If the golf cart won't start, then on the inside of the service panel read to see where the electrical start fuse is and pull it out. Step 3 Pinch the fuse with your fingers and pull it straight out. Sometimes on the inside service panel there are plastic pliers to help you pull the fuse.
Full Answer
Where are the fuses located on a Yamaha golf cart?
Yamaha Golf Cart Fuse Box Location The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
Do Yamaha golf carts have fuses?
Fuse Box Location on Yamaha Carts Yamaha typically places the fuses on its golf carts in the same location for each model. This choice is designed to create a uniform style between each of these models that makes it easier to work on them without running into any complications.
Is there a fuse in an electric golf cart?
Yes, golf carts contain fuses just like those found in a car or truck.
Where is the reset button on Yamaha electric golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Why does my electric golf cart have no power?
The main reason why a EZGO golf cart can lose power is because the battery is not charging due to loose cables or the corrosion of the connecting terminals. If they become loose or some of the electrical circuits' connecting wires snap, the battery loses power.
Where is the fuse box?
Fuse boxes are commonly found in utility rooms, porches or under-the-stairs cupboards. You may also have one in your hallway or garage. Wherever your fuse board is located, you must have easy access to it.
Do all golf carts have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How do I reset my Yamaha golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
How do I reset my golf cart?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you fix a golf cart that won't start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Where is the fuse box on a 2014 Yamaha Golf Cart?
The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver’s side of the cart. They’re round in shape and made of glass.
Where is the fuse panel on a 1990 golf cart?
In 1990 Marathon golf carts the fuse panel is situated behind rubber air intake bellows on the inner body on the passenger side where it’s fitted to the carburetor. In a 1997 Club Car, the fuse is located in the electrical components black box that is present near the battery.
Why push a golf cart fuse in straight?
It’s important to push the fuse in straight as far as it will go to avoid the possibility of a weak connection that results in the fuse blowing up again. If the fuse tends to blow repeatedly, the golf cart has a major problem with its electrical system. It’s recommended having a professional inspect your golf cart.
What happens when you change the starter on a golf cart?
When the starter is changed, the fuse of the golf cart will stop blowing up. Alternatively, the starter generator wire tends to vibrate and eventually blow out the fuse after grounding. The solenoid tends to click on and off at a very fast rate repeatedly when the pedal is deactivated.
What is the fuse on a 2008 EZ Go TXT?
The 2008 EZ-GO TXT golf cart uses an inline fuse with a small wire going to the key switch. This wire is present at the point where the big wire of the positive battery terminal is connected to the solenoid.
Why does my golf cart keep blowing?
A golf cart fuse can blow for many reasons such as a faulty relay switch, loose connections or a naked wire. There are some reasons why your golf cart fuse tends to keep blowing: There is a naked wire or a grounded wire. Check all connections to see if any of them have come off and connect them once again.
Why is it important to replace a fuse?
This is important because the replacing fuse must match the exact current specifications although the voltage can vary. Look out for the broken fuse. To do this, you must identify the area of the electrical system that isn’t working.
Why is my Yamaha golf cart not moving?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid. The battery has to be checked first to see if it’s delivering the right voltage while in the idle state as well as when the pedal is pressed. There can be other reasons for the Yamaha golf cart not moving though you hear the click.
What to do if your G9 golf cart is not clicking?
If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
How to check solenoid on G9 Yamaha?
The solenoid can be checked using an old screwdriver to jump the terminals. Your G9 Yamaha golf cart’s key must be in the start position. If the starter turns when you do this, your solenoid needs to be replaced. You must be careful while doing this crude test; there could be sparks when the two terminals touch.
Why do you need a wiring diagram?
A clear wiring diagram will help in ensuring that the cables are properly reconnected if you remove them for testing. In the solenoid, for example, the contacts inside can get jammed over a period. These have to be checked, cleaned, and re-fixed. If it still doesn’t work it has to be replaced.
Why does my golf cart have a fuse that is not pushed?
A fuse not pushed in all the way causes a weak connection and the possibility of the fuse blowing again. Routine maintenance can prevent a small issue like a blown fuse from becoming a major electrical problem. If the fuse continues to blow, there is a serious problem with the electrical system of the golf cart.
What does a blown fuse mean on a golf cart?
Many hardware stores carry fuses that are compatible with those in a golf cart. A blown fuse can also mean there is an electrical problem. A blown fuse requires a thorough examination of the circuit system to locate the problem.
What happens if a golf cart won't start?
If the golf cart won't start, then on the inside of the service panel read to see where the electrical start fuse is and pull it out.
What are some examples of fuse levels?
Most fuses have white numbers stamped on the face of the fuse to tell you the type of fuse. Examples of level of current stamps on a fuse are 5A, 10A and 15A.
Do golf carts need fuses?
Golf carts serve a greater need than just driving on the golf course. As more drivers select golf carts as their preferred method for quick transportation, understanding how to make simple repairs, like changing a blown fuse, becomes necessary. Many hardware stores carry fuses that are compatible with those in a golf cart.
