If you own a 48-volt Club Car, sometimes your golf cart itself can get in the way of a proper charge. If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Can you use a 48 volt charger on a golf cart?
With 48 volt chargers, the same applies (you can swap out plugs), EXCEPT when you are attempting to use a 48V Club Car or its charger with the round 3-pin plug. The 48V Club Car chargers are completely different than all other golf cart chargers.
How to troubleshoot 48 volt club car charging problems?
Use this troubleshooting guide to diagnose charging problems with 48 Volt Club Car vehicles 1. The first step would be to make sure the vehicle has enough voltage to trigger the charger turn-on signal from the on-board computer. Check the battery voltage of the entire battery pack with a digital volt meter.
Is your battery charger not working on your electric golf cart?
If you own an electric golf cart, you are undoubtedly familiar with charging the batteries. If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, you should have some sense of where the problem might lie and how to mitigate it.
Why is my golf cart Charger always hot?
A cheap extension cord can cause the charger to overheat. Give the charger room to breathe and make sure it is on a hard surface, preferably the garage floor. With that said, if the golf cart charger is always hot and always giving off a bad smell, you should contact the manufacturer to confirm that everything is functioning properly.
How do you reset a golf cart charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do I know if my golf cart battery charger is bad?
Bad Charger: IN GENERAL, if the charger kicks on, but doesn't charge fully or kicks off soon after, this is likely a charger issue. If the charger makes a loud clicking noise, this is likely a battery charger issue.
What would cause a battery charger to stop working?
There are a few basic reasons why your charger would stop working: The wall socket is off or damaged. A damaged charger. There is damage to the device power port.
How do you test a 48 volt golf cart charger?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
What do you do when your golf cart batteries won't charge?
Golf Cart Won't ChargeCheck our outlet to make sure that you're getting power to your electrical outlet.Check the water level in your batteries, using distilled water to refill only. ... Check for corrosion or any loose cables on the batteries.Check the condition of your charger's cables (AC and DC cables).More items...
Do golf cart battery chargers have fuses?
Golf Cart Issues If the Club Car's computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse. If you check the fuse and it is okay, then you could also have a damaged relay, although this is rare.
Does battery charger have a fuse?
The fuse on the battery charger is typically located on the front. Open the fuse cover and remove the old fuse. If you can't get the fuse out with your fingers, use a screwdriver to remove it. Push a replacement fuse into place and close the fuse cover.
Where is the fuse on a battery charger?
0:444:16Battery, Terminals & Fusebox Locations Dodge Charger - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd the battery. The battery is right here tucked away the positive terminal is right thereMoreAnd the battery. The battery is right here tucked away the positive terminal is right there underneath this protective cover the negative terminal is right here there is also a fuse. Box right here.
How do I know if my golf cart is charging?
1:564:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipOff if you're using a more modern style charger like this one you'll find led indicator lights toMoreOff if you're using a more modern style charger like this one you'll find led indicator lights to show that charging is in progress depending on the make.
How do you test a battery charger?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
Do golf carts need batteries?
If you find that your golf cart won’t go very far on a full charge, then you probably need new batteries. Test them to make sure that the power on them is low; if indeed it is, then you need new batteries.
Can a club car monitor battery charge?
Only the club car can monitor the charge of your batteries, but it bears mention because these computers can fail, thus requiring a replacement. If the Club Car’s computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse.
What happens if the voltage is low on a charger?
Glad you got it going! Just a note though. If the incoming 110 volts to the charger is low, The efficiency of it's output is drastically effected. P=IxE, and so if E is low the charger tries to supply more I to produce it power to the battery back. This often happens with the use of long extension cords (or ones with to light of wiring) to supply the power to the charger. Just something you might want to take a look at. May not have anything to do with your situation, but just worth noting. I've had it happen myself. I was blaming the charger, and didn't realize that the incoming voltage to the charger was dropping down in the 90's. Another thing I would do, is ALWAYS start with a meter to determine the charge state of the battery pack first. You need to see what you are dealing with in there first. You can use the same meter (on AC instead of DC) to look at the 110 coming into the charger under it's load. Just a thought.
How long to charge a 12V battery?
The batteries are low you need to charge them with a 12 V charger 20-30 minutes each then try the charger again
Does EZGO golf cart have reed switch?
Your cart doesn't have a reed switch. EZGO uses them to prevent the golf cart from running while the battery charger is plugged in.
What to do if your charger is not clicking?
If your charger hasn't been "clicking" on, replace the relay. If you don't see a change in voltage on your screen when this test is performed, this is an indication that the on-board computer has failed and is no longer able to communicate with the charger. The on-board computer must be replaced.
What to do if your charger fuse is bad?
If the fuse is bad, replace it with a 3/8 amp fuse. Anything else will damage the charging system. There is also a larger fuse bolted to the back of the charger receptacle. You'll see that there are two black wires bolted to the back of the receptacle. This is where you'll find the fuse.
Where is the inline fuse located on a club car?
3. If you have a Club Car DS or Carryall vehicle you will have two fuses to check near the charger receptacle. One is an inline fuse located on the grey control wire mentioned in step two. It is located inside a yellow rubber fuse holder.
What is the color of the battery on a computer?
Red is the positive. Black is the negative. Grey is the On-Board computer control wire. Make sure that the red wire is in good shape and follow it all the way to the MAIN positive battery post. Make sure there is a good connection on the battery and ensure that the wire isn't corroded or broken.
How to Tell If My Golf Cart Battery Charger Is Bad?
You can tell if your golf cart battery charger is bad if it doesn’t charge fully but is functional or the charger gives out some clicking noises at regular intervals.
Why Is My Yamaha Golf Cart Charger Clicking On And Off?
Your Yamaha golf cart charger clicks ON and OFF because of a charger that is connected incorrectly.
Why EZGO Battery Charger Is Clicking?
The EZGO battery charger is often clicking because it’s not working properly or the charger cable is worn-out or water level is too low in the battery , all of which could result in a bad connection with the cart.
How to Fix the EZGO Golf Cart Charger Which Keeps Clicking On and Off?
You can fix the EZGO golf cart charger that keeps clicking ON and OFF by checking the voltage ratings and water levels of the batteries. You may also need to replace the charger.
How To Fix A Club Car Charger That Clicks But Doesn’t Charge?
A Club Car charger that clicks but doesn’t charge can be fixed by checking for an issue with the voltage in the wall receptacle or with the battery.
Why Powerwise Charger Clicks But Won’t Turn On?
The Powerwise charger clicks but won’t turn ON because of a capacitor that might have gone bad or a defective meter in the charger. The clicking sound can also be due to a faulty relay in the charger.
Why is my Powerwise charger not working?
If the pH of the battery is not as desired, then the charger might not work properly. Such issues are usually common in the case of an automatic Powerwise charger. Changing the charger usually helps in resolving this issue quite easily.
Why is my golf cart charging so bad?
Most of the time, charging problems of golf carts comes from a damaged charger. I cannot confirm it, but you should taste it before throwing it.
Why won't my golf cart charger shut off?
Why Does My Golf Cart Charger Not Shut Off? A golf cart charger will not shut off due to a faulty battery, faulty charger, damage to the power cable, or insufficient water levels in the battery. Bad Battery: In general, charging problems with batteries occurs when the battery is no longer in the space of fixing.
How to check if a battery charger is charging?
Connect the batteries with a voltmeter and check if the charger is charging them more than they need. This way, you can find out which one is faulty among the batteries and the charger.
Why is my voltage regulator bad?
Bad voltage regulators can also result from faulty grounding somewhere in the regulator or the starter generator. Try to fix it, and the overcharging problem will be initially fixed.
How long does it take for an EZGO battery charger to charge?
Why EZGO Battery Charger Won’t Stop Charging. A golf cart’s batteries can take up to 16 hours to complete its charge. This information can help you if you are giving up before 16 hours. You must know that if you have a 36v system, the charger charges the batteries up to 44-46 volts.
What is an OBC in a club car?
Check if the OBC is alright. Generally, in the 48v club cars, OBC is like a root of batteries’ charging functions. So in order to charge the batteries correctly, the OBC needs to be fully functional all time.
Why is my G16 overcharging?
The most common reason for overcharging of the g16 golf cart is the problematic voltage regulator. Maybe changing it will solve the problems.