Generally, a golf cart not charging is a result of the loss of power from the wall outlet to your charger, an issue with the voltage of your battery pack, the charging receptacle is faulty, or occasionally, the issue is with the golf cart charger itself.
Why is my golf cart battery not charging?
Yamaha g1 Golf Cart not charging
- Often, the G1 golf cart doesn’t charge because of a bad receptacle. Make sure that the receptacles fit tightly and are clean. ...
- Check the plastic coverings on the prongs. A broken cover can also build problems. ...
- The next thing to watch out for is corrosion. Corrosion mainly occurs at the battery terminals. ...
How do you recharge a dead golf cart battery?
You will need:
- Battery charger
- Epsom salts
- Baking soda (and an old paintbrush)
- Distilled water (and a turkey baster)
What is the best battery charger for a golf cart?
PROS:
- This product is designed in a fully automatic manner so that it can easily charge a golf cart battery.
- This is great for golf carts – and can be used for many other different batteries, which may be important to some consumers.
- This charger was designed with reverse polarity protection.
- There is a power on, power off, and fully charged indication.
How to properly charge a golf cart battery?
When to Charge Golf Cart Batteries:
- Charge your golf cart batteries before they get empty.
- The cart batteries could get damage permanently if you left them without any charge for a few weeks or a month; because of the self-discharge ability of the cart ...
- You should keep charging the batteries even when the golf cart is in rest. ...
What would cause an electric golf cart not to run?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
How do you reset an electric golf cart?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Why did my golf cart suddenly stop working?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch. If the micro-switch is faulty, it can also cause the cart to suddenly stop midway.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Where is the reset button on an electric Club Car golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Where is the fuse box on an electric golf cart?
In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart. They're round in shape and made of glass. The blue fuse block in a Yamaha G29 golf cart is below the cup holder and secured on the shelf.
How do you troubleshoot an electric EZ Go golf cart?
Things to Keep in Mind Before TroubleshootingEZGO golf cart batteries aren't perfect right away.Sticky accelerators are perfectly normal and can be fixed easily.Keep your cart stable.Make sure your charging wall socket isn't faulty.Keep your tire pressure stable.Troubleshooting the speed controller.
How do you troubleshoot an electric Club Car?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do you test a golf cart electric motor?
3:5410:28Testing 36 volt golf cart motor with 12 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou just want to connect the two together with this again a2 to s1 with this jumper cable. And youMoreYou just want to connect the two together with this again a2 to s1 with this jumper cable. And you want to take the battery box or positive cable and put it on the s2.
What are the symptoms of a bad solenoid in a golf cart?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Do electric golf carts have fuses?
Yes, golf carts contain fuses just like those found in a car or truck.
Why won't my electric golf cart start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won’t start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
How to test golf cart batteries?
Another method to test your batteries is by using a load tester. Battery load testers can come in a variety of different price ranges. They give golf cart owners the ability to monitor their battery’s voltage to see how much the volt drops during testing, which indicates the health of the batteries.
What is the best way to check if a golf cart battery is charging?
A Battery Hydrometer: A battery hydrometer measures the specific gravity of the electrolyte solution and can indicate whether or not your batteries are charging correctly. This method is inexpensive and reliable, making it a popular choice for golf cart owners.
How to reduce golf cart issues?
However, the best way to reduce your chances of golf cart issues, later on, is by performing regular preventative maintenance. With preventative maintenance, you can extend the life of your golf cart and potentially save money in the long run.
Why does my golf cart make a clicking noise?
The solenoid is a critical component of your golf cart because it is the main switch that connects the current from the battery to the traction motor. That clicking noise that you hear when you press the gas pedal is the solenoid.
How to check if a battery is charged?
Make sure your batteries are fully charged, first, and then check for the following: 1 Any cracks or dirt in the batteries. 2 The water-electrolyte levels (on a weekly basis). If the water runs too low, it can shorten the life of your batteries. Overfilling can also result in a loss of electrolytes. 3 Look for signs of corrosion on your connectors and ensure that they are tight. 4 Dirt and other debris can affect the performance of your batteries. Clean them regularly with a bristle brush, water, and baking soda, but take care not to get any of the electrical components wet.
What to check before checking batteries?
Make sure your batteries are fully charged, first, and then check for the following: Any cracks or dirt in the batteries. The water-electrolyte levels (on a weekly basis).
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How many volts does a battery charger need to charge?
When your charger can’t tell that your batteries are hooked up, it often won’t even turn on. A base charge of 25-30 volts is usually sufficient to wake up your charger and begin charging. To get around this problem, specific chargers offer modes that keep your batteries charged even when you’re not using them.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
What to do if battery is stuck at no charge?
However, if you’re stuck at no charge, a small, manual charger should provide each battery with enough juice to activate your regular charger.
How to check if golf cart battery charger is faulty?
The charger may be faulty. Check this by plugging the charger into the golf cart and see how much it charges the battery pack using a digital voltmeter. Alternatively, you can use another charger to do the charging and see if there is a difference. Allow the charger to charge the pack fully and shut down on its own.
Why won't my Ezgo golf cart charge?
Some reasons why an EZGO RXV golf cart will not charge could be because of a dirty charging port, loose or broken wire, a blown-out fuse or a problem with the auxiliary contact. Clean the charging port so that it’s free of dust and dirt accumulation. Sometimes, dust and dirt can prevent proper charging.
How many volts does an EZGO 2012 hold?
Check the battery pack voltage using a multimeter. For a 48-volt cart, this should be between 46 to 50 volts based on the charge level.
How many volts should a golf cart battery pack have?
Charge two batteries at a time with a 12-volt charger and then use the auto golf cart charger to resume the charging. The battery pack must have at least 28 volts for the cart charger to be able to kick in. Also, ensure that the battery plates have at least 1/4 inch of distilled water above them before charging.
Why is my Ezgo cart not charging?
It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries. A charger problem can also be associated with the charger making a loud clicking noise, failing to stop charging after the batteries have attained full charge ...
How many volts should a 48 volt battery be?
Depending on the charge level, it should read between 46 to 50 volts for a 48-volt cart. If the reading is abnormally low such as 16 volts or 24 volts, check the voltage of each battery individually by hooking on to a regular charger. Also, check the water level in each battery.
How to check if a voltage regulator is faulty?
To check if the regulator is defective, remove the green wire connecting the generator and the stator at the generator end. Get the engine running, ground the disconnected end and check the voltage rating using a voltmeter.
Why won't my golf cart start?
Like any other electric vehicle, the batteries are mainly at the root of why your cart won't start. After all, they are the primary source of power for your electric golf cart. If your cart is not working, this is the first place to check. Generally, lead acid-based batteries are used for electric golf carts, and you must recharge them regularly so that they function correctly.
What is a direction switch on a golf cart?
The direction switch or forward/reverse switch controls whether the golf cart moves forward or backward. This switch is one of the most used parts in a golf cart, which means it will be subject to wear and tear. You'll find what the issue is if the switch is acting up. There is a big chance that it will need to be replaced. Again, it's best to choose a mechanic for repair.
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
How to keep a charger from getting hot?
But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight.
Step 2. Unplug your golf cart charger from your golf cart
If your charger is currently plugged in to your golf cart. Unplug the charger from the golf cart.
Step 3. Check AC power from wall outlet
Starting the troubleshooting process begins with checking the simplest to correct stages of the charging process first. In this case, we’ll begin by checking the AC power from your wall outlet to the golf cart charger.
Step 4. Check the reset switch on charger (if applicable)
After you’ve confirmed that your wall outlet is energized and providing proper power, quickly check if your golf car charger has a reset switch.
Step 5. Confirm charger is properly plugged into golf cart
After unplugging your charger from the golf cart and making sure your outlet is providing power, wait at least 20 seconds before plugging the charger back into the golf car. This is particularly important for Club Car vehicles equipped with an on-board computer (OBC).
Step 6. Check Battery pack voltage
The most common reason a golf cart isn’t charging has to do with an issue with the battery pack, battery cables, or a single battery. Well run through how to check for each issue.
Step 7. Test the charging receptacle
If your golf car battery pack is within the ranges above, but your golf car is still not charging with the golf cart charger, you may have an issue with your charging receptacle on the golf car.
Step 8. Test On-board Computer (Club Car only)
At this point, there are only a couple of components left that could be preventing your golf cart from charging. On Club Cars only, one component is the on-board computer, or OBC. This component is involved in the charging system on your 48V Club Car on troubleshooting this component will be discussed in a separate article.
What happens if your golf cart battery is low?
If the water level of the batteries is low, then the blade inside it will be dried, and you won’t be able to recharge your battery. Charging problems of golf carts are not something new. It can be quickly resolved. All you need to do is to examine the cart thoroughly and immediately replace the faulty parts.
Why won't my club car golf cart turn off?
A Club Car golf cart will not shut off if the OBC is outdated or faulty. In this case, the reason depends on whether the charger is not shutting off when it is plugged into the device , or it is not plugged in but still not shutting off.
Why is my charger clicking?
If the charger is clicking while plugging it in, and doing nothing, examine your charger and probably replace it . If the “brain” of the charger fails , then it can cause several issues, and the batteries will not charge. Purchasing a new one or repairing the component can solve the problem.
What is the OBC on a 48V club car?
In the 48V club cars, the OBC is primarily responsible for the batteries’ charge. It controls the batteries charging, which is why the 48V requires a fully functional OBC all the time. Connect the batteries to a voltmeter and check if the charger is generating enough power.
How to keep car batteries charged when idle?
Try to keep specific chargers, which will help your batteries to stay charged even when the car is idle. Enough power supply is critical to keep the charger working and keep the batteries charging. Check your connections, and then turn on your charger.
What does it mean when a charger is bad?
Bad charger: if the charger turns on but there is no sign of charging. If the charger is making noises like a loud click, before kicking off. If the charger keeps charging even after turning the switch off then, without any doubt, it’s time to replace the charger.
What is the problem with my 2007 golf cart?
But to bypass the OBC, you will need a smart charger. There are three wires at the back of your cart’s charger connection- a large black wire, a large red wire, and the small wire.