Golf-FAQ.com

why would golf cart rims scrub leaf spring

by Gus Bashirian DVM Published 3 years ago Updated 2 years ago
image

After years of use, your EZGO's leaf springs and shocks can start to show their age. Weak leaf springs and non-responsive shocks will have the most significant impact when driving over rough terrain or adding additional weight to your cart. If you have larger wheels and tires, they may start to rub up against the wheel well.

Full Answer

Why is my golf cart so bumpy?

Too high a pressure makes the cart ride bumpy while too low pressure causes the cart to drag. Rotating the tires occasionally for uniform use is a good idea. To confirm if your shocks need to be changed, get on to the bumper of the cart and push it down three to four times continuously.

Why do golf carts have tires that bottom out?

Just the tires alone give extra height to the cart, but the fancy, new tires create another problem, which is that they shrink the clearance between the tire and the wheel well, causing them to bottom out with a heavy load or rub themselves raw against the underside of the cart.

Why does my Yamaha golf cart ride rough?

Your Yamaha golf cart rides rough because of a small lift and a leaf spring type suspension. Both of these components can give you a harsh ride. Consider replacing the existing lift with a long travel lift. Similarly, it’s a good idea to use a long travel A-arm in place of the leaf spring suspension.

How do you level out a golf cart with springs?

You can change the springs from the front to the rear to check if the lean moves towards the back. If the lean angle changes, you will know that the issue is caused by these springs. Try swapping out the springs from both the sides. Changing the springs will level out your cart and solve this problem.

image

Do golf cart leaf springs wear out?

Golf cart shocks, struts, coil-over suspension and leaf spring parts fade out over time due to use and age. These parts come in at #8 on our list of most commonly replaced items by our customers. Golf Carts utilize shock absorbers and/or leaf springs to soften ride quality over the bumps of rough terrain.

How long does a golf cart last?

For example, some experts estimate that the average golf cart has a useful life range of about 5-7 years. That said, golf carts can still be used for 10 years or more depending on how well they are maintained and how much money a buyer wants to put into their vehicle.

Will heavy duty leaf springs lift a golf cart?

You may already know this, but Heavy Duty Leaf Springs are essential when you add bigger tires and a lift kit. They prepare your golf cart for more rough terrain and carry a heavier weight. They are quick and easy to install.

Do lifted golf carts ride rough?

Your Yamaha golf cart rides rough because of a small lift and a leaf spring type suspension. Both of these components can give you a harsh ride. Consider replacing the existing lift with a long travel lift.

Should you charge golf cart after every use?

Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.

Do golf carts hold their value?

The trend right now in the golf cart market is that both new and pre-owned golf carts are worth buying. The fact that a cart is a few years old doesn't depreciate its value. Although, like every consumer product, there will be differences in the cost of used and brand new products.

Is a lifted golf cart better?

Higher Speed A lifted golf car usually means larger tires. These tires offer a higher level of speed than regular tires do. The difference in speed varies from a few miles per hour to 20 mph. Speed may not be necessarily beneficial from a safety standpoint, but it allows you to drive faster.

Can I put bigger tires on my golf cart?

Lifted golf carts can fit ANY 8” tire, low profile OR high profile. In addition, lifted golf carts can fit any high profile tire measuring at 10”, 12” or 14”. Lifted carts will be able to take 20", 22", 23" and in some cases 24" all terrain tires.

Why is my golf cart leaning?

Why is My Golf Car Leaning to One Side? A golf cart may be leaning to one side because of a bent spring, a cracked frame or simply from only one person riding the cart for years at a time. In most of the cases, the cart might be leaning heavily in the front or the back.

How can I make my golf cart go smooth?

How to Make a Golf Cart Ride SmootherCorrect Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...

What PSI should golf cart tires be?

15 to 25 pounds per square inchThese tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.

How can I make my golf cart more stable?

Drop Spindle kits are used to replace and increase the golf cart spindle size and length. This can give your golf cart a wider stance, and increase the stability. The wider stance is perfect for those looking to fit those big off-set wheels on your cart, which in turn, can allow you to add wider and taller tires.

Strut is leaking oil or shows physical damage

Most of the time if a strut is going bad it is because a seal holding the fluid (usually oil) in the shock starts to get old and starts to let the oil escape. This can often be discovered by a simple inspection of the shock. If it appears to be oily, wet or caked with dust and dirt, it is likely that the shock is leaking and needs to be replaced.

Golf cart is experiencing excessive body roll

Excessive body rolling is another indication of a strut going bad. This test can be performed by driving the golf car then turning the steering wheel so that the golf cart is tracing out an “S” pattern.

Bonus tip

If none of these tests or inspections reveal that your shock is bad, you may want to inspect the shock bushings. These are the rubber or plastic bushings at the ends of the shocks and also found where the leaf springs are bolted to the spring plates or brackets.

How to tell if a cart spring has collapsed?

To identify if the springs have collapsed you can take a ruler and measure the springs on both sides. If one side has a longer length than the other side you will know that it has collapsed.

Why does my cart lean towards the right?

Another possibility is that the cantilever on the rear side could have broken or rusted out. This can cause the cart to lean towards the right side. Also, check the springs under the driver’s seat for any damage or bent edges. If they appear bent, replace them with a new one of the same size.

What happens if a golf cart is damaged?

If any of them are damaged, the cart may lean towards one side. The shock absorbers present under the frame could be broken or damaged. You will have to lift the cart to view this. If it appears that these components are broken, simply replacing them will solve the issue.

Why is my golf cart leaning to one side?

Why is My Golf Car Leaning to One Side? A golf cart may be leaning to one side because of a bent spring, a cracked frame or simply from only one person riding the cart for years at a time. In most of the cases, the cart might be leaning heavily in the front or the back. This means that if you look at your cart from the front you might notice ...

How to check if a cart retainer is broken?

Check for a broken retainer on the leaning side. If the retainer is broken, the cart will not be able to balance correctly. You can swap the shock absorbers from the rear to the front or vice-versa. This will help you to figure out if the shocks are causing the lean.

Does Yamaha G16 have a lean?

If your Yamaha golf cart is creating troubles after being put to good use for years, worry not. A lot of Yamaha golf cart users have complained of a slight lean in their carts after some years of usage . This is especially true of the Yamaha G16 models.

Why is Your Golf Cart Pulling in One Direction?

If when you release the wheel, your golf cart drifts in one direction, or your golf cart steering pulls to one side, it’s likely one or more components in the following systems is the culprit:

Diagnosing Why Your Golf Cart Pulls in One Direction

Whether your cart is pulling to the left or the right, the following visual checks can help you determine why.

How to Fix a Drifting Golf Cart

There are some great resources online to help you diagnose and fix issues involved with golf cart directional pull. This table includes a section for addressing EZGO golf cart suspension and steering issues.

How to Prevent a Golf Cart from Pulling in One Direction

Especially if you use your cart off-road, being proactive about maintenance will save you time and money in the long run. The following table focuses on maintenance for steering and suspension, which are the primary systems involved if your cart pulls to the left or right:

In Summary

If your golf cart steering pulls to the right or the left, then determining the causes and fixing it will ensure your safety and minimize wear and tear on the components involved.

Why do golf carts need lift kits?

Golf Cart owners are turning to lift kits. There are many reasons to buy a lift kit including the fact that they turn a buggy-looking golf cart into something that looks more like a roadster. Just the tires alone give extra height to the cart, but the fancy, new tires create another problem, which is that they shrink the clearance between ...

What is the habitat of a golf cart?

For many decades the natural habitat of the golf cart was almost any climate from the equator to the arctic circle so long as the terrain was mostly grassy, rolling hills with a few meandering paths that wandered from one relatively flat space to another usually in groupings of nine or eighteen. The relatively flat spaces had very short grass ...

How much does a lift kit cost without tires?

One reason to stop is money, of course. A lift kit without new tires can run from $100 to $400, but it is not wise to go cheap on such a project. You don’t want taller and weaker. You want a solid job if you do this at all.

Is golf cart invasive?

But the golf cart, like many other invasive species, had no natural predator to worry about and thus began a sure-footed expansion into residential communities, backcountry areas, farms, beaches, you name it. As such, while the golf cart was perfectly adapted for the game of golf, the species had to adapt to fit other types ...

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9