
The water level in the golf cart batteries is far below the desired level. Check the water levels of the batteries and top up the ones with low water levels. The golf cart is kept in a very cold area. Batteries tend to drain faster in cold temperatures.
Full Answer
Why does my golf cart lose power after driving?
You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.
Why do my golf cart batteries corrode?
Golf cart batteries corrode by releasing acid due to incorrect water levels, overcharging, over-discharging, and general lack of battery maintenance. Additional products like a corrosion inhibitor spray to treat the terminals will greatly reduce corrosion.
Can I leave my golf cart plugged in all the time?
You can leave your golf cart plugged in all the time as long as the charger is an automatic unit that comes on when the charge level drops.
Why does my golf cart beep when I stop?
The first beep sound will indicate the performance factor. The second set of beep sounds will indicate the fault code. Take note of the beep sounds and look up the manual to see what the problem is, signified by the beeps. The golf cart speed sensor could also be responsible for sudden stops, followed by beeps.

Does cold weather affect golf cart batteries?
The cold winter months can slow down the rate of charge/discharge on your vehicle, golf cart and equipment batteries. In addition to affecting rates, colder temperatures also carry the risk of freezing the electrolyte if the battery is not stored properly.
What causes a golf cart to lose power?
If the coach goes without charge for a long time, the battery may lack the minimum voltage required to restart. Batteries also lose their efficiency with age. Golf Carts will run for approximately five years before the battery needs to be replaced or the charger will need replacement.
Do golf carts work in cold weather?
In a cold climate, it can take a while for a golf cart battery to charge up, but it should hold its power longer. The other thing to consider in cold climates is that the battery will have likely not charge to full capacity.
Why is my golf cart battery draining?
The most common issue that typically affects battery carts and causes them to drain more quickly is a low water level. This situation is so common because many cart owners don't take the time to balance the water in their battery or don't know that they even need to perform this step.
Why is my ezgo golf cart going so slow?
A EZGO RXV and TXT golf cart can run slow because of a faulty speed sensor, low battery charge and insufficient levels of water in the battery. A problem with the speed sensor. A faulty speed magnet. One or more batteries could are weak and don't have sufficient charge or the water level could be low.
Why is my golf cart losing power up hills?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
How do I protect my golf cart batteries in the winter?
Keep them in a cool area and stay away from areas that are near heat sources such as radiators or heaters, since hot temperatures accelerate battery self-discharge. In addition, al- ways avoid areas where freezing temperatures are expected during the storage pe- riod.
How often should I charge my batteries in my golf cart?
4) To keep your golf car batteries at maximum capacity, use golf cart batteries often. Always remember to do a refresh charge every 45 to 60 days, and even more frequently in hotter climates.
How do you winterize a electric golf cart?
0:105:15Winterizing Your Electric Cart - Customcarts.ca - YouTubeYouTubeStart of suggested clipEnd of suggested clipHi i'm dan from custom cards there comes a time at the end of every season where we get a lot ofMoreHi i'm dan from custom cards there comes a time at the end of every season where we get a lot of questions about what should I do with my electric car well I'm not using it today what we're going to
How can I improve the performance of my golf cart batteries?
Here are 6 Tips to Making Your Golf Cart Batteries Last Longer.Always Use Distilled Water. Battery maintenance is best done in a well-ventilated area on a plain and level surface. ... Use a Proper Battery Charger. ... Trickle Charge the Battery. ... Prevent Corrosion. ... Pay More to Last More. ... Use Anti-Corrosion Lubricants. ... Final Note.
Should you charge your golf cart after every use?
Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
How long should a golf cart run on a full charge?
Typically, an electric golf cart has between 45 and 90 minutes of full-power run time on a fully charged battery. Times depend on the age of the battery, with newer batteries having longer run times.
How to charge a 6 volt battery overnight?
Connect the battery to a three-phase charger that can charge 6 volts batteries and let it charge overnight. Check the charger status in the morning. If it indicates a full charge, check the battery cells once again and add some more distilled water to the cells with exposed battery plates.
How to check if a golf cart battery is dead?
There are four methods of checking whether your golf cart battery is dead. Use a multimeter to check the voltage of each battery in your golf cart. Use a hydrometer to check the gravity of the electrolytes in the batteries. Use the Load Testing method.
Why does my golf cart battery keep going dead?
The reason why your golf cart battery keeps going dead may be due to loose connections, incorrect battery wiring, or having a faulty voltage regulator. The voltage regulator is at fault and tends to affect the starter solenoid.
Why does my golf cart battery drain so quickly?
The reason why your golf cart battery keeps losing charge or drains quickly, may be due to loose wires, corroded connectors or an insufficient amount of water in the battery. The battery connections may have become loose or the connectors are corroded.
How many amp hours does a golf cart battery last?
A bigger voltage drop is a sure sign of a failing or faulty battery. A golf cart battery comes with a specific amp hour rating at 20 hours. This is usually mentioned in the battery information sticker.
How to check the specific gravity of a golf cart battery?
Using a Hydrometer. You can use a hydrometer with a thermometer to check the specific gravity of the electrolyte in the golf cart batteries. If this value lies between 1.1 and 1.2, you must consider recharging the battery. Alternatively, if the value is between 1.225 and 1.265, you can continue testing your battery.
How much sulfuric acid is in a battery?
It’s worth keeping in mind that the sulfuric acid to water concentration for a fully charged battery is 1.28 while it’s 1.145 for a discharged battery. It’s highly recommended that you wear a pair of safety gloves and safety glasses when you use a hydrometer. Pour the electrolyte into the hydrometer.
How to charge a golf cart battery?
Fill all of the battery cells to the proper levels. Remove the battery tops and use distilled water to raise the water levels in the battery cells to cover the plates. Electrolyte levels in your golf cart batteries are critical, especially when cold weather hits and you need to maintain a full charge to prevent damage from freezing temperatures. ...
What is a tow/run switch on a golf cart?
The Tow/Run switch is only installed on a golf car with a separately excited motor that produces regenerative braking. This uses a small amount of power even when the key is off and can take a full charge If your cart has this switch, Set it to “Tow” and set the parking brake.
How to revive a frozen battery?
First, bring the battery inside and thaw it out, then hook it to an automotive charger that is equipped with clamps to put on the terminals. Set the charger on the lowest charge rate setting and charge the battery for around an hour.
How do batteries self discharge?
Batteries need to be dry and cleaned of any corrosion and dirt. Batteries can self-discharge by a small trickle of current slowly discharging your batteries through conductive debris.
What happens to electrolytes in cold weather?
Electrolyte expansion during cold weather can crack the battery case, causing complete battery failure. At a 40% state of charge, the electrolyte will freeze. As the state of charge in a battery decreases, the electrolyte solution gets to be more and more like water.
Can you store golf cart batteries in cold weather?
Also, note that golf cart batteries will take longer to charge in colder temperatures than they will in warm weather.
Can golf cart batteries freeze?
Golf cart batteries can freeze if not charged, and once they have frozen, it is difficult to get them to recover. The more the battery is charged, the lower the temperature must be to freeze it. Here are some tips for storing your golf cart batteries over the winter.
1. Speed Sensor Issues
The speed sensor is an essential and critical part of golf cart operation that helps to ensure that cart runs smoothly and efficiently. It operates by measuring how fast you are driving and how much electricity is needed to maintain that speed. When the speed sensor ends up running into trouble, chances are your cart may end up running slowly.
2. Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
4. Bearing Encoder Issues
The bearing encoder is an essential part of your golf cart that provides you with careful electrical charge distribution throughout your cart. It works by encoding various elements of your cart's operation and translating them to different impulses to keep the power running smoothly.
5 Ampacity Controller Fault
The Ampacity controller is a part of your cart that helps to manage the amperage that produces and uses as your cart drives. When this particular part malfunctions, you're going to run into some issues with your cart operation.
How to Increase your golf cart speed?
Are you looking to increase your golf cart speed? Learn more about how to make your golf cart go faster.
Golf Cart Battery Corrosion Basics
Golf Cart batteries often corrode due to the gases that are released as your batteries lose their charge and release sulfuric gases. These gases will gradually cause corrosion and cause issues with your golf cart batteries so make sure to check and clean your batteries often.
How to care for your golf cart batteries?
Caring for your golf cart batteries will prolong the life of your golf cart and allow you plenty of use for years to come. In order for you to get the most life out of your golf cart batteries, there are a few maintenance steps to take.
How to Clean Corrosion off of your Golf Cart batteries?
After you have had your golf cart for some time, you may begin to see corrosion or build up on your batteries. To clean your batteries and golf cart well, you can simply remove your batteries for easier access.
What products are best to prevent golf cart battery corrosion?
Corrosion on golf cart batteries is caused by sulfation which releases gases when the battery is charged to 50 percent or less capacity. There are chargers as well as special products that will reduce the chance of corrosion and keep your battery in great condition for years to come.
Why is it important to use distilled water to refill your Golf Cart batteries?
Making sure to check the water level on your batteries will ensure that they will last for years to come. You should always check water levels on your battery after it reaches a full charge and before you take it out for a drive. It is important to specifically use distilled water anytime you refill your golf cart battery fluid.
Should I keep my Golf Cart plugged in at all times?
Knowing when to charge your golf cart simply depends on how often you use it. If you are using your Golf Cart occasionally, such as a couple times a month, then you should make it a habit to unplug your battery every so often.
Is corrosion a sign of a bad battery?
Your Golf Cart batteries usually can tell you something is wrong or needs to be fixed by showing you multiple different signs. The care of your golf cart battery will be the difference between having issues with your golf cart over and over or having a working golf cart for years to come.
Can a bad battery affect a cart?
Your batteries may have the proper voltage and may not hold a charge under load. Even one bad battery can affect the performance of your cart. You should also check the voltage drop while driving uphill. Get some alligator clip test leads and connect those between positive and negative connection your cart and your meter ...
Can a golf cart go uphill?
When golf cart gets just slightly below a full charge it will not go uphill. It will go on flat land. Battery voltage was a little low but batteries still tested good.
