When you’re electric golf cart struggles on inclines for a variety of reasons, including weak batteries, incorrect tires, or worn-out motor or wiring, you could be in for a long day. You can restore your vehicle’s mobility by calling your local golf car service for help.
Full Answer
Why won’t my golf cart start?
The first time I tried to use my golf cart and it wouldn’t start, I was lost trying to figure out what to do next. I learned that there are symptoms to watch for and what to do to fix the problem. Your golf cart won’t start if there is a problem with the fuel, airflow, or electrical system.
Why won't my electric golf cart go uphill?
My electric golf cart will not go uphill and losses power quickly. When golf cart gets just slightly below a full charge it will not go uphill. It will go on flat land. Battery voltage was a little low but batteries still tested good. Answered! View the answer I have this problem too
Why does my golf cart pull in one direction?
Steering, tires, suspension, and alignment all can contribute to your golf cart pulling in one direction. If your golf cart pulls in one direction, chances are that it is one of these components. There are steps you can take to diagnose the problem and fix basic issues from one of these components.
Why is my golf cart solenoid not working?
In case you are not familiar with a solenoid, a solenoid is the main electrical switch in your golf cart, which is designed to allow the current from the batteries to flow into the motor. A bad or damaged solenoid could be the reason why your golf cart is not working correctly. Solenoid often stops working because of the following reasons.
Why won't my golf cart work?
What happens when a golf cart is not working?
Why is my golf cart not moving?
How does a speed controller work on a golf cart?
Why is my golf cart solenoid not working?
What is the function of a golf cart solenoid?
How to fix a golf cart that won't accelerate?
See more
What causes a golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
Why wont my golf cart go forward or reverse?
The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.
Why does my golf cart click but not move?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you know if your golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you test a golf cart controller?
How to Test a Club Car Golf Cart Speed Controller? The simplest test to ascertain your golf cart controller's performance is to to watch whether it runs when the batteries are fully charged with a slight push of the pedal. If you hear a distinct clicking noise, then your golf cart is running correctly.
How do I know if my ezgo golf cart solenoid is bad?
First, turn on the ignition while looking for a reading on the smaller terminals. If nothing is appearing, then press on the accelerator. If the needle doesn't move, then the problem is not with the solenoid. If it jumps and displays full voltage, then the solenoid is the problem and should be replaced with a new one.
How do I reset my Club Car golf cart?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
Why is my golf cart solenoid clicking?
Solenoid Cable and Coil Damage Issues As we mentioned previously, the solenoid is often the most common cause of a click in a Club Car golf cart. It's not necessarily that their solenoids are less durable or reliable than those of other manufacturers, as such.
Electric Golf Cart Accelerator Problems (The Most Common Issues)
Call Toll Free: 1-800-401-2934; Monday - Friday 7am - 9pm EST; Saturday 9am - 6pm EST; Sunday 10am - 7pm EST
SOLVED: Push Pedal nothing happens - Golf Cart - iFixit
Yesterday I pulled up to my ball and hit it and then got back into the cart and it wouldn't go anywhere when I press the pedal I have a 2000 ezgo electric golf cart.
Why is Your Golf Cart Pulling in One Direction?
If when you release the wheel, your golf cart drifts in one direction, or your golf cart steering pulls to one side, it’s likely one or more components in the following systems is the culprit:
Diagnosing Why Your Golf Cart Pulls in One Direction
Whether your cart is pulling to the left or the right, the following visual checks can help you determine why.
How to Fix a Drifting Golf Cart
There are some great resources online to help you diagnose and fix issues involved with golf cart directional pull. This table includes a section for addressing EZGO golf cart suspension and steering issues.
How to Prevent a Golf Cart from Pulling in One Direction
Especially if you use your cart off-road, being proactive about maintenance will save you time and money in the long run. The following table focuses on maintenance for steering and suspension, which are the primary systems involved if your cart pulls to the left or right:
In Summary
If your golf cart steering pulls to the right or the left, then determining the causes and fixing it will ensure your safety and minimize wear and tear on the components involved.
Why won't my golf cart start?
Like any other electric vehicle, the batteries are mainly at the root of why your cart won't start. After all, they are the primary source of power for your electric golf cart. If your cart is not working, this is the first place to check. Generally, lead acid-based batteries are used for electric golf carts, and you must recharge them regularly so that they function correctly.
What is a direction switch on a golf cart?
The direction switch or forward/reverse switch controls whether the golf cart moves forward or backward. This switch is one of the most used parts in a golf cart, which means it will be subject to wear and tear. You'll find what the issue is if the switch is acting up. There is a big chance that it will need to be replaced. Again, it's best to choose a mechanic for repair.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
Do key switches wear out?
They do wear out from time to time. Before troubleshooting the key switch make sure that your forward-reverse switch is fully in the forward, reverse, or neutral position. Any space in between would cause an interruption in the electrical flow to the key switch.
Can a bad battery affect a cart?
Your batteries may have the proper voltage and may not hold a charge under load. Even one bad battery can affect the performance of your cart. You should also check the voltage drop while driving uphill. Get some alligator clip test leads and connect those between positive and negative connection your cart and your meter ...
Can a golf cart go uphill?
When golf cart gets just slightly below a full charge it will not go uphill. It will go on flat land. Battery voltage was a little low but batteries still tested good.
Why does my golf cart go slow?
Our assessment of why does my electric golf cart goes slow uphill has yielded several answers. While battery problems tend to be the most common reason for slow speeds uphill. The size of your tires, speed, wire corrosion, and brake solenoid damage are also possible causes for your cart’s slow speeds. I recommend checking your batteries ...
Why is my golf cart not charging?
Golf Cart Batteries. When it comes to challenges with your cart’s speed, they are more often than not caused by an unruly battery. Corrosion, age, or a lack of routine maintenance can all lead to inefficient battery performance. As your batteries age, they are no longer able to hold a charge like they previously did.
Why is my electric golf cart slow?
Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
What happens when a brake solenoid overheats?
When your brake solenoid overheats, it will pull all your power through the resistor spring, reducing the energy transmitted to your battery. YouTuber Mike Hughes found that disconnecting the two wires leading to the solenoid, along with the cart’s speed sensor, helped to improve the transmission of power to the motor.
How to tell if a battery is going slow?
The best way to identify if the batteries are the root of your go slow is to use some alligator clip test leads. Link your meter to the positive and negative connection of the cart. Then do a test, driving uphill to simulate the problems you have had.
Can mud affect a cart's speed?
That impacts the ability of your cart to navigate slopes and may even struggle on flat terrain. The performance of your cart’s sensor can become impaired from mud build-up, which cover s the sensors and blocks their ability to determine speed. Cleaning the mud off the sensors should see it back up and running.
Why is my golf cart not full?
The fuel filter of the golf cart may not stay full because of a fault vacuum tube. Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, ...
Why is my golf cart starving for fuel?
A golf cart can be starving for fuel because of old gas in the engine, or because the flow of gas to the fuel tank is blocked. If the engine was running smooth until a few days ago, then it can be presumed that there is no glitch with the engine. Some of the possible causes are stated below:
Why does my EZGO stop?
If you have a EZGO and it has come to an abrupt stop, then it may be because of the golf cart not getting adequate fuel supplied to its tank. Check if all fuel pipe hoses are properly connected and there is no crack or hole in it. The brass vent needs to be absolutely clean.
What is the G16 golf cart?
The G16 model of Yamaha golf carts suffers from the glitch of not receiving the required levels of gas, which ends up hampering the overall performance of the golf cart.
Why does my golf cart have a dirt filter?
Some of the possible causes are stated below: There could be dirt filled in the carburetor, potentially stopping the gas flow from the tank to the engine. If the air filter can be opened from the golf cart and around 2 ounces of fresh gas get drilled in to the pump, then the issue may get sorted.
Why is my carb pump not getting sorted?
If the problem still does not get sorted, then chances are that the pump is faulty and the vacuum line has got clogged.
Why is my Yamaha G9 getting out of breath?
The Yamaha G9 has been recorded to be getting out of breath due to lack of enough fuel levels in the tank. Some of the reasons for the glitch along with possible solutions are stated as below: It may be that the air box is not sealed properly due to which air would enter inside the tank.
Why won't my golf cart work?
The golf cart will not function if the transfer of electric current is disrupted. Current gets disrupted when the solenoid gets worn out or damaged. When you press the pedal, the solenoid gets activated and compounded into a metallic contact plate.
What happens when a golf cart is not working?
When the speed controller malfunctions or does not work properly, the cart will move but with several breaks in between. The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs ...
Why is my golf cart not moving?
The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs of a problem with the speed controller of the vehicle. Here are a few things you can do to fix the issues associated with your speed controller.
How does a speed controller work on a golf cart?
Once you do this, the brake should release and the cart will start accelerating once again. The speed controller works towards regulating the speed of the golf cart. There are instances when the speed controller fails but the vehicle will still start and move ahead.
Why is my golf cart solenoid not working?
If you encounter a problem with the solenoid of your golf cart, then you must know that it could be because of a faulty speed controller. To check the condition of your vehicle’s solenoid, you will be required to take a reading of the voltage and check if it is the same as the reading from the battery.
What is the function of a golf cart solenoid?
Its main function is to enable the flow of electricity from the battery into the motor. When you press the gas pedal and hear a sound that resembles a tap, you must know that the solenoid has been activated. The golf cart will not function if the transfer of electric current is disrupted.
How to fix a golf cart that won't accelerate?
The best way to fix a golf that won’t accelerate is to readjust the battery cable, check all connections and replace the solenoid. When your golf cart does not accelerate, the one thing you need to keep in mind is that while it is an automobile, it is not a regular vehicle like your car.
