How can I speed up my Yamaha gas golf cart?
You can speed up your Yamaha gas golf cart with a number of simple tweaks. Power clean your cart using a hose, water and soap. Be sure to remove any excess dirt and grime from the wheels and wheel wells to allow your cart to operate at its most efficient. Remove any unnecessary accessories from the cart to lighten the cart's weight.
Why is my Yamaha golf cart smoking?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why is there oil in the airbox of my Yamaha golf cart?
If that’s the case then you need to rebuild your engine to replace the rings and fix the problem. Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine.
Why does my Yamaha golf cart controller get too hot?
The primary reason why a Yamaha golf cart controller gets too hot is because of overuse. When the golf cart is used for long periods of time, the controller can start overheating. The driving surface might also be a cause of heating. If driving on a straight and soft surface, the problem of heating should not occur.
Can a golf cart shock you?
Shocks and struts will sometimes need to be replaced on a golf cart. This is not a common occurrence, but it does happen after many years of use.
What causes a golf cart to jerk?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking.
Why does my Yamaha golf cart ride so rough?
Your Yamaha golf cart rides rough because of a small lift and a leaf spring type suspension. Both of these components can give you a harsh ride. Consider replacing the existing lift with a long travel lift. Similarly, it's a good idea to use a long travel A-arm in place of the leaf spring suspension.
How do you know if you have a bad solenoid on a golf cart?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
What causes a gas golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
Why does my gas golf cart hesitation?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt.
How do you know when your golf cart needs new shocks?
Is your cart extra noisy when going over bumps or even when driving around gently? Chances are your suspension parts are getting old. Golf cart shocks, struts, coil-over suspension and leaf spring parts fade out over time due to use and age.
How can I make my golf cart more stable?
Drop Spindle kits are used to replace and increase the golf cart spindle size and length. This can give your golf cart a wider stance, and increase the stability. The wider stance is perfect for those looking to fit those big off-set wheels on your cart, which in turn, can allow you to add wider and taller tires.
What PSI should my golf cart tires be at?
15 to 25 pounds per square inchThese tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
How do you test a Yamaha solenoid on a golf cart?
Turn on the engine of the cart and press the pedal downwards. If you hear a clicking sound, then it means that the low side voltage is working. But, if there is no such sound, it means that either there is no low side voltage or there is a problem with the solenoid. Use a voltmeter and engage the solenoid.
Do gas golf carts have solenoids?
Every golf cart, regardless of whether it is gas or electric, uses a small but powerful device called a solenoid. Solenoids are constantly working in your golf cart, and are what allows the electrical current from your battery to provide power to the rest of the vehicle.
Where is the solenoid located on a Yamaha golf cart?
1:0011:27Yamaha G29 Golf Cart Solenoid Replacement - YouTubeYouTubeStart of suggested clipEnd of suggested clipComing down to here under the seat and there's two little fasteners here and you just pop them outMoreComing down to here under the seat and there's two little fasteners here and you just pop them out flat head screwdriver pull it.
Hans Pearson
With the engine running at about half power/speed, put a volt meter across the battery terminals. The meter should read somewhere around 14.5 volts. If it is below 13 volts it is definitely not charging. Consider that the battery, unless new, could also be failing.
Marvin
You may have this posted in the wrong product category.
I need to buy all three wheels for my tourtrek push cart. My car was stolen and I had detached the wheels to store the cart
You question is very vague as to what type of push cart your needing wheels for.
What could be causing my golf cart to lose power? In the morning, it barely goes up the hills. It seems to run normally at night, but when I hit the gas pedal the lights go completely out
Have the battery checked. Especially make sure they do a shunt regulator test on the cells. Sounds light a shorted cell in the battery.
Should the solenoid have increasing voltage across the main terminals, 9.0vdc to 30vdc. Master switch in tow, key switch off
My answer is I don't know regarding golf carts but generally a designer would arrange for a solenoid to be actuated by as constant a voltage as possible, especially if it is to be engaged for long periods. That is the only method to ensure consistent operation without danger of overheating.
YAMAHA OLF CART GASOLINE OPERATED CHARGED BATTERY WHENi TURN KEY ON AND TRY TO GO IT WONT MOVE AND A SLIGHT WHINE
Check the starter solenoid, but sounds like the starter is bad. If it is draining the battery when you try to start it, then it is the starter. Check for a bad ground first though. The starte requires a great deal of amperage and a weak ground could be the problem.
1982 e-z go electric golf cart needteck sheet
I have a 96 EZ GO gas golf cart with loose steering. What parts are normally needed to correct this problem and are special tools required for me to replace the parts.
Why is my Yamaha golf cart controller so hot?
The primary reason why a Yamaha golf cart controller gets too hot is because of overuse. When the golf cart is used for long periods of time, the controller can start overheating. The driving surface might also be a cause of heating. If driving on a straight and soft surface, the problem of heating should not occur.
Why is it important to troubleshoot a golf cart controller?
Troubleshooting the controller is extremely important for the golf cart’s smooth functioning. Generally, controllers face major issues only when there is a problem with wires or defects on the controller itself, such as marks or cracks.
What to do if your golf cart controller does not increase?
If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead. If dead, replace them. Examine the controller, as discussed in the previous sections. Remember to always consult a mechanic to have your golf cart controller repaired.
What are the problems with a Yamaha G22?
Yamaha G22 also faces similar problems like G9 and G16. Overheating, battery faults, wiring issues, voltage issues are some problems that might occur with your Yamaha G22. To avoid these problems, test the golf cart’s major components connected to the controller regularly.
How to test Yamaha G16?
To test the Yamaha g16’s speed controller, check the voltage reading while pressing the accelerator. Test other components such as the batteries, the charger, and the solenoid for their smooth functioning. If any of these components do not work as expected, then you need to replace them.
How to troubleshoot a G9 controller?
Here are some easy steps for troubleshooting the G9 controller: Check the controller’s body to locate any major defects such as cracks, scratches, or black marks. If these are found, then replace the controller immediately. If no major defects are found, then check the wiring.
Why is my golf cart not heating?
If driving on a straight and soft surface, the problem of heating should not occur. But, if driven on uneven or steep surfaces , there are chances of heating. Another reason could be the brakes. It is essential to check if the brakes are dragging while the golf cart controller is driven.
How to speed up a Yamaha golf cart?
You can speed up your Yamaha gas golf cart with a number of simple tweaks. Power clean your cart using a hose, water and soap. Be sure to remove any excess dirt and grime from the wheels and wheel wells to allow your cart to operate at its most efficient. Remove any unnecessary accessories from the cart to lighten the cart's weight.
How fast can a Yamaha golf cart go?
While these vehicles are often restricted to around 10 to 15 miles per hour by factory standards and settings, you can speed up your cart in a variety of ways to have it moving as fast as 20 to 25 miles per hour.
How to remove speed restriction on a golf cart?
Open the seat of your cart to access the engine underneath. Push the governor toward the carburetor to remove this speed restriction. The governor is a T-shaped metal rod that you will find fastened with a rubber band or duct tape toward the cylinders of the carburetor.
Why does my Yamaha golf cart smoke?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why is there oil in my Yamaha golf cart?
Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine. To fix this, drain out all the oil in your engine then fill in exactly one quart of oil.
Why does my Yamaha G16 burn oil?
Your Yamaha G16 is burning oil because it has fuel in the oil. The first thing you should try to fix the burning oil problem is replace the old oil in your cart with exactly one quart of high quality oil. Hopefully this immediately fixes your problem. If your oil is overfull then your G16 will burn oil.
Why is my G16 oil overfilled?
Your oil being overfull might be because you lifted your cart which causes your oil dipstick reading to be off (the full mark is incorrect). This causes you to overfill your oil. If your oil smells like gas and is too overfull then gas will get dumped into the crankcase of your G16 and cause smoking.
How to fix a G16 engine?
To fix this, take out your airbox and clean it, clean your carburetor, drain your oil and fill in exactly one quart of oil.
Why is my Yamaha G9 smoking?
Your Yamaha G9 might be smoking because your oil rings are stuck on a piston due to engine sludge buildup. If this is the case, your engine needs to be rebuilt to fix it. Your G9 might be smoking because of oil in the muffler. Run your cart hard for 30 minutes to an hour or cook your muffler in a bonfire to fix this.
How to fix a G16 airbox?
Fix this by draining your G16’s oil and then filling in exactly one quart. Clean out the excess oil in your airbox as well.