Full Answer
Why does my golf cart turn over but not start?
A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark.
How to troubleshoot a gasoline golf cart?
How Do You Troubleshoot a Gasoline Golf Cart? Spark Plugs. Let’s start with the spark plug. ... Is it all oily, fouled, or the gap bridged in any way? If this all... Fuel. Okay, the electrical system checks out and the engine still won’t start. Before screwing the spark plug back into... Air. Check ...
Why does my Yamaha golf cart have no power?
Your Yamaha golf cart may have no power due to a problematic fuel filter, a cracked rubber boot, dirt/debris accumulation, or improper combustion. If you have an electric golf cart, faulty batteries or wrong battery connections may also cause the problem. Check if the fuel filter of your golf cart is damaged and do a replacement if necessary.
What to do if your G9 Yamaha golf cart won’t start?
Check the fuses and the fuse holder as well, to be doubly sure. If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
What would make a gas golf cart not start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Why does my Yamaha golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Where is the reset button on a Yamaha golf cart motor?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you test a fuel pump on a Yamaha golf cart?
A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you've enjoyed out tutorial on golf cart fuel pumps.
How do you start a Yamaha gas golf cart?
1:412:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
What makes a gas golf cart start?
In a car, the engine starts when you turn the key, and it keeps running until you switch the ignition off. In a gasoline-powered golf cart, the engine starts when you step on the gas pedal, and it shuts off when you take your foot off the gas.
How do I reset my Yamaha golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Where is the solenoid located on a Yamaha gas golf cart?
0:095:38Replace Solenoid in Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipCart um your solenoid could be located in a bunch of different places but almost always underneathMoreCart um your solenoid could be located in a bunch of different places but almost always underneath the seat.
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do you prime a Yamaha golf cart?
How to Prime a Golf Cart Fuel PumpTurn the engine of the golf cart on and remove the gas cap.Keep a rag around the filler hole.Blow hard into the gas tank. You may have to do this a few times until the engine starts purring and the fuel filter has fuel in it.
How do I know if my golf cart fuel pump is bad?
Fuel Pump Problems The simple answer is the engine doesn't run as well as it should. More specifically, you may have trouble with your engine at low speeds, or it may lose power at high speeds. If your clog is especially bad, the engine sputters to a halt or may not even start.
Why is my carburetor not getting gas?
float may be stuck in the closed position or if carburetor equipped with a electric shut off/solenoid it could be faulty/stuck/bad connection. Now if you are getting fuel to carb. and the bowl is filling, either the jets are clogged or you have not adjusted the screws out to the proper settings to allow fuel to flow.
Why is my Club Car Gas golf cart turning over but not starting?
There are quite a few reasons why your club car golf cart refuses to start. One of the problems may be a clogged fuel line. To fix this, you have to:
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
What to check on an EZGO golf cart?
Check for damaged spark plugs, solenoids or dirty gas lines on your EZGO RXV golf cart. If you find some faults here, fix them and check if it’s running smoothly or not.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
How to test a Yamaha G9 golf cart?
To test this, you have to put the key in the starting position and crank up the Yamaha G9 golf cart engine; the solenoid should provide power to both the terminals. This will now supply power to the starter.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
Why is my Yamaha G1 golf cart not turning on?
Your Yamaha G1 golf cart may have no power because of cracked seals, a plugged muffler, a fouled spark plug, or low compression. A malfunctioning clutch, an improperly adjusted carburetor, or a worn-out drive belt can also cause this problem.
Why is my Yamaha golf cart losing power?
Your electric Yamaha golf cart is likely to be losing power due to a battery or installation-related problems. The battery could be loose, corroded, frayed connections, not retaining charge or have a low water level.
How to check if golf cart is running out of power?
Do a compression test on the golf cart using a compression tester. Low compression can also cause the golf cart to run out of power. Also, check the fuel pressure and ensure that it’s as desired. Check the clutch to see if it’s functioning properly. It should shift out when the cart is on jacks.
Why won't my Yamaha golf cart go uphill?
Your Yamaha golf cart will not have power while going uphill if it has a fuel related problem, a worn-out, cracked, or loose drive belt or tension cable, malfunctioning clutches, or low battery voltage.
Why is my Yamaha G9 not turning on?
Your Yamaha G9 golf cart might have no power because of a clutch problem, a dirty carburetor, or low engine compression. The throttle not opening properly or improperly seated air filter box lid can also be a reason for the golf cart to have no power.
How to fix a battery that is loose?
If there are loose connections, tighten them. However, make sure that they are not overly tight. Replace corroded or frayed connections with new ones.
Why does my Yamaha G22 lose power?
Your Yamaha G22 may lose power due to a broken C clip or the rubbing action of the helix on the rear end housing, out of adjustment governor, or problematic clutches.
What happens when you press the gas pedal on a golf cart?
When you press the gas pedal, it clicks but will not go forward or reverse. All was fine. I have a yamaha gas golf cart. When you press the gas pedal, it clicks but will not go forward or reverse. All was fine - Answered by a verified Technician.
Can you use a Yamaha G16 gas golf cart?
You can! I have a Yamaha g16 gas golf cart and I just
Why is my Yamaha golf cart not clicking?
Check the controller if you find that your Yamaha golf cart’s solenoid is not clicking after you have installed a new set of batteries. This can happen and you must first check the controller.
Why My Yamaha Golf Cart Solenoid Clicks but Won’t Move?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid.
Why is my G29 not moving?
Some experts think that faulty batteries are the main reason for G29 Yamaha golf carts not moving when started. With the batteries, there can be multiple issues. Keeping them charged to the full is important.
Why is my solenoid not clicking?
The reason why the solenoid is not clicking could be that it is faulty or has no grounding. Experts recommend checking all wiring and cable connections to rule out this possibility. Batteries on your G16 Yamaha golf carts should raise sufficient power to reach the solenoid and the starter/generator.
How to check solenoid on a G9 golf cart?
The solenoid can be checked using an old screwdriver to jump the terminals. Your G9 Yamaha golf cart’s key must be in the start position. If the starter turns when you do this, your solenoid needs to be replaced. You must be careful while doing this crude test; there could be sparks when the two terminals touch.
What does absence of spin mean on Yamaha golf cart?
The absence of a spin in this test could mean your Yamaha golf cart’s battery pack is failing.
How to connect a battery to a solenoid?
Take a jumper cable and connect them from the positive and negative posts of the battery pack to the two posts on the solenoid that you just disconnected.
How to tell if a Yamaha golf cart is going to start?
Your Yamaha G1 golf cart may start up easily and you hear the solenoid making a click sound when you press the pedal . Despite this, if the vehicle suffers from acceleration problems, you could try pushing and releasing the pedal several times.
What happens when a golf cart is not working?
When the speed controller malfunctions or does not work properly, the cart will move but with several breaks in between. The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs ...
How to slow down a golf cart?
If you wish to have control over the speed of your golf cart, you have to ensure that the speed controller is in good condition. Apart from ensuring that the vehicle runs fast, the speed controller also helps in slowing it down.
Why EZGO gas golf cart won’t accelerate?
The EZGO gas golf cart is known to be one of the most sturdy and durable golf carts out there. If it does not accelerate at some point in time, there is a possibility of some damage to its solenoid. The solenoid can be defined as the primary or the most basic electrical switch present in the EZGO gas golf cart. Its main function is to enable the flow of electricity from the battery into the motor.
Why is my golf cart not moving?
The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs of a problem with the speed controller of the vehicle. Here are a few things you can do to fix the issues associated with your speed controller.
How does a speed controller work on a golf cart?
Once you do this, the brake should release and the cart will start accelerating once again. The speed controller works towards regulating the speed of the golf cart. There are instances when the speed controller fails but the vehicle will still start and move ahead.
Why is my golf cart solenoid not working?
If you encounter a problem with the solenoid of your golf cart, then you must know that it could be because of a faulty speed controller. To check the condition of your vehicle’s solenoid, you will be required to take a reading of the voltage and check if it is the same as the reading from the battery.