issue.
How do you reset a golf cart charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you force a golf cart battery to charge?
Drive the golf car for an extended period of time so the batteries will discharge, plug the golf car charger in again and repeat this cycle for about 3 or 4 times. Each time will increase the battery charge and golf car run time.
What do you do if your golf cart won't charge?
Golf Cart Won't ChargeCheck our outlet to make sure that you're getting power to your electrical outlet.Check the water level in your batteries, using distilled water to refill only. ... Check for corrosion or any loose cables on the batteries.Check the condition of your charger's cables (AC and DC cables).More items...
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
Where is the reset button on electric golf cart?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
How do you test a golf cart charger?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do I know if my battery charger is working?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
Can you leave golf cart charger plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
Can you charge golf cart batteries with a regular battery charger?
These batteries are designed to be discharged almost completely and repeatedly with low loss in performance. Golf carts usually come with their own charger, however a car charger can also be used to charge a golf cart. The trick is matching the voltage of the charger to the voltage of the batteries.
Can you overcharge golf cart batteries?
Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Some older models lack this important feature. If you must use a manual charger, don't forget to turn it off.
How do you test a golf cart charger?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How can you tell if a battery charger is working?
To test the charger's output, connect the battery to the charger and turn on the charger. The meter should read near or equal to the battery's rated voltage. If it doesn't, the charger fails. It is also a good idea to test the charger's current output.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
How do you test a battery charger?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
What wires are needed to charge a golf cart?
Only the red and black wires are needed to completely charge the golf cart. The blue wire is an optional safety wire. If hooked up to the motor controller it will not allow you drive the golf cart while charging it. Think about being at the gas pump and driving off with the pump still in the car.
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
Why does my cart battery not charge?
Unfortunately, a lack of water in your battery will cause it to fail to charge. The water here is essential for conducting the electricity and focusing it into the cells.
Why is my battery not charging?
Typically, this happens if you have left the battery in the sun or in a hot area that allowed the cells to get damaged.
How long does a golf cart battery last?
While a golf cart battery does have a fairly long lifespan, it is not designed to last longer than a decade or so. After 10 years, you’re going to start seeing a lot of troubles with your battery. The charge may come out unevenly into the cart or the cells may refuse to hold any charge at all when you try.
What happens if you drive a cart a lot?
If you drive your cart a lot and often fully deplete the battery before charging, you may end up creating a scenario in which the array refuses to take a charge.
What happens if you put water in a battery?
Inside of your battery, there should be a certain amount of distilled water that covers the plates completely. This water can end up leaking or evaporating out of your battery with time and cause issues that may be hard to predict.
What does it mean when a charger is malfunctioning?
Typically, a malfunctioning charger is one that may require more difficult repairs than you can handle yourself. Make sure that you pay attention to the type of charger that you buy, here, as you want to make sure that you buy one that is appropriate for your cart model and its battery.
How to replace battery water?
Just open up your battery, check the depth of water inside of the cells, and use distilled water to replace the old water. You need distilled and NOT tap water because the latter type has minerals and metals inside that may cause malfunction.
Why won't my Ezgo golf cart charge?
Some reasons why an EZGO RXV golf cart will not charge could be because of a dirty charging port, loose or broken wire, a blown-out fuse or a problem with the auxiliary contact. Clean the charging port so that it’s free of dust and dirt accumulation. Sometimes, dust and dirt can prevent proper charging.
How to check if golf cart battery charger is faulty?
The charger may be faulty. Check this by plugging the charger into the golf cart and see how much it charges the battery pack using a digital voltmeter. Alternatively, you can use another charger to do the charging and see if there is a difference. Allow the charger to charge the pack fully and shut down on its own.
How many volts does an EZGO 2012 hold?
Check the battery pack voltage using a multimeter. For a 48-volt cart, this should be between 46 to 50 volts based on the charge level.
How many volts should a golf cart battery pack have?
Charge two batteries at a time with a 12-volt charger and then use the auto golf cart charger to resume the charging. The battery pack must have at least 28 volts for the cart charger to be able to kick in. Also, ensure that the battery plates have at least 1/4 inch of distilled water above them before charging.
Why is my Ezgo cart not charging?
It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries. A charger problem can also be associated with the charger making a loud clicking noise, failing to stop charging after the batteries have attained full charge ...
How many volts should a 48 volt battery be?
Depending on the charge level, it should read between 46 to 50 volts for a 48-volt cart. If the reading is abnormally low such as 16 volts or 24 volts, check the voltage of each battery individually by hooking on to a regular charger. Also, check the water level in each battery.
How to check if a voltage regulator is faulty?
To check if the regulator is defective, remove the green wire connecting the generator and the stator at the generator end. Get the engine running, ground the disconnected end and check the voltage rating using a voltmeter.
How long does it take to charge an electric golf cart?
It can take anywhere from 3 to 10 hours to fully charge your electric golf cart. This is assuming the battery is nearly discharged. The exact time it will take depends on the age of your batteries and the type of charger you use. Generally, you can expect older batteries to take longer to charge (5+ hours).
Where is the charging plug on a golf cart?
Connect charging plug to the cart’s charging outlet – the charging outlet can be located on the exterior of the cart or underneath the seat. Leave the charger connected until the battery is fully charged – not allowing your battery to fully charge might reduce its lifespan.
What does a red light on a battery charger mean?
Others have indicator lights to let you know. For example, a red light might mean that the battery still needs to be charged while a green light usually indicates it is fully charged.
Can you charge a golf cart with a generator?
Most people choose to use a simple wall outlet from their home. If your golf cart is usually stored somewhere where this is not an option, you can also use a generator. ***Make sure you charge your cart in a well-ventilated area.
Can you overcharge a golf cart battery?
If you frequently run your cart until the battery is nearly dead, it will damage the battery and can significantly shorten its lifespan. On the other hand, it’s important not to overcharge your electric golf cart battery as repetitive over-charging can also lead to battery damage.
What is a battery charger?
Battery chargers have a logic circuit that determines the voltage of the battery before turning on. In the case of an E-Z-GO Powerwise charger, the logic board is actually powered by the DC voltage from the golf car. If there is no voltage in the batteries, the logic board does not even activate.
What happens if there is no voltage in the battery?
If there is no voltage in the batteries, the logic board does not even activate. In a normal situation, the logic board gets its current from the cart through the small red wire in the DC power cord. That current powers up the board and the board determines if the voltage is within a certain range.
Why won't my golf cart charger shut off?
Why Does My Golf Cart Charger Not Shut Off? A golf cart charger will not shut off due to a faulty battery, faulty charger, damage to the power cable, or insufficient water levels in the battery. Bad Battery: In general, charging problems with batteries occurs when the battery is no longer in the space of fixing.
How to tell if a golf cart battery is faulty?
You will know if the battery is faulty or not very quickly. Check if there is any corrosion at the terminals. Check all the cables or wires of your golf cart; ensure that they are not damaged. Don’t forget to check the water levels in your batteries. They should not be lower than the plates.
Why is my golf cart not shutting off?
You should first replace the batteries and charger as these are the likely reasons why the golf cart is not shutting off. The relay might have been bypassed in the charger, or simply, it’s faulty. Maybe the control board of the charger is not in good condition. The “brain” of the charger might have been damaged somehow.
What is OBC on a golf cart?
OBC controls some of the crucial functions of a golf cart, so if it’s outdated, then some of your cart’s parts may not function correctly. Maybe the brain of your charger is failing. In that case, replacing it is the only and quick solution. Make sure if the fuse is alright or it has blown.
How long does it take for an EZGO battery charger to charge?
Why EZGO Battery Charger Won’t Stop Charging. A golf cart’s batteries can take up to 16 hours to complete its charge. This information can help you if you are giving up before 16 hours. You must know that if you have a 36v system, the charger charges the batteries up to 44-46 volts.
How long does it take for a charger to shut off?
The timer board in the charger does the job to shut the charger off after 16 hours, even if the batteries are not fully charged. Maybe buying a new board can fix the problem. It can be possible that somehow the pins in the charger have worn. Try holding it up by you after plugging it in and check what happens.
What happens if the ground wire is at the F2 terminal?
If the ground wire is at the f2 terminal and the wire comes from the solenoid is on the A2 terminal, the generator is active, so the regulator does not have enough time to shut the charger off. Somehow the key switch or the throttle switch is responsible for the overcharging.
